EN机械应力对燃料电池微孔层传输特性影响研究
机械应力对燃料电池微孔层传输特性影响研究
- 太阳能学报 2025年46卷第6期 页码：212-218
- 作者机构：
- 作者简介：
- 基金信息：国家自然科学基金（52306270）;广东省基础与应用基础研究基金（2022A1515110456）
DOI：doi:10.19912/j.0254-0096.tynxb.2024-0230
中图分类号： TM911-
网络出版：2025-07-07，
纸质出版：2025
- 稿件说明：
移动端阅览
张恒, 邵轩宇, 王虎. 机械应力对燃料电池微孔层传输特性影响研究[J]. 太阳能学报, 2025,46(6):212-218.
张恒, 邵轩宇, 王虎. 机械应力对燃料电池微孔层传输特性影响研究[J]. 2025, 46(6): 212-218.
张恒, 邵轩宇, 王虎. 机械应力对燃料电池微孔层传输特性影响研究[J]. 太阳能学报, 2025,46(6):212-218. DOI： doi:10.19912/j.0254-0096.tynxb.2024-0230.
张恒, 邵轩宇, 王虎. 机械应力对燃料电池微孔层传输特性影响研究[J]. 2025, 46(6): 212-218. DOI： doi:10.19912/j.0254-0096.tynxb.2024-0230.
摘要
该文首先对质子交换膜燃料电池中的微孔层进行数值重构
以获得其真实的微结构;随后
采用有限元方法模拟微孔层在不同机械压缩比下的应力-应变及孔隙率和孔径分布;最后
利用孔尺度模型求解机械压缩对微孔层传输特性的影响。研究结果表明：当机械压缩比从0增至30%时
微孔层的孔隙率和孔径大小分别减小20%和45%
同时曲度、有效热导率和有效电导率分别增至初始的1.5、1.6和1.7倍。此外
当压缩比从18%增至30%时
机械压缩对有效传输特性的影响明显大于压缩比从0增至18%时
表明约 18% 的机械压缩比为微孔层的优化压缩比。
Abstract
This study first numerically reconstructs the microporous layer （MPL） in proton exchange membrane fuel cells （PEMFCs） to obtain its real microstructure. Then
the finite element method is employed to simulate the stress-strain behavior
as well as the distribution of porosity and pore size in the MPL
under different mechanical compression ratios. Finally
a pore-scale model is used to analyze the effect of mechanical compression on transport properties. The results show that as the mechanical compression ratio increases from 0 to 30%
the porosity and pore size of the MPL decrease by 20% and 45%
respectively. Meanwhile
the effective tortuosity
thermal conductivity
and electrical conductivity increase to 1.5
1.6
and 1.7 times of their uncompressed values
respectively. When the compression ratio increases from 18% to 30%
its impact on effective transport properties is significantly greater than that observed in the 0-18% range. The optimal mechanical compression ratio for the MPL is approximately 18%.
关键词
Keywords
references
JIAO K, XUAN J, DU Q, et al.Designing the next generation of proton-exchange membrane fuel cells[J]. Nature, 2021, 595(7867): 361-369.
ZHANG J J, WANG B, JIN J H, et al.A review of the microporous layer in proton exchange membrane fuel cells: materials and structural designs based on water transport mechanism[J]. Renewable and sustainable energy reviews, 2022, 156: 111998.
MEHRAZI S, SARKER M, MOJICA F, et al.A rheological approach to studying process-induced structural evolution of the microporous layer in a proton exchange membrane fuel cell[J]. Electrochimica acta, 2021, 389: 138690.
陈小松, 朱瑞杰, 宋浩, 等. 高电流密度下薄膜PEMFC自润湿特性研究[J]. 太阳能学报, 2023, 44(10): 564-571.
YIN Q N, GAO W T, ZHANG C, et al.The buffer microporous layer improved water management for proton exchange membrane fuel cell at varying humidification[J]. Journal of electroanalytical chemistry, 2023, 928: 117072.
WANG M L, HOU M, GAO Y Y, et al.Study of substrate-free microporous layer of proton exchange membrane fuel cells[J]. International journal of energy research, 2022, 46(7): 9782-9793.
王来华, 代世勋, 曹爱红. 基于实际工况的燃料电池水气传输及相变规律研究[J]. 太阳能学报, 2024, 45(3):260-268.
张恒, 詹志刚, 陈奔, 等. 基于XCT的气体扩散层传输特性孔尺度模拟[J]. 太阳能学报, 2023, 44(6): 99-105.
ZHANG H, RAHMAN M A, MOJICA F, et al.A comprehensive two-phase proton exchange membrane fuel cell model coupled with anisotropic properties and mechanical deformation of the gas diffusion layer[J]. Electrochimica acta, 2021, 382: 138273.
MOSLEMI M, JAVAHERDEH K, ASHORYNEJAD H R.Effect of compression of microporous and gas diffusion layers on liquid water transport of PEMFC with interdigitated flow field by Lattice Boltzmann method[J]. Colloids and surfaces A: physicochemical and engineering aspects, 2022, 642: 128623.
CHEN Y C, KARAGEORGIOU C, ELLER J, et al.Determination of the porosity and its heterogeneity of fuel cell microporous layers by X-ray tomographic microscopy[J]. Journal of power sources, 2022, 539: 231612.
DENG H, HOU Y Z, JIAO K.Lattice Boltzmann simulation of liquid water transport inside and at interface of gas diffusion and micro-porous layers of PEM fuel cells[J]. International journal of heat and mass transfer, 2019, 140: 1074-1090.
YU Y, CHEN S, WEI H.Numerical study on the effect of microporous layer crack changes on water management in gas diffusion layer of proton exchange membrane fuel cell[J]. International journal of heat and mass transfer, 2023, 212:124275.
EL HANNACH M, SINGH R, DJILALI N, et al.Micro-porous layer stochastic reconstruction and transport parameter determination[J]. Journal of power sources, 2015, 282: 58-64.
BECKER J, WIESER C, FELL S, et al.A multi-scale approach to material modeling of fuel cell diffusion media[J]. International journal of heat and mass transfer, 2011, 54(7-8): 1360-1368.
MOHSENINIA A, KARTOUZIAN D, EPPLER M, et al.Influence of structural modification of micro-porous layer and catalyst layer on performance and water management of PEM fuel cells: hydrophobicity and porosity[J]. Fuel cells, 2020, 20(4): 469-476.
SEPE M, SATJARITANUN P, ZENYUK I V, et al.The impact of micro porous layer on liquid water evolution inside PEMFC using lattice Boltzmann method[J]. Journal of the Electrochemical Society, 2021, 168(7): 074507.
SIM J, KANG M, MIN K, et al.Effect of capillary pressure gradient in microporous layer on proton exchange membrane fuel cell performance[J]. International journal of hydrogen energy, 2022, 47(40): 17762-17777.
XU Y M, FAN R J, CHANG G F, et al.Investigating temperature-driven water transport in cathode gas diffusion media of PEMFC with a non-isothermal, two-phase model[J]. Energy conversion and management, 2021, 248:114791.
IRA Y, BAKHSHAN Y, KHORSHIDIMALAHMADI J.Effect of wettability heterogeneity and compression on liquid water transport in gas diffusion layer coated with microporous layer of PEMFC[J]. International journal of hydrogen energy, 2021, 46(33): 17397-17413.
HOU Y Z, LI X, DU Q, et al.Pore-scale investigation of the effect of micro-porous layer on water transport in proton exchange membrane fuel cell[J]. Journal of the Electrochemical Society, 2020, 167(14): 144504.
ZHANG H, SHAO X Y, ZHAN Z G, et al.Pore-scale modeling of microporous layer for proton exchange membrane fuel cell: effective transport properties[J]. Membranes, 2023, 13(2): 219.
XIAO L S, LUO M J, ZHANG H, et al.Solid mechanics simulation of reconstructed gas diffusion layers for PEMFCs[J]. Journal of the Electrochemical Society, 2019, 166(6): F377-F385.
XU J, ZHU L J, XIAO L S, et al.A multiscale study on the effect of compression on lithium-ion battery separators[J]. Journal of energy storage, 2022, 54: 105255.
ZHU L J, ZHANG H, XIAO L S, et al.Pore-scale modeling of gas diffusion layers: Effects of compression on transport properties[J]. Journal of power sources, 2021, 496: 229822.
ZHANG H, ZHU L J, HARANDI H B, et al.Microstructure reconstruction of the gas diffusion layer and analyses of the anisotropic transport properties[J]. Energy conversion and management, 2021, 241: 114293.
MILLICHAMP J, MASON T J, NEVILLE T P, et al.Mechanisms and effects of mechanical compression and dimensional change in polymer electrolyte fuel cells-A review[J]. Journal of power sources, 2015, 284: 305-320.
MOVAHEDI M, RAMIAR A, RANJBER A A.3D numerical investigation of clamping pressure effect on the performance of proton exchange membrane fuel cell with interdigitated flow field[J]. Energy, 2018, 142: 617-632.
SHOJAEEFARD M H, MOLAEIMANESH G R, NAZEMIAN M, et al.A review on microstructure reconstruction of PEM fuel cells porous electrodes for pore scale simulation[J]. International journal of hydrogen energy, 2016, 41(44): 20276-20293.
0
浏览量
5
下载量
0
CSCD
- Meta-XML下载
- BibTeX下载
- Endnote下载
- RefMan 下载
- NoteExpress下载
- NoteFirst下载
关联资源
相关文章
相关作者
相关机构
AI问答- 技术支持由北京北大方正电子有限公司提供 京ICP备09064830号-19
京公网安备11010802024621 - 本系统建议在Chrome、 IE9+ 以上版本浏览器阅读本站内容，360浏览器请切换至极速模式
- Cookies帮助我们提供服务并提供个性化体验。使用本网站，即表示您同意我们使用Cookies