启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析

李浩; 谭建军; 朱才朝; 费文军; 孙章栋; 王红霞

doi:doi:10.19912/j.0254-0096.tynxb.2024-1785

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析

更新时间：2026-03-06

- 启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析
- 启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析
- 太阳能学报 2026年47卷第2期页码：486-497
- 作者机构：
- 作者简介：
- 基金信息：
  
  国家重点研发计划（2022YFB4201100）;国家自然科学基金（52105050）;南京市科技计划（202309009）
- DOI：doi:10.19912/j.0254-0096.tynxb.2024-1785
  中图分类号： TM614
- 网络首发：2026-03-05，
  
  纸质出版：2026-03-05
- 稿件说明：
移动端阅览
李浩, 谭建军, 朱才朝, 等. 启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析[J]. 太阳能学报, 2026,47(2):486-497.

李浩, 谭建军, 朱才朝, et al. 启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析[J]. 2026, 47(2): 486-497.
李浩, 谭建军, 朱才朝, 等. 启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析[J]. 太阳能学报, 2026,47(2):486-497. DOI： doi:10.19912/j.0254-0096.tynxb.2024-1785.

李浩, 谭建军, 朱才朝, et al. 启动阶段风电齿轮箱行星轮径向-双向推力耦合滑动轴承瞬态润滑性能分析[J]. 2026, 47(2): 486-497. DOI： doi:10.19912/j.0254-0096.tynxb.2024-1785.

摘要

考虑启动过程中行星轮动态转速与啮合载荷影响

建立6 MW风电齿轮箱行星轮径向-双向推力耦合滑动轴承5自由度摩擦动力学数值分析模型

并以齿轮箱动力学模型预先提取的行星轮滑动轴承时序载荷、转速作为滑动轴承数值模型输入

分析压力耦合边界、推力滑动轴承和轴向间隙对启动阶段径向-双向推力耦合滑动轴承润滑性能变化规律

并进行试验验证。结果表明

受行星轮动态啮合载荷影响

径向滑动轴承在启动阶段末期出现轻微粗糙峰接触

其油膜压力存在单双峰交替现象

并通过压力耦合边界造成推力滑动轴承最大油膜压力增加;双向推力滑动轴承可抑制行星轮-销轴承载方向的错位和偏心

改善界面粗糙峰接触

但同时也会增加其非承载方向错位和偏心;过小的轴向间隙会引起推力滑动轴承最大油膜压力和波动程度剧增

推力瓦瓦块均载性能下降。

Abstract

Considering the effects of dynamic rotational speed and meshing load of the planet gear during start-up

a 5-degree-of-freedom frictional dynamics model of coupled journal and bidirectional thrust bearings is established to investigate the lubrication performance during the start-up phase. The equivalent boundary conditions for the planet gear during start-up are derived from a multi-body dynamics model of the wind turbine gearbox. The impacts of pressure coupling boundaries

thrust bearings

and axial clearance on the lubrication performance of the coupled bearings are analyzed and validated through experiments. The results indicate that

under the influence of dynamic meshing load from the planet gear

the journal bearing experiences slight asperity contact at the conclusion of the start-up phase

with film pressure alternating between single and double peaks. The maximum film pressure is enhanced by the pressure coupling boundary. The bidirectional thrust bearing can mitigate misalignment and eccentricity in the load direction

while potentially increasing them in the non-load direction. Insufficient axial clearance can lead to a significant increase in maximum film pressure and fluctuation of the thrust bearing

as well as a reduction in the load balancing performance of the thrust pads.

关键词

Keywords

references

国家统计局. 中华人民共和国2024年国民经济和社会发展统计公报[J]. 中国统计, 2025(3): 4-21.

王妮妮, 马萍, 张宏立, 等. 基于多尺度深度卷积网络特征融合的滚动轴承故障诊断[J]. 太阳能学报, 2022, 43(4): 351-358.

李浩, 朱才朝, 谭建军, 等. 风电机组用滑动轴承研究现状与发展趋势[J]. 太阳能学报, 2024, 45(5): 77-85.

谭建军, 朱才朝, 宋朝省, 等. 风电机组传动链刚柔耦合动态特性分析[J]. 太阳能学报, 2020, 41(7): 341-351.

李浩, 谭建军, 朱才朝, 等. 斜齿轮啮合弯矩对风电齿轮箱行星轮滑动轴承瞬态润滑性能影响分析[J]. 中国机械工程, 2024, 35(6): 1010-1022.

HAGEMANN T, DING H H, RADTKE E, et al.Operating behavior of sliding planet gear bearings for wind turbine gearbox applications: part II: impact of structure deformation[J]. Lubricants, 2021, 9(10): 98.

GONG J Y, LIU K, ZHENG Y, et al.Thermal-elastohydrodynamic lubrication study of misaligned journal bearing in wind turbine gearbox[J]. Tribology international, 2023, 188: 108887.

PRÖLß M, SCHWARZE H, HAGEMANN T, et al. Theoretical and experimental investigations on transient Run-up procedures of journal bearings including mixed friction conditions[J]. Lubricants, 2018, 6(4): 105.

ZHANG K, CHEN Q, ZHANG Y B, et al.Numerical and experimental investigations on thermoelastic hydrodynamic performance of planetary gear sliding bearings in wind turbine gearboxes[J]. Tribology international, 2024, 191: 109081.

LUCASSEN M, DECKER T, GUZMÁN F G, et al. Simulation methodology for the identification of critical operating conditions of planetary journal bearings in wind turbines[J]. Forschung im ingenieurwesen, 2023, 87(1): 147-157.

CUI S H, GU L, WANG L Q, et al.Numerical analysis on the dynamic contact behavior of hydrodynamic journal bearings during start-up[J]. Tribology international, 2018, 121: 260-268.

MOKHTAR M O A, HOWARTH R B, DAVIES P B. The behavior of plain hydrodynamic journal bearings during starting and stopping[J]. ASLE transactions, 1977, 20(3): 183-190.

曹玉哲. 重载及启动工况下水润滑轴承多场耦合的润滑特性研究[D]. 青岛: 青岛理工大学, 2021.

WANG Z C, LIU Y, WANG Y C, et al.Influence of squeezing and interface slippage on the performance of water-lubricated tilting-pad thrust bearing during start-up and shutdown[J]. Lubrication science, 2018, 30(4): 137-148.

HENRY Y, BOUYER J, FILLON M.Experimental analysis of the hydrodynamic effect during start-up of fixed geometry thrust bearings[J]. Tribology international, 2018, 120: 299-308.

HU Y, MENG Y G.Theoretical and experimental study of transient behavior of spiral-groove thrust bearings during start-up[J]. Tribology transactions, 2020, 63(1): 154-172.

WU F L, HU Y.Theoretical investigations on tribological properties of air foil thrust bearings during start-up process[J]. Lubricants, 2023, 11(3): 94.

ZHANG C D, YU W N, ZHANG L.Dynamic characteristics of tilting-pad coupled-bearing-rotor systems considering mixed lubrication and pad wear[J]. Tribology international, 2024, 192: 109287.

KIM K, LEE M, LEE S M, et al.Optimal design and experimental verification of fluid dynamic bearings with high load capacity applied to an integrated motor propulsor in unmanned underwater vehicles[J]. Tribology international, 2017, 114: 221-233.

WANG Y S, JANE WANG Q, LIN C.A mixed-EHL analysis of effects of misalignments and elastic deformations on the performance of a coupled journal-thrust bearing system[J]. Tribology international, 2006, 39(4): 281-289.

XIANG G, WANG J X, ZHOU C D, et al.A tribo-dynamic model of coupled journal-thrust water-lubricated bearings under propeller disturbance[J]. Tribology international, 2021, 160: 107008.

YANG T Y, XIANG G, CAI J L, et al.Five-DOF nonlinear tribo-dynamic analysis for coupled bearings during start-up[J]. International journal of mechanical sciences, 2024, 269: 109068.

TANG D X, XIAO K, XIANG G, et al.On the nonlinear time-varying mixed lubrication for coupled spiral microgroove water-lubricated bearings with mass conservation cavitation[J]. Tribology international, 2024, 193: 109381.

CAI J L, XIANG G, LI S, et al.Mathematical modeling for nonlinear dynamic mixed friction behaviors of novel coupled bearing lubricated with low-viscosity fluid[J]. Physics of fluids, 2022, 34(9): 093612.

王洲, 吴淼杰, 陶友瑞. 风电齿轮箱滑动轴承润滑性能及可靠性分析[J]. 润滑与密封, 2024, 49(9): 171-177.

曹玉哲, 梁鹏, 郭峰, 等. 长径比对重载工况水润滑轴承性能的影响[J]. 润滑与密封, 2021, 46(11): 60-67.

田德, 胡玥, 陶立壮. 风电齿轮箱浮动构件支撑刚度的分析与优化设计[J]. 太阳能学报, 2023, 44(4): 195-202.

FEI W J, TAN J J, LI H, et al.Influences of planet gear journal bearing on dynamic characteristics of megawatt-scale wind turbine drivetrains: simulations and experiments[J]. Mechanical systems and signal processing, 2024, 221: 111747.

田德, 陶立壮, 吴晓璇, 等. 基于正交设计的大型海上风电齿轮箱多级螺旋角优选研究[J]. 太阳能学报, 2022, 43(6): 153-159.

PEIXOTO T F, CAVALCA K L.Investigation on the angular displacements influence and nonlinear effects on thrust bearing dynamics[J]. Tribology international, 2019, 131: 554-566.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于改进MobileViT的风力机增速齿轮箱智能故障诊断方法

基于振动和转子电流深度融合的风电机组转频估计及故障诊断方法

基于改进MW-KECA算法的风电齿轮箱故障诊断研究

基于多目标算法优化改进谱聚类和BiLSTM-MHA的光伏功率预测

基于仿生结构的复合材料风电叶片损伤分析