分流叶片非谐对离心压气机叶轮气动噪声特性的影响研究

梁春娟; 唐新姿; 金绍哲

doi:10.19805/j.cnki.jcspe.2024.230708

欢迎来到能源电力期刊网！

English Version 读者登录期刊登录

您当前的位置：

首页 >

文章列表页 >

分流叶片非谐对离心压气机叶轮气动噪声特性的影响研究

新能源与储能 | 更新时间：2026-02-05

- 分流叶片非谐对离心压气机叶轮气动噪声特性的影响研究
- Research on Influence of Non-harmonic Splitter Blade on Aerodynamic Noise Characteristics of Centrifugal Compressor Impeller
- 动力工程学报 2025年45卷第1期页码：70-79
- 作者机构：
  
  湘潭大学机械工程与力学学院,湖南,湘潭,411105
- 作者简介：
- 基金信息：
  
  湖南省教育厅重点资助项目(23A0130)
- DOI：10.19805/j.cnki.jcspe.2024.230708
  中图分类号： TH452;TB53
- 网络首发：2025-01-15，
  
  纸质出版：2025
- 稿件说明：
移动端阅览
梁春娟,唐新姿,金绍哲. 分流叶片非谐对离心压气机叶轮气动噪声特性的影响研究动力工程学报, 2025, 45(1): 70-79 https://doi.

org/10.19805/j.cnki.jcspe.2024.230708
梁春娟,唐新姿,金绍哲. 分流叶片非谐对离心压气机叶轮气动噪声特性的影响研究动力工程学报, 2025, 45(1): 70-79 https://doi. DOI： 10.19805/j.cnki.jcspe.2024.230708.

org/10.19805/j.cnki.jcspe.2024.230708 DOI：

摘要

为探讨非谐设计在分流叶片离心叶轮上的可行性及气动降噪程度

以离心压气机叶轮为研究对象

采用全流道非定常数值模拟和FW-H气动噪声模型

对比分析了4种分流叶片非谐叶轮和原始均匀叶轮的气动噪声特性

通过叶片表面压力脉动频谱特性和湍动能分布揭示了非谐设计对气动噪声的影响机理。结果表明:分流叶片周向角非谐设计在保证气动性能的同时

可以降低离散单音噪声;在采用的对比方案中

叶轮A1降噪效果最为明显

在第1、2和3阶处叶片通过频率的声谱密度分别下降43百分点、44百分点和50百分点

对应的压力脉动幅值分别下降25百分点、25百分点和30百分点

同时宽频噪声水平相比原始均匀叶轮明显增加。

Abstract

In order to investigate the feasibility and noise reduction degree of non-harmonic design on centrifugal impeller

aerodynamic noise characteristics of four kinds of diffused vane non-harmonic impels and original uniform impels were compared and analyzed by using unsteady numerical simulation and FW-H aerodynamic noise model. The influence mechanism of non-harmonic design on aerodynamic noise was revealed through the spectrum characteristics of pressure pulsation and turbulent kinetic energy distribution of blade surface. Results show that the circumferential angular non-harmonic design of splitter blade can reduce the discrete monophonic noise while ensuring the aerodynamic performance. In the comparison schemes adopted

the noise reduction effect of impeller A1 is the most obvious. At the 1st

2nd and 3rd order

the sound spectral density of the blade passing frequency decreases by 43 percentage points

44 percentage points and 50 percentage points respectively

and the corresponding pressure pulsation amplitude decreases by 25 percentage points

25 percentage points and 30 percentage points respectively. At the same time

the broadband noise level increases significantly compared with the original uniform impeller.

关键词

Keywords

references

SHI Cheng, CHAI S, WANG Huaiyu, et al. An insight into direct water injection applied on the hydrogen-enriched rotary engine[J]. Fuel, 2023, 339: 127352.

BROATCH A, RUIZ S, GARCA-TSCAR J, et al. On the influence of inlet elbow radius on recirculating backflow, whoosh noise and efficiency in turbocharger compressors[J]. Experimental Thermal and Fluid Science, 2018, 96: 224-233.

黄月晴, 杨爱玲, 宋文杰, 等. 部分叶高串列扩压器对离心压气机性能的影响[J]. 动力工程学报, 2017, 37(1): 26-32. HUANG Yueqing, YANG Ailing, SONG Wenjie, et al. Effect of partial-height tandem diffuser on performance of the centrifugal compressor[J]. Journal of Chinese Society of Power Engineering, 2017, 37(1): 26-32.

SHARMA S, GARCA-TSCAR J, ALLPORT J M, et al. Evaluation of modelling parameters for computing flow-induced noise in a small high-speed centrifugal compressor[J]. Aerospace Science and Technology, 2020, 98: 105697.

LIU Chen, CAO Yipeng, ZHANG Wenping, et al. Numerical and experimental investigations of centrifugal compressor BPF noise[J]. Applied Acoustics, 2019, 150: 290-301.

NEISE W. Review of fan noise generation mechanisms and control methods[C]//Proceedings of the International Symposium on Fan Noise. Seulis: Publications CETIM, 1992.

NEISE W. Noise reduction in centrifugal fans: a literature survey[J]. Journal of Sound and Vibration, 1976, 45(3): 375-403.

ZHONG Chao, HU Liaoping, GONG Jinke, et al. Effects analysis on aerodynamic noise reduction of centrifugal compressor used for gasoline engine[J]. Applied Acoustics, 2021, 180: 108104.

GALINDO J, TISEIRA A, NAVARRO R, et al. Effect of the inlet geometry on performance, surge margin and noise emission of an automotive turbocharger compressor[J]. Applied Thermal Engineering, 2017, 110: 875-882.

TORREGROSA A J, BROATCH A, NAVARRO R, et al. Acoustic characterization of automotive turbocompressors[J]. International Journal of Engine Research, 2015, 16(1): 31-37.

康达, 何卫东, 徐毅. 分流叶片长度和周向位置对高压比离心压气机性能的影响[J]. 推进技术, 2020, 41(12): 2709-2719. KANG Da, HE Weidong, XU Yi. Effects of splitter blade length and circumferential position on performance of high pressure ratio centrifugal compressor[J]. Journal of Propulsion Technology, 2020, 41(12): 2709-2719.

张书玮, 姜玉廷, 林洪飞, 等. 分流叶片长度和周向位置对氦氙离心压气机性能的影响[J]. 热能动力工程, 2022, 37(1): 49-56, 64. ZHANG Shuwei, JIANG Yuting, LIN Hongfei, et al. Effects of splitter blade length and circumferential position on performance of helium-xenon centrifugal compressor[J]. Journal of Engineering for Thermal Energy and Power, 2022, 37(1): 49-56, 64.

张建华, 楚武利, 刘炜. 单级轴流风扇单音噪声源及噪声辐射特性的数值研究[J]. 动力工程学报, 2015, 35(7): 574-580. ZHANG Jianhua, CHU Wuli, LIU Wei. Numerical study on tone noise source and noise radiation characteristics of single stage axial flow fan[J]. Journal of Chinese Society of Power Engineering, 2015, 35(7): 574-580.

王良锋, 杨野, 乔渭阳, 等. 转子叶尖间隙对风扇气动特性及单音噪声特性影响的数值计算[J]. 空气动力学学报, 2020, 38(6): 1047-1055. WANG Liangfeng, YANG Ye, QIAO Weiyang, et al. Numerical study of the effects of rotor tip clearance on aerodynamic performance and tonal noise behavior of fan[J]. Acta Aerodynamica Sinica, 2020, 38(6): 1047-1055.

LI Zhihui, LIU Yanming, JI Lucheng, et al. Effect of nonuniform tip clearance on the performance of transonic axial compressors[J]. Journal of Propulsion and Power, 2018, 34(3): 808-818.

CATTANEI A, MAZZOCUT ZECCHIN F, DI PASQUALI A, et al. Effect of the uneven blade spacing on the noise annoyance of axial-flow fans and side channel blowers[J]. Applied Acoustics, 2021, 177: 107924.

JIANG Boyan, WANG Jun, YANG Xiaopei, et al. Tonal noise reduction by unevenly spaced blades in a forward-curved-blades centrifugal fan[J]. Applied Acoustics, 2019, 146: 172-183.

KIM T Y. Reduction of tonal propeller noise by means of uneven blade spacing[D]. Irvine: University of California, 2016.

祁明旭, 张美杰, 马朝臣. 间隙非谐对离心压气机离散噪声的影响[J]. 北京理工大学学报, 2016, 36(5): 475-479. QI Mingxu, ZHANG Meijie, MA Chaochen. Influences of dis-tuned tip clearance on the discrete aerodynamic noise in centrifugal compressor[J]. Transactions of Beijing Institute of Technology, 2016, 36(5): 475-479.

LENG Yujun, KEY N L. Effects of nonuniform blade spacing on compressor rotor forced response and aeroacoustics[J]. Journal of Propulsion and Power, 2020, 36(5): 721-731.

EKICI K, KIELB R E, HALL K C. The effect of aerodynamic asymmetries on turbomachinery flutter[J]. Journal of Fluids and Structures, 2013, 36: 1-17.

PHAN H, HE Li. Phasing structural and aerodynamic mistuning for leveraging aeroelastic performance[C]//ASME Turbo Expo 2022: Turbomachinery Technical Conference and Exposition. Rotterdam: American Society of Mechanical Engineers, 2022.

牛永红, 侯安平, 张明明, 等. 非均匀静子布局对转子叶片振动的影响[J]. 推进技术, 2015, 36(7): 1078-1084. NIU Yonghong, HOU Anping, ZHANG Mingming, et al. Effects of asymmetric vane spacing on rotor blade vibration[J]. Journal of Propulsion Technology, 2015, 36(7): 1078-1084.

郑赟, 崔健, 高庆哲, 等. 导叶非均匀布局对气动激励的影响[J]. 航空动力学报, 2022, 37(11): 2627-2635. ZHENG Yun, CUI Jian, GAO Qingzhe, et al. Effects of inlet guide vanes asymmetry layouts on aerodynamic excitation[J]. Journal of Aerospace Power, 2022, 37(11): 2627-2635.

NAQAVI I Z, WANG Zhongnan, TUCKER P G, et al. Far-field noise prediction for jets using large-eddy simulation and Ffowcs Williams-Hawkings method[J]. International Journal of Aeroacoustics, 2016, 15(8): 757-780.

STRAZISAR A J, POWELL J A. Laser anemometer measurements in a transonic axial flow compressor rotor[J]. Journal of Engineering for Power, 1981, 103(2): 430-437.

浏览量

109

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

暂无数据