单气泡池沸腾传热中的重力效应数值模拟

赵建福; 张良; 杜王芳; 李会雄

doi:10.7638/kqdlxxb-2021.0039

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

单气泡池沸腾传热中的重力效应数值模拟

专栏——多相流研究进展及应用 | 更新时间：2026-05-28

- 单气泡池沸腾传热中的重力效应数值模拟
- Numerical simulation of gravity effect on heat transfer in single bubble pool boiling
- 空气动力学学报 2021年39卷第3期页码：121-129
- 作者机构：
  
  1. 中国科学院力学研究所微重力重点实验室,北京,100190
  2. 中国科学院大学工程科学学院,北京,100049
  3. 中国科学院力学研究所高温气体动力学国家重点实验室,北京,100190
  4. 西安交通大学动力工程多相流国家重点实验室,西安,710049
- 作者简介：
  
  赵建福*（1967-），男，河南南阳人，研究员，研究方向：微重力多相热流体动力学及其空间应用. E-mail：jfzhao@imech.ac.cn
- 基金信息：
  
  国家自然科学基金联合基金项目（U1738105）;中国载人空间站工程科学实验项目（YYWT-0601-EXP-18）
- DOI：10.7638/kqdlxxb-2021.0039
  中图分类号： O359;TK124
- 纸质出版：2021
- 稿件说明：
移动端阅览
赵建福, 张良, 杜王芳, 等. 单气泡池沸腾传热中的重力效应数值模拟[J]. 空气动力学学报, 2021, 39(3): 121−129.

ZHAO Jianfu, ZHANG Liang, DU Wangfang, et al. Numerical simulation of gravity effect on heat transfer in single bubble pool boiling[J]. 2021, 39(3): 121-129.
赵建福, 张良, 杜王芳, 等. 单气泡池沸腾传热中的重力效应数值模拟[J]. 空气动力学学报, 2021, 39(3): 121−129. DOI： 10.7638/kqdlxxb-2021.0039

ZHAO Jianfu, ZHANG Liang, DU Wangfang, et al. Numerical simulation of gravity effect on heat transfer in single bubble pool boiling[J]. 2021, 39(3): 121-129. DOI： 10.7638/kqdlxxb-2021.0039.

摘要

本文数值模拟了不同重力条件下饱和状态的FC-72在厚度5 mm的SiO

固壁上的单气泡池沸腾传热现象及相应的气泡动力学和传热性能。固壁底面给定均匀过热度10 K，其瞬态热响应被考虑在内。通过多个气泡周期的计算，得到了准稳态的沸腾过程。结果表明，在小热流密度下，气泡脱落直径

反比于重力的1/2次方，且与Fritz模型一致；气泡脱落频率

则正比于重力。传热特性存在2个明显不同的区域，即重力相关区和重力无关区，其分界位置约为0.03

：高于该临界重力时，热流密度与重力相关，恒定过热度下热流密度与重力呈确定的指数函数关系；小于该临界重力时，热流密度与重力无关。临界重力值对应于基于Laplace长度的无量纲加热器长度约2～3之间，与Raj-Kim-McQuillen重力标度模型建议的2.1相近。重力相关区标度指数随着过热度增大而单调增大，但明显大于Raj-Kim-McQuillen重力标度模型预测结果。研究结果还表明固壁瞬态热响应对重力无关区传热性能的影响比重力相关区更为明显。

Abstract

The bubble dynamics and heat transfer in single bubble pool boiling of saturated FC-72 at different gravity levels are studied numerically

having transient thermal response of the heated SiO

wall with a thickness of 5 mm. A constant and uniform temperature corresponding to a superheat of 10 K is prescribed at the bottom surface of the solid wall. Multi-cycle simulations are conducted and quasi-steady state of boiling process is achieved. It is observed that the bubble departure diameter

inv

ersely proportional to the square root of gravity

is consistent with the Fritz model

and the bubble frequency is proportional to the gravity. There are two regions with obvious differences in terms of heat transfer

namely a gravity-dependent region and a gravity-independent region. The corresponding transition or critical value of the gravity is about 0.03

. The heat flux has a power law relation with the gravity at constant superheat if the gravity is larger than the critical value

while this trend will break down when gravity is less than the critical value. The boundary between these two regions is located in the range of dimensionless heater length based on the Laplace length from 2 to 3

which is close to 2.1 proposed by Raj-Kim-McQuillen model. In the gravity related region

the exponent of the power law relation increases monotonously with the superheat

but its value is obviously larger than the prediction of Raj-Kim-McQuillen model. It is also found that the transient thermal response of the solid wall has a more obvious effect on the heat transfer performance in SDB region than in BDB region.

关键词

Keywords

references

DU W F, ZHAO J F. Gravity scaling law of heat transfer in nucleate pool boiling[J]. Chinese Science Bulletin, 2020, 65(17): 1629-1637. (in Chinese).

STRAUB J. Boiling heat transfer and bubble dynamics in microgravity[J]. Advances in Heat Transfer, 2001, 35: 57-172. doi: 10.1016/S0065-2717(01)80020-4.

RAJ R. Development of a boiling regime map and gravity scaling parameter for pool boiling heat transfer[D]. College Park: University of Maryland , 2010.

RAJ R, KIM J, MCQUILLEN J. Subcooled pool boiling in variable gravity environments[J]. Journal of Heat Transfer, 2009, 131(9): 091502. doi: 10.1115/1.3122782.

RAJ R, KIM J, MCQUILLEN J. Gravity scaling parameter for pool boiling heat transfer[J]. Journal of Heat Transfer, 2010, 132(9): 091502. doi: 10.1115/1.4001632.

RAJ R, KIM J, MCQUILLEN J. On the scaling of pool boiling heat flux with gravity and heater size[J]. Journal of Heat Transfer, 2012, 134(1): 011502. doi: 10.1115/1.4004370.

RAJ R, KIM J, MCQUILLEN J. Pool boiling heat transfer on the international space station: experimental results and model verification[J]. Journal of Heat Transfer, 2012, 134(10): 101504. doi: 10.1115/1.4006846.

WANG L, ZHU K, XIE F S, et al. Prediction of pool boiling heat transfer for hydrogen in microgravity[J]. International Journal of Heat and Mass Transfer, 2016, 94: 465-473. doi: 10.1016/j.ijheatmasstransfer.2015.11.049.

WANG X L, ZHANG Y H, QI B J, et al. Experimental study of the heater size effect on subcooled pool boiling heat transfer of FC-72 in microgravity[J]. Experimental Thermal and Fluid Science, 2016, 76: 275-286. doi: 10.1016/j.expthermflusci.2016.03.031.

MA X J, CHENG P, GONG S, et al. Mesoscale simulations of saturated pool boiling heat transfer under microgravity conditions[J]. International Journal of Heat and Mass Transfer, 2017, 114: 453-457. doi: 10.1016/j.ijheatmasstransfer.2017.06.019.

FENG Y, LI H X, GUO K K, et al. Numerical study on saturated pool boiling heat transfer in presence of a uniform electric field using lattice Boltzmann method[J]. International Journal of Heat and Mass Transfer, 2019, 135: 885-896. doi: 10.1016/j.ijheatmasstransfer.2019.01.119.

STEPHAN P, HAMMER J. A new model for nucleate boiling heat transfer[J]. Heat and Mass Transfer, 1994, 30(2): 119-125. doi: 10.1007/BF00715018.

SON G, DHIR V K, RAMANUJAPU N. Dynamics and heat transfer associated with a single bubble during nucleate boiling on a horizontal surface[J]. Journal of Heat Transfer, 1999, 121(3): 623-631. doi: 10.1115/1.2826025.

ZHAO J F, LI Z D, ZHANG L, et al. Numerical simulation of single bubble pool boiling in different gravity conditions[C ] // New Trends in Fluid Mechanics Research. Proc. 6th Int. Conf. Fluid Mech., Guangzhou, China, 2011. doi: 10.1063/1.3651978 .

YI T H, LEI Z S, ZHAO J F. Numerical investigation of bubble dynamics and heat transfer in subcooling pool boiling under low gravity[J]. International Journal of Heat and Mass Transfer, 2019, 132: 1176-1186. doi: 10.1016/j.ijheatmasstransfer.2018.12.096.

FUCHS T, KERN J, STEPHAN P. A transient nucleate boiling model including microscale effects and wall heat transfer[J]. Journal of Heat Transfer, 2006, 128(12): 1257-1265. doi: 10.1115/1.2349502.

AKTINOL E, DHIR V K. Numerical simulation of nucleate boiling phenomenon coupled with thermal response of the solid[J]. Microgravity Science and Technology, 2012, 24(4): 255-265. doi: 10.1007/s12217-012-9308-7.

ZHANG L, LI Z D, LI K, et al. Influence of heater thermal capacity on pool boiling heat transfer[J]. Journal of Computational Multiphase Flows, 2014, 6: 361–375.

ZHANG L, LI Z D, LI K, et al. Influence of heater thermal capacity on bubble dynamics and heat transfer in nucleate pool boiling[J]. Applied Thermal Engineering, 2015, 88: 118-126. doi: 10.1016/j.applthermaleng.2014.11.080.

LI Z D, ZHANG L, ZHAO J F, et al. Numerical simulation of bubble dynamics and heat transfer with transient thermal response of solid wall during pool boiling of FC-72[J]. International Journal of Heat and Mass Transfer, 2015, 84: 409-418. doi: 10.1016/j.ijheatmasstransfer.2014.12.061.

DHRUV A, BALARAS E, RIAZ A, et al. A formulation for high-fidelity simulations of pool boiling in low gravity[J]. International Journal of Multiphase Flow, 2019, 120: 103099. doi: 10.1016/j.ijmultiphaseflow.2019.103099.

ZHANG L. Study on the thermal dynamical characteristics of fluid particles in microgravity[D]. Beijing: Institute of Mechanics, Chinese Academy of Sciences, 2014.

SIEGEL R, KESHOCK E G. Effects of reduced gravity on nucleate boiling bubble dynamics in saturated water[J]. AIChE Journal, 1964, 10(4): 509-517. doi: 10.1002/aic.690100419.

HSU Y Y. On the size range of active nucleation cavities on a heating surface[J] J. Heat Transfer 1962, 84(3): 207-213. doi: /10.1115/1.3684339.

SON G. Numerical study on a sliding bubble during nucleate boiling[J]. KSME International Journal, 2001, 15(7): 931-940. doi: 10.1007/BF03185271.

FRITZ W, ENDE W. Berechnungen des Maximalvolumens von Dampfblasen[J]. Physik, Zeitschr, 36 (1935) 379–384.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

不同间距下过冷水滴连续撞击超疏水表面的数值研究

多孔介质传热模型在多孔壁湍流中的适用性

底面局部加热条件下热湍流的流场变化及传热规律

湍流热对流调制及其机理的研究现状和展望

基于LBM方法的LAGOON起落架噪声预测与降噪方法研究