温度与相对湿度对PEMFC输出性能及膜含水量的影响

耿莉敏; 山世玉; 黄飞创; 黄东; 陈昊; 赵卫艳

doi:10.19912/j.0254-0096.tynxb.2024-2272

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

温度与相对湿度对PEMFC输出性能及膜含水量的影响

更新时间：2026-07-21

- 温度与相对湿度对PEMFC输出性能及膜含水量的影响
- 温度与相对湿度对PEMFC输出性能及膜含水量的影响
- 太阳能学报 2026年47卷第5期页码：542-550
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：10.19912/j.0254-0096.tynxb.2024-2272
  中图分类号： TK91
- 网络首发：2026-06-04，
  
  纸质出版：2026
- 稿件说明：
移动端阅览
耿莉敏, 山世玉, 黄飞创, 等. 温度与相对湿度对PEMFC输出性能及膜含水量的影响[J]. 太阳能学报, 2026,47(5):542-550.

耿莉敏, 山世玉, 黄飞创, et al. 温度与相对湿度对PEMFC输出性能及膜含水量的影响[J]. 2026, 47(5): 542-550.
耿莉敏, 山世玉, 黄飞创, 等. 温度与相对湿度对PEMFC输出性能及膜含水量的影响[J]. 太阳能学报, 2026,47(5):542-550. DOI： 10.19912/j.0254-0096.tynxb.2024-2272.

耿莉敏, 山世玉, 黄飞创, et al. 温度与相对湿度对PEMFC输出性能及膜含水量的影响[J]. 2026, 47(5): 542-550. DOI： 10.19912/j.0254-0096.tynxb.2024-2272.

摘要

建立三蛇形流场质子交换膜燃料电池（PEMFC）仿真模型

研究不同温度（25~95 ℃）和相对湿度（20%~100%）下PEMFC的极化曲线、膜含水量和膜水分布情况

并基于敏感性分析法

研究高温低湿和低温高湿状态下PEMFC输出性能与膜含水量的敏感度指标

为PEMFC的性能优化提供参考。结果表明：1）温度变化时

65 ℃条件下电压损耗最小;高电位阶段

温度越高

膜含水量越低;低电位阶段

温度越高

膜含水量越高。2）相对湿度变化时

80%相对湿度（RH）条件下电压损耗最小;相对湿度越高

膜含水量越大且分布更均匀。3）在高温低湿与低温高湿状态下

PEMFC输出性能和膜含水量对温度的变化更为敏感。

Abstract

This research established a simulation model of three-serpentine flow field PEMFC

and studied the polarization curve

membrane water content and membrane water distribution of PEMFC under different temperatures （25-95 ℃） and relative humidity （20%-100%）. Based on sensitivity analysis

the sensitivity indexes of output performance and membrane water content of PEMFC under high temperature & low humidity and low temperature & high humidity are studied

which can provide reference for performance optimization of PEMFC. The results indicate that： 1） In temperature variations

the voltage loss is minimized at 65 °C; at higher voltage regions

the membrane water content decreases with increasing temperature

whereas at lower voltage regions

the membrane water content increases with temperature. 2） In relative humidity variations

the voltage loss is minimized at 80% RH; higher relative humidity results in higher membrane water content and a more uniform distribution. 3） The output performance and membrane water content of PEMFC are more sensitive to changes in temperature under the condition of high temperature & low humidity and low temperature & high humidity.

关键词

Keywords

references

陈文淼, 凌文. 中国氢能交通发展关键问题与对策建议[J]. 前瞻科技, 2024, 3(4): 58-68.

MENSOU S, ESSADKI A, NASSER T, et al.A direct power control of a DFIG based-WECS during symmetrical voltage dips[J]. Protection and control of modern power systems, 2020, 5(1): 5.

王克文, 张晓平, 周厚庆, 等. 基于混合动力的氢燃料电池轨道车辆研究概述[J]. 太阳能学报, 2024, 45(9): 50-59.

REDDY K J, SUDHAKAR N.ANFIS-MPPT control algorithm for a PEMFC system used in electric vehicle applications[J]. International journal of hydrogen energy, 2019, 44(29): 15355-15369.

刘应都, 郭红霞, 欧阳晓平. 氢燃料电池技术发展现状及未来展望[J]. 中国工程科学, 2021, 23(4): 162-171.

CHUGH S, CHAUDHARI C, SONKAR K, et al.Experimental and modelling studies of low temperature PEMFC performance[J]. International journal of hydrogen energy, 2020, 45(15): 8866-8874.

陶丽蓉, 刘煜, 孔红兵, 等. 质子交换膜燃料电池整车辅助散热系统设计建模及分析[J]. 太阳能学报, 2023, 44(4): 299-305.

KIM J, KIM J.Effect of gas diffusion layer compression and inlet relative humidity on PEMFC performance[J]. Applied chemistry for engineering, 2021, 32(1): 68-74.

王翠表, 孙峰, 苏丹丹, 等. 质子交换膜燃料电池直流道内液滴传输研究[J]. 太阳能学报, 2024, 45(10): 61-67.

马睿, 党翰斌, 张钰奇, 等. 质子交换膜燃料电池系统故障机理分析及诊断方法研究综述[J]. 中国电机工程学报, 2024, 44(1): 407-427.

程思亮. 质子交换膜燃料电池温度控制研究[D]. 北京: 清华大学, 2017.

KIM S, HONG I.Effects of humidity and temperature on a proton exchange membrane fuel cell (PEMFC) stack[J]. Journal of industrial and engineering chemistry, 2008, 14(3): 357-364.

SHAN Y Y, CHOE S Y.Modeling and simulation of a PEM fuel cell stack considering temperature effects[J]. Journal of power sources, 2006, 158(1): 274-286.

SAHRAOUI M, BICHIOUI Y, HALOUANI K.Three-dimensional modeling of water transport in PEMFC[J]. International journal of hydrogen energy, 2013, 38(20): 8524-8531.

TAKALLOO P K, NIA E S, GHAZIKHANI M.Numerical and experimental investigation on effects of inlet humidity and fuel flow rate and oxidant on the performance on polymer fuel cell[J]. Energy conversion and management, 2016, 114: 290-302.

彭跃进, 张国瑞, 王勇, 等. 阴、阳极加湿对质子交换膜燃料电池性能影响的差异性[J]. 电工技术学报, 2017, 32(4): 196-203.

JIAO K, LI X.A three-dimensional non-isothermal model of high temperature proton exchange membrane fuel cells with phosphoric acid doped polybenzimidazole membranes[J]. Fuel cells, 2010, 10(3): 351-362.

纪少波, 马荣泽, 赵同军, 等. 质子交换膜燃料电池运行参数影响规律研究[J]. 汽车安全与节能学报, 2021, 12(2): 251-256.

DONG Z Z, LIU Y W, QIN Y Z.Coupled FEM and CFD modeling of structure deformation and performance of PEMFC considering the effects of membrane water content[J]. Energies, 2022, 15(15): 5319.

陆佳斌, 申欣明, 陈明, 等. 阴极湿度与电流密度对PEMFC性能的协同影响[J]. 电源技术, 2021, 45(8): 1018-1022.

GE S H, YI B L, MING P W.Experimental determination of electro-osmotic drag coefficient in nafion membrane for fuel cells[J]. Journal of the Electrochemical Society, 2006, 153(8): A1443.

CARNES B, SPERNJAK D, LUO G, et al.Validation of a two-phase multidimensional polymer electrolyte membrane fuel cell computational model using current distribution measurements[J]. Journal of power sources, 2013, 236: 126-137.

WEI G H, LU J B, ZHANG Q L, et al.Analyze the effects of flow mode and humidity on PEMFC performance by equivalent membrane conductivity[J]. International journal of energy research, 2019, 43(9): 4592-4605.

HAO H M, MO R J, KANG S Y, et al.Effects of temperature, inlet gas pressure and humidity on PEM water contents and current density distribution[J]. Results in engineering, 2023, 20: 101411.

RAHMAN M A, MOJICA F, SARKER M, et al.Development of 1-D multiphysics PEMFC model with dry limiting current experimental validation[J]. Electrochimica acta, 2019, 320: 134601.

ZHANG Q, LIN R, TÉCHER L, et al. Experimental study of variable operating parameters effects on overall PEMFC performance and spatial performance distribution[J]. Energy, 2016, 115: 550-560.

乔雨田, 刘永峰, 张璐, 等. 不同温湿度对质子交换膜燃料电池性能的影响[J]. 中国科技论文, 2024, 19(5): 621-628.

尹文进, 张静远, 饶喆, 等. 基于Sobol指数法作战能力全局敏感性分析方法[J]. 船电技术, 2015, 35(12): 19-21, 25.

马睿, 杨富旺, 霍喆, 等. 质子交换膜燃料电池多物理场建模及模型参数敏感性分析[J]. 中国电机工程学报, 2024, 44(7): 2699-2710.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

新型导流块流道PEMFC传质与电性能模拟研究

基于一体化耦合技术的海上风电基础疲劳分析

不同储运方式下氢能全过程利用的综合评价

非均匀流道PEMFC传质模拟与性能研究

PEMFC组合流场结构设计与性能优化模拟研究