可变操作条件对PEMFC水淹的影响研究

肖飞; 陈涛; 兰洋; 陈子瑜

doi:10.19912/j.0254-0096.tynxb.2023-1762

欢迎来到能源电力期刊网！

English Version 读者登录期刊登录

您当前的位置：

首页 >

文章列表页 >

可变操作条件对PEMFC水淹的影响研究

更新时间：2025-10-18

- 可变操作条件对PEMFC水淹的影响研究
- STUDY ON EFFECT OF VARIABLE OPERATING CONDITIONS ON FLOODING OF PEMFC
- 太阳能学报 2025年46卷第3期页码：100-107
- 作者机构：
  
  武汉理工大学机电工程学院,武汉 430070
- 作者简介：
- 基金信息：
- DOI：10.19912/j.0254-0096.tynxb.2023-1762
  中图分类号： TM911.4
- 网络出版：2025-04-07，
  
  纸质出版：2025
- 稿件说明：
移动端阅览
肖飞, 陈涛, 兰洋, 陈子瑜. 可变操作条件对PEMFC水淹的影响研究[J]. 太阳能学报, 2025, 46(3): 100-107.

Xiao Fei, Chen Tao, Lan Yang, et al. STUDY ON EFFECT OF VARIABLE OPERATING CONDITIONS ON FLOODING OF PEMFC[J]. 2025, 46(3): 100-107.
肖飞, 陈涛, 兰洋, 陈子瑜. 可变操作条件对PEMFC水淹的影响研究[J]. 太阳能学报, 2025, 46(3): 100-107. DOI： 10.19912/j.0254-0096.tynxb.2023-1762.

Xiao Fei, Chen Tao, Lan Yang, et al. STUDY ON EFFECT OF VARIABLE OPERATING CONDITIONS ON FLOODING OF PEMFC[J]. 2025, 46(3): 100-107. DOI： 10.19912/j.0254-0096.tynxb.2023-1762.

摘要

为探究可变操作条件对质子交换膜燃料电池（PEMFC）水淹故障的影响

采用电压监测与电化学阻抗谱（EIS）动态测量相结合的方法进行多组水淹对照实验。然后

利用所提出的RL（RQ-RC）等效电路模型对EIS测量结果进行参数辨识

得到欧姆阻抗、传荷阻抗和传质阻抗拟合值。最后

通过分析电压变化趋势和阻抗变化规律

研究不同操作条件对水淹故障的影响。实验结果表明

传荷阻抗和传质阻抗随水淹程度的加剧而逐渐增大

其中传质阻抗的增幅更加显著;增加阴极化学计量比和出口背压可缓解水淹现象;电流密度越高越易造成严重水淹。

Abstract

To investigate the influence of variable operating conditions on the flooding faults of proton exchange membrane fuel cell （PEMFC）

multiple flooding control experiments were conducted by combining voltage monitoring and electrochemical impedance spectroscopy （EIS） dynamic measurements. Then

the EIS measurements were parameterized using the proposed RL（RQ-RC） equivalent circuit model to obtain the fitted values of ohmic impedance

charge transfer impedance and mass transfer impedance. Finally

the effect of different operating conditions on flooding faults were studied by analyzing the trend of voltage change and the variation laws of impedance. The experimental results show that the charge transfer impedance and mass transfer impedance gradually increased with the degree of flooding

in which the increase of mass transfer impedance was more significant. Increasing the cathode stoichiometric ratio and outlet back-pressure could alleviate the flooding phenomenon

and the higher the current density

the more easily to cause severe flooding.

关键词

Keywords

references

CHEN H C, ZHAO X, ZHANG T, et al.The reactant starvation of the proton exchange membrane fuel cells for vehicular applications: a review[J]. Energy conversion and management, 2019, 182: 282-298.

刘士华, 陈涛, 谢屹, 等. 超声制备疏水性碳纸的性能研究[J]. 太阳能学报, 2021, 42(11): 437-441.

CHEN H C, ZHANG R R, XIA Z F, et al.Experimental investigation on PEM fuel cell flooding mitigation under heavy loading condition[J]. Applied energy, 2023, 349: 121632.

REN P, PEI P C, LI Y H, et al.Diagnosis of water failures in proton exchange membrane fuel cell with zero-phase ohmic resistance and fixed-low-frequency impedance[J]. Applied energy, 2019, 239: 785-792.

PENG Z, BADETS V, HUGUET P, et al.Operando μ-Raman study of the actual water content of perfluorosulfonic acid membranes in the fuel cell[J]. Journal of power sources, 2017, 356: 200-211.

NANADEGANI F S, LAY E N, SUNDEN B.Effects of an MPL on water and thermal management in a PEMFC[J]. International journal of energy research, 2019, 43(1): 274-296.

ZUO B, ZHANG Z H, CHENG J S, et al.Data-driven flooding fault diagnosis method for proton-exchange membrane fuel cells using deep learning technologies[J]. Energy conversion and management, 2022, 251: 115004.

LU H X, CHEN J, YAN C Z, et al.On-line fault diagnosis for proton exchange membrane fuel cells based on a fast electrochemical impedance spectroscopy measurement[J]. Journal of power sources, 2019, 430: 233-243.

XU Y M, CHANG G F, FAN R J, et al.Effects of various operating conditions and optimal ionomer-gradient distribution on temperature-driven water transport in cathode catalyst layer of PEMFC[J]. Chemical engineering journal, 2023, 451: 138924.

陈维荣, 刘嘉蔚, 李奇, 等. 质子交换膜燃料电池故障诊断方法综述及展望[J]. 中国电机工程学报, 2017, 37(16): 4712-4721.

MOÇOTÉGUY P, LUDWIG B, BERETTA D, et al. Study of the impact of water management on the performance of PEMFC commercial stacks by impedance spectroscopy[J]. International journal of hydrogen energy, 2020, 45(33): 16724-16737.

FOUQUET N, DOULET C, NOUILLANT C, et al.Model based PEM fuel cell state-of-health monitoring via AC impedance measurements[J]. Journal of power sources, 2006, 159(2): 905-913.

LIU S H, LI X Y, PANG L J, et al.Study on the effect of purging time on the performance of PEMFC with dead-ended anode under gravity[J]. Renewable energy, 2022, 200: 1141-1151.

KO D, DOH S, PARK H S, et al.Investigation of the effect of operating pressure on the performance of proton exchange membrane fuel cell: in the aspect of water distribution[J]. Renewable energy, 2018, 115: 896-907.

马睿, 党翰斌, 张钰奇, 等. 质子交换膜燃料电池系统故障机理分析及诊断方法研究综述[J]. 中国电机工程学报, 2024, 44(1): 407-427.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

气体扩散层压缩形变对PEM燃料电池性能影响分析

迭层太阳电池中电流、电压及功率分配的理论分析

太阳能建材技术的研究与开发（Ⅰ）——光伏屋顶热性能的调查

质子交换膜燃料电池专用碳纸的制备及性能测试