基于波动电源的PEMWE动态响应实验研究

曾庆辉; 杨晓宏; 刘芷彤; 吉锋; 苑帆航; 晋源

doi:10.19912/j.0254-0096.tynxb.2024-2389

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

基于波动电源的PEMWE动态响应实验研究

更新时间：2026-07-21

- 基于波动电源的PEMWE动态响应实验研究
- 基于波动电源的PEMWE动态响应实验研究
- 太阳能学报 2026年47卷第5期页码：579-587
- 作者机构：
- 作者简介：
- 基金信息：
  
  内蒙古自治区高等学校创新团队发展计划支持-可再生能源电解水制氢协同优化创新团队（NMGIRT2309);内蒙古自治区自然科学基金（2023MS05014）;内蒙古科学技术研究院产业技术创新项目（2023JSYD01001）;“科技兴蒙”行动重点专项-呼和浩特创建国家自主创新示范区项目（2024-重大创新平台基地建设项目-11）
- DOI：10.19912/j.0254-0096.tynxb.2024-2389
  中图分类号： TQ116
- 网络首发：2026-06-04，
  
  纸质出版：2026
- 稿件说明：
移动端阅览
曾庆辉, 杨晓宏, 刘芷彤, 等. 基于波动电源的PEMWE动态响应实验研究[J]. 太阳能学报, 2026,47(5):579-587.

曾庆辉, 杨晓宏, 刘芷彤, et al. 基于波动电源的PEMWE动态响应实验研究[J]. 2026, 47(5): 579-587.
曾庆辉, 杨晓宏, 刘芷彤, 等. 基于波动电源的PEMWE动态响应实验研究[J]. 太阳能学报, 2026,47(5):579-587. DOI： 10.19912/j.0254-0096.tynxb.2024-2389.

曾庆辉, 杨晓宏, 刘芷彤, et al. 基于波动电源的PEMWE动态响应实验研究[J]. 2026, 47(5): 579-587. DOI： 10.19912/j.0254-0096.tynxb.2024-2389.

摘要

通过搭建的质子交换膜电解槽（PEMWE）实验系统

系统研究电流启动、停止、阶跃加载和减载4组波动电源工况下

进水温度和进水流量对电压、温度和能效的响应特性。结果表明：电源加载过程中

电压和回水温度对电流变化表现出相似的过调响应;提高加载电流增大电压和温度过调

降低水流量和提高水温度可有效缓解电压、温度和能源效率的波动。进水温度80 ℃、水流量60 mL/min、加载电流2 A工况下

测试电解槽波动较小。建议减小电流突变值

提高进水温度和降低进水流量以维持小型百瓦级电解槽稳定运行。

Abstract

In this study

an experimental PEMWE system was developed to systematically investigate four representative dynamic operating conditions： start-up

shut-down

step-loading

and unloading. Particular attention was given to the effects of inlet water temperature and inlet water flow rate on voltage response

temperature evolution

and energy efficiency under these transient conditions. The results indicate that during the loading process

both the cell voltage and outlet water temperature exhibit pronounced overshoot behavior in response to rapid current changes. Increasing the loading current intensifies these fluctuations. In contrast

reducing the inlet water flow rate and increasing the inlet water temperature effectively mitigate voltage

temperature

and energy efficiency fluctuations. The test electrolyzer demonstrates the smallest dynamic deviations at an inlet water temperature of 80 ℃

a flow rate of 60 mL/min

and a loading current of 2 A. For stable operation of small-scale （hundred-watt-level） PEMWE under dynamic power input

it is recommended to minimize abrupt current variations

increase the inlet water temperature

and appropriately reduce the water flow rate.

关键词

Keywords

references

李丽旻, 我国可再生能源支撑力量稳步提升[N]. 中国能源报, 2026-04-13(1).

CHO H H, STREZOV V, EVANS T J.A review on global warming potential, challenges and opportunities of renewable hydrogen production technologies[J]. Sustainable materials and technologies, 2023, 35: e00567.

丁历威, 彭笑东, 侯继彪, 等. 风光波动电源下质子交换膜电解水制氢技术发展与应用[J]. 中国工程科学, 2023, 25(6): 237-247.

张正, 宋凌珺. 电解水制氢技术: 进展、挑战与未来展望[J]. 工程科学学报, 2025, 47(2): 282-295.

SUN M J, ZHANG Y M, LIU L Y, et al.Dynamic performance analysis of hydrogen production and hot standby dual-mode system via proton exchange membrane electrolyzer and phase change material-based heat storage[J]. Applied energy, 2025, 377: 124636.

施正荣, 翁楚, 蔡靖雍, 等. 基于PV/T的质子交换膜电解制氢系统动态性能研究[J]. 太阳能学报, 2023, 44(8): 164-170.

刘柯壮. 光伏发电直接耦合PEM电解水制氢系统性能研究[D]. 西安: 西安理工大学, 2023.

舒展宏, 陈蕊, 宋浩, 等. 质子交换膜电解池二维两相流综合模拟研究[J]. 太阳能学报, 2023, 44(11): 450-458.

WANG W T, LI J, DING L, et al.3D multiphysics modeling for probing the non-homogenous parameter distribution in proton exchange membrane electrolyzer cells[J]. Energy conversion and management, 2025, 324: 119222.

HE D D, CHEN K, CHEN W S, et al.Numerical study on dynamic response characteristics of proton exchange membrane water electrolyzer under transient loading[J]. International journal of hydrogen energy, 2024, 93: 845-865.

SAYED-AHMED H, TOLDY Á I, SANTASALO-AARNIO A.Dynamic operation of proton exchange membrane electrolyzers: critical review[J]. Renewable and sustainable energy reviews, 2024, 189: 113883.

ZHANG X Y, WANG B W, XU Y F, et al.Effects of different loading strategies on the dynamic response and multi-physics fields distribution of PEMEC stack[J]. Fuel, 2023, 332: 126090.

ZHAO D Q, HE Q J, YU J, et al.Dynamic behaviour and control strategy of high temperature proton exchange membrane electrolyzer cells (HT-PEMECs) for hydrogen production[J]. International journal of hydrogen energy, 2020, 45(51): 26613-26622.

GUILBERT D, ZASADZINSKI M, RAFARALAHY H, et al.Modeling of the dynamic behavior of a PEM electrolyzer[C]//2022 10th International Conference on Systems and Control (ICSC). Marseille, France, 2023: 78-84.

HE M Z, NIE G Z, YANG H R, et al.A generic equivalent circuit model for PEM electrolyzer with multi-timescale and stages under multi-mode control[J]. Applied energy, 2024, 359: 122728.

CHEN Z C, YIN L K, WANG Z M, et al.Numerical simulation of parameter change in a proton exchange membrane electrolysis cell based on a dynamic model[J]. International journal of energy research, 2022, 46(15): 24074-24090.

DANG J, YANG F Y, LI Y Y, et al.Transient behaviors and mathematical model of proton exchange membrane electrolyzer[J]. Journal of power sources, 2022, 542: 231757.

HERNÁNDEZ-GÓMEZ Á, RAMIREZ V, GUILBERT D, et al. Development of an adaptive static-dynamic electrical model based on input electrical energy for PEM water electrolysis[J]. International journal of hydrogen energy, 2020, 45(38): 18817-18830.

HERNÁNDEZ-GÓMEZ Á, RAMIREZ V, GUILBERT D, et al. Cell voltage static-dynamic modeling of a PEM electrolyzer based on adaptive parameters: development and experimental validation[J]. Renewable energy, 2021, 163: 1508-1522.

MAYA J C, CHEJNE F, GÓMEZ C A, et al. Analysys of the performance a PEM-type electrolyzer in variable energy supply conditions[J]. Chemical engineering research and design, 2023, 196: 526-541.

GONG J D, SUN C, SHI H G, et al.Response behaviour of proton exchange membrane water electrolysis to hydrogen production under dynamic conditions[J]. International journal of hydrogen energy, 2023, 48(79): 30642-30652.

WANG K C, FENG Y C, XIAO F, et al.operando analysis of through-plane interlayer temperatures in the PEM electrolyzer cell under various operating conditions[J]. Applied energy, 2023, 348: 121588.

WANG K C, XU C, XIAO F, et al.operando analysis of in-plane heterogeneity for the PEM electrolyzer cell: mappings of temperature and current density[J]. Journal of cleaner production, 2024, 436: 140586.

IMMERZ C, BENSMANN B, TRINKE P, et al.Understanding electrical under-and overshoots in proton exchange membrane water electrolysis cells[J]. Journal of the Electrochemical Society, 2019, 166(15): F1200-F1208.

RAULS E, HEHEMANN M, KELLER R, et al.Favorable start-up behavior of polymer electrolyte membrane water electrolyzers[J]. Applied energy, 2023, 330: 120350.

ZHANG T Y, WANG K C, XIAO F, et al.Measurement and simulation of voltage differences under ribs and channels and temperature variations within channels in PEMEC[J]. Renewable energy, 2024, 223: 119949.

SHAHRIL A A D, MASDAR M S, MAJLAN E H, et al. A review on mode conversion: dynamic response of unitised regenerative proton exchange membrane fuel cell[J]. International journal of hydrogen energy, 2024, 50: 91-103.

CHEN W S, MENG K, ZHOU H R, et al.Water-gas two-phase transport behavior and purge strategy optimization during mode-switching of unitized regenerative proton exchange membrane fuel cell[J]. Energy conversion and management, 2023, 298: 117749.

ZHANG K X, LIANG X, WANG L N, et al.Status and perspectives of key materials for PEM electrolyzer[J]. Nano research energy, 2022, 1: e9120032.

HASSAN A H, WANG X Y, LIAO Z R, et al.Numerical investigation on the effects of design parameters and operating conditions on the electrochemical performance of proton exchange membrane water electrolysis[J]. Journal of thermal science, 2023, 32(6): 1989-2007.

ZHANG T Y, CAO Y P, ZHANG Y P, et al.Relationship of local current and two-phase flow in proton exchange membrane electrolyzer cells[J]. Journal of power sources, 2022, 542: 231742.

SU X, XU L J, HU B.Simulation of proton exchange membrane electrolyzer: influence of bubble covering[J]. International journal of hydrogen energy, 2022, 47(46): 20027-20039.

XU B S, YANG Y, LI J, et al.Computational assessment of response to fluctuating load of renewable energy in proton exchange membrane water electrolyzer[J]. Renewable energy, 2024, 232: 121084.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

可再生能源电解制氢宽范围运行控制策略

太阳能辐射数据驱动下光电催化与光伏电解协同制氢的地区适应性分析

基于生物柴油重整的燃料电池发电系统性能研究

基于改进APO-SVMD的海上风电场混合储能容量配置

不同坡度地形下光伏组件风荷载特性研究