氨煤混烧对墙式切圆锅炉燃烧的影响分析

杨琨; 张涛; 泮浩翔; 丁士发

doi:10.19805/j.cnki.jcspe.2025.240223

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

氨煤混烧对墙式切圆锅炉燃烧的影响分析

动力设备与系统 | 更新时间：2026-10-10

- 氨煤混烧对墙式切圆锅炉燃烧的影响分析
- Analysis of Impact of Ammonia-Coal Co-burning on Combustion in a Wall Type Tangentially-fired Boiler
- 动力工程学报 2025年45卷第6期页码：805-812
- 作者机构：
  
  上海发电设备成套设计研究院有限责任公司,上海,200240
- 作者简介：
  
  杨琨(1997—),男,江苏淮安人,工程师,硕士研究生,研究方向为燃煤机组低碳化改造技术,E-mail:2051719875@qq.com
- 基金信息：
- DOI：10.19805/j.cnki.jcspe.2025.240223
  中图分类号： TM621.2
- 网络首发：2025-06-16，
  
  纸质出版：2025
- 稿件说明：
移动端阅览
杨琨,张涛,泮浩翔,丁士发. 氨煤混烧对墙式切圆锅炉燃烧的影响分析动力工程学报, 2025, 45(6): 805-812 https://doi.

org/10.19805/j.cnki.jcspe.2025.240223
杨琨,张涛,泮浩翔,丁士发. 氨煤混烧对墙式切圆锅炉燃烧的影响分析动力工程学报, 2025, 45(6): 805-812 https://doi. DOI： 10.19805/j.cnki.jcspe.2025.240223.

org/10.19805/j.cnki.jcspe.2025.240223 DOI：

摘要

为验证燃煤机组掺烧大比例氨气的可行性

以某660 MW墙式切圆锅炉为例

建立数值模拟模型

分析氨气掺烧比例、氨气掺烧位置、一二次风配风方式对炉膛内燃烧的影响。结果表明:燃煤锅炉掺烧氨气会造成炉膛内烟气温度降低和NO

的质量浓度增加;氨气掺烧比例越大

烟气温度下降与NO

质量浓度增加的幅度越大;当氨气掺烧比例增加至40%时

炉膛内烟气的平均温度下降约50 K

出口NO

质量浓度升高29.4%;采取更高层燃烧器掺烧氨气和提高一次风比例等举措

可在保证氨煤充分燃烧的基础上

降低炉膛出口NO

质量浓度。

Abstract

In order to verify the feasibility of blending a large proportion of ammonia in a coal-fired unit

a numerical simulation model was established using a 660 MW wall type tangentially-fired boiler as an example. The impact of ammonia blending ratio

ammonia injection location

and primary and secondary air distribution methods on combustion in the furnace was analyzed. Results show that blending ammonia in coal-fired boiler leads to a decrease in flue gas temperature and an increase in NO

mass concentration in the furnace. The greater the ammonia blending ratio

the more significant the decrease in flue gas temperature and the increase in NO

mass concentration. When the ammonia blending ratio increases to 40%

the average flue gas temperature in the furnace drops by approximately 50 K

and the outlet NO

mass concentration increases by 29.4%. Measures such as blending ammonia in higher-level burners and increasing the primary air ratio can reduce the NO

mass concentration at the furnace outlet while ensuring complete combustion of ammonia and coal.

关键词

Keywords

references

李政, 张东杰, 潘玲颖, 等. "双碳"目标下我国能源低碳转型路径及建议[J]. 动力工程学报, 2021, 41(11): 905-909, 971. LI Zheng, ZHANG Dongjie, PAN Lingying, et al. Low-carbon transition of china's energy sector and suggestions with the 'carbon-peak and carbon-neutrality' target[J]. Journal of Chinese Society of Power Engineering, 2021, 41(11): 905-909, 971.

GIELEN D, BOSHELL F, SAYGIN D, et al. The role of renewable energy in the global energy transformation[J]. Energy Strategy Reviews, 2019, 24: 38-50.

VALERA-MEDINA A, AMER-HATEM F, AZAD A K, et al. Review on ammonia as a potential fuel: from synthesis to economics[J]. Energy & Fuels, 2021, 35(9): 6964-7029.

周上坤, 杨文俊, 谭厚章, 等. 氨燃烧研究进展[J]. 中国电机工程学报, 2021, 41(12): 4164-4181. ZHOU Shangkun, YANG Wenjun, TAN Houzhang, et al. Research progress of ammonia combustion[J]. Proceedings of the CSEE, 2021, 41(12): 4164-4181.

吴梓秋, 黄骞, 马鹏, 等. 氨煤混燃过程中单颗粒煤粉着火特性[J]. 洁净煤技术, 2023, 29(10): 108-115. WU Ziqiu, HUANG Qian, MA Peng, et al. Characteristics of single-coal-particle ignition in ammonia-coal cofiring process[J]. Clean Coal Technology, 2023, 29(10): 108-115.

王志超, 方亮, 贾子秀, 等. 不同比例氨与煤混燃试验研究[J]. 热力发电, 2023, 52(7): 41-47. WANG Zhichao, FANG Liang, JIA Zixiu, et al. Experimental study on co-combustion of different ratios of ammonia with coal[J]. Thermal Power Generation, 2023, 52(7): 41-47.

TAMURA M, GOTOU T, ISHII H, et al. Experimental investigation of ammonia combustion in a bench scale 1.2 MW-thermal pulverised coal firing furnace[J]. Applied Energy, 2020, 277: 115580.

TANIGAWA H. Test results of the ammonia mixed combustion at Mizushima power station unit No.2 and related patent applications[C]//2018 AIChE Annual Meeting. [S.l.]:AIChE, 2018.

LYU Qiang, WANG Ruru, DU Yongbo, et al. Numerical study on coal/ammonia co-firing in a 600 MW utility boiler[J]. International Journal of Hydrogen Energy, 2023, 48(45): 17293-17310.

JIN Wei, SI Fengqi, CAO Yue, et al. Numerical research on ammonia-coal co-firing in a 1050 MW coal-fired utility boiler under ultra-low load: effects of ammonia ratio and air staging condition[J]. Applied Thermal Engineering, 2023, 233: 121100.

牛涛, 张文振, 魏书洲, 等. 不同空气分级模式下氨煤掺烧数值模拟[J]. 洁净煤技术, 2023, 29(9): 145-151. NIU Tao, ZHANG Wenzhen, WEI Shuzhou, et al. Modeling co-firing ammonia with coal in different air staging modes[J]. Clean Coal Technology, 2023, 29(9): 145-151.

马仑, 方庆艳, 张成, 等. 深度空气分级下煤粉耦合氨燃烧及NO生成特性[J]. 洁净煤技术, 2022, 28(3): 201-213. MA Lun, FANG Qingyan, ZHANG Cheng, et al. Combustion and NO formation characteristics of pulverized coal co-firing with ammonia in a deep-air staging condition[J]. Clean Coal Technology, 2022, 28(3): 201-213.

YAMAMOTO A, KIMOTO M, OZAWA Y, et al. Basic co-firing characteristics of ammonia with pulverized coal in a single burner test furnace[C]//2018 AIChE Annual Meeting. [S.l.]:[s.n.], 2018.

CARDOSO J S, SILVA V, EUSBIO D, et al. Numerical modelling of ammonia-coal co-firing in a pilot-scale fluidized bed reactor: influence of ammonia addition for emissions control[J]. Energy Conversion and Management, 2022, 254: 115226.

WANG Xin, FAN Weidong, CHEN Jun, et al. Experimental study on effects of air-staged strategy and NH 3 co-firing ratios on NO formation characteristics in ammonia/coal co-firing process[J ] . Fuel, 2023, 332: 126217.

MA Peng, HUANG Qian, SI Tong, et al. Experimental investigation of NO x emission and ash-related issues in ammonia/coal/biomass co-combustion in a 25-kW down-fired furnace[J ] . Proceedings of the Combustion Institute, 2023, 39(3): 3467-3477.

ZHANG Wenzhen, LIU Xin, ZHANG Chaoqun, et al. Industrial scale testing on the combustion and NO x emission characteristics of ammonia cofiring in a 40 MW th coal-fired boiler[J ] . Fuel, 2024, 359: 130471.

CHEN Ping, WANG Huichun, JIANG Boyu, et al. An experimental and theoretical study of NO heterogeneous reduction in the reduction zone of ammonia co-firing in a coal-fired boiler: influence of CO[J]. Fuel Processing Technology, 2022, 231: 107184.

TAN Jiaxin, HE Yong, ZHU Runfan, et al. Experimental study on co-firing characteristics of ammonia with pulverized coal in a staged combustion drop tube furnace[J]. Proceedings of the Combustion Institute, 2023, 39(3): 3217-3225.

浏览量

351

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

氢燃气轮机燃烧特性与涡轮气热性能研究进展

燃气轮机掺氢燃烧流动及排放特性数值模拟

不同维度下大型VAWT并联布置气动特性分析

基于多通道特征提取与深度交互融合网络的IES多元负荷短期预测

热电厂耦合蒸汽储能电热特性研究与优化