水平T型管两相流流致振动实验研究

宿恒; 瞿叶高; 周劭翀; 周莹; 彭志科

doi:10.7638/kqdlxxb-2021.0033

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

水平T型管两相流流致振动实验研究

专栏——多相流研究进展及应用 | 更新时间：2026-05-28

- 水平T型管两相流流致振动实验研究
- Experimental investigation on two-phase flow induced vibration responses in a horizontal tee-pipe
- 空气动力学学报 2021年39卷第3期页码：130-137
- 作者机构：
  
  1. 上海交通大学机械与动力工程学院,上海,200240
  2. 上海核工程研究设计院有限公司,上海,200233
- 作者简介：
  
  宿恒（1994-），男，山东人，博士研究生，研究方向：管道流固耦合. E-mail：117020910081@sjtu.edu.cn
  瞿叶高*（1983-），男，山东人，副教授，博士生导师，研究方向：流固耦合动力学与控制. E-mail：quyegao@sjtu.edu.cn
- 基金信息：
  
  国家重大科技专项计划（2019ZX06004001）
- DOI：10.7638/kqdlxxb-2021.0033
  中图分类号： O353.5
- 纸质出版：2021
- 稿件说明：
移动端阅览
宿恒, 瞿叶高, 周劭翀, 等. 水平T型管两相流流致振动实验研究[J]. 空气动力学学报, 2021, 39(3): 130−137.

SU Heng, QU Yegao, ZHOU Shaochong, et al. Experimental investigation on two-phase flow induced vibration responses in a horizontal tee-pipe[J]. 2021, 39(3): 130-137.
宿恒, 瞿叶高, 周劭翀, 等. 水平T型管两相流流致振动实验研究[J]. 空气动力学学报, 2021, 39(3): 130−137. DOI： 10.7638/kqdlxxb-2021.0033

SU Heng, QU Yegao, ZHOU Shaochong, et al. Experimental investigation on two-phase flow induced vibration responses in a horizontal tee-pipe[J]. 2021, 39(3): 130-137. DOI： 10.7638/kqdlxxb-2021.0033.

摘要

以水平T型管为研究对象，开展了两相流输运管道流致振动实验，研究了T型管在气液两相流作用下的振动响应，重点考察了不同气液表观流速下段塞流对流体脉动压力和管道振动响应的影响规律。研究结果表明：T型管相分离现象主要与流体所受惯性力有关，径向及轴向分支管路相分配随气相表观流速增加趋向均匀；段塞流引起的脉动压力频段范围集中在0～15 Hz以内，压力幅值随气相表观流速的增加而增大；段塞流引起的结构振动以垂向振动为主，且振动幅值随气相表观流速增大而增大；T型管的振动与管内气塞和液塞的交替运动有关，两相流作为宽频激励主要激起管道的运行模态并以一阶振动模态为主；主管路两相流平均动量高于分支管路，主管路振动响应幅值最高，峰值频率最小；轴向分支管路由于相分离现象导致液相占比增大，流速减小，易出现因液柱堵塞引起的流体冲击现象，轴向分支管路振动响应幅值高于径向分支管路。

Abstract

Experiments are carried out to investigate the flow-induced vibration responses in a horizontal tee pipe under the excitation of gas-liquid two-phase flow. The influence of the superficial gas velocity on the pressure fluctuations and the vibration responses of the tee-pipe is investigated. The results show that the phase separation phenomenon of tee-pipe is mainly related to the fluid inertia of two-phase flow

and the phase distribution of radial and axial branches tends to be uniform with the increase of the superficial gas velocity. The frequency range of the pressure fluctuation caused by slug flow is concentrated between 0 to 15 Hz

and the pressure amplitude increases with the increase of the superficial gas velocity. The slug flow mainly causes the vertical vibration and the vibration amplitude increases with the increase of the superficial gas velocity. The vibration responses of the tee-pipe are related to the alternate movement of the gas slug and the liquid slug. The two-phase flow mainly excites the operating modes of the pipe

and the first-order vibration mode is the main mode. The vibration amplitude of the main pipe is the largest

and that of the horizontal radial direction line is the smallest

due to the fact that the average momentum of the two-phase flow in the main pipe is higher than that in the branch pipe. The flow separation leads to the proportion of liquid phase in the axial branch pipe increases

and the flow rate of the two-phase flow decreases

which induce fluid impact phenomenon. The amplitude of vibration response of the axial branch pipe is significantly higher than that of the radial branch pipe.

关键词

Keywords

references

CHENG L X, RIBATSKI G, THOME J R. Two-phase flow patterns and flow-pattern maps: fundamentals and applications[J]. Applied Mechanics Reviews, 2008, 61(5): 050802.DOI: 10.1115/1.2955990.

XI H M, ZHANG W, YAO M H. Periodic and chaotic vibration of an infusion tube with variable velocity[J]. Journal of Dynamics and Control, 2008, 6(3): 243-248. (in Chinese).

JAEGER J, SANTOS C M, ROSA L M, et al. Experimental and numerical evaluation of slugs in a vertical air-water flow[J]. International Journal of Multiphase Flow, 2018, 101: 152-166. doi: 10.1016/j.ijmultiphaseflow.2018.01.009.

DAUDE F, GALON P A. Finite-Volume approach for compressible single- and two-phase flows in flexible pipelines with fluid-structure interaction[J]. Journal of Computational Physics, 2018, 362: 375-408. doi: 10.1016/j.jcp.2018.01.055.

HARA F, YAMASHITA T. Parallel two-phase-flow-induced vibrations in fuel pin model[J]. Journal of Nuclear Science and Technology, 1978, 15(5): 346-354. doi: 10.1080/18811248.1978.9735520.

ORTIZ-VIDAL L E, MUREITHI N W, RODRIGUEZ O M H. Vibration response of a pipe subjected to two-phase flow: Analytical formulations and experiments[J]. Nuclear Engineering and Design, 2017, 313: 214-224.DOI: 10.1016/j.nucengdes.2016.12.020.

TAY B L, THORPE R B. Hydrodynamic forces acting on pipe bends in gas-liquid slug flow[J]. Chemical Engineering Research and Design, 2014, 92(5): 812-825.DOI: 10.1016/j.cherd.2013.08.012.

AL-HASHIMY Z I, AL-KAYIEM H H, TIME R W. Experimental investigation on the vibration induced by slug flow in horizontal pipe[J]. Journal of Engineering and Applied Sciences, 2016, 11(20): 12134-12139.

ZHU H J, GAO Y, ZHAO H L. Experimental investigation of slug flow-induced vibration of a flexible riser[J]. Ocean Engineering, 2019, 189: 106370. doi: 10.1016/j.oceaneng.2019.106370.

LANNES D P, GAMA A L. On the relationship between pipe accelerance and the void fraction of internal two-phase flow[J]. Journal of Fluids and Structures, 2018, 80: 350-369. doi: 10.1016/j.jfluidstructs.2018.04.005.

LIU Y, MIWA S, HIBIKI T, et al. Experimental study of internal two-phase flow induced fluctuating force on a 90° elbow[J]. Chemical Engineering Science, 2012, 76: 173-187. doi: 10.1016/j.ces.2012.04.021.

MA X X, TIAN M C, ZHANG G M, et al. Numerical simulation of gas-liquid two-phase flow induced vibration in a vertical U-tube[J]. Journal of Engineering Thermophysics, 2015, 36(10): 2221-2225. (in Chinese).

WANG S F, SHOJI M. Fluctuation characteristics of two-phase flow splitting at a vertical impacting T-junction[J]. International Journal of Multiphase Flow, 2002, 28(12): 2007-2016.DOI: 10.1016/S0301-9322(02)00104-0.

WANG D, ZHANG X G, LIN Y, et al. The split of two-phase flow at horizontal t-junctions of unequal diameters[J]. Journal of Engineering Thermophysics, 2003, 24(2): 259-261. (in Chinese).

AZZI A, AL-ATTIYAH A, QI L, et al. Gas-liquid two-phase flow division at a micro-T-junction[J]. Chemical Engineering Science, 2010, 65(13): 3986-3993. doi: 10.1016/j.ces.2010.03.037.

WANG L S, LIU L F, TIAN W X, et al. Research of phase separation phenomenon in two-phase bubbly flow in T-junction[J]. Nuclear Power Engineering, 2014, 35(2): 53-57. (in Chinese).

RIVERIN J L, DE LANGRE E, PETTIGREW M J. Fluctuating forces caused by internal two-phase flow on bends and Tees[J]. Journal of Sound and Vibration, 2006, 298(4-5): 1088-1098. doi: 10.1016/j.jsv.2006.06.039.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

交错型CPR方法的保正实现策略及其对比研究

水滴撞击运动超疏水表面特性及其调控

基于Ac-准则的最优输入设计方法

个体间距对多扑翼气动噪声的影响特性

基于LBM方法的LAGOON起落架噪声预测与降噪方法研究