生物质低温热解与氧化动力学特性研究

周福; 潘存华; 邓中乙; 张科; 陈鑫科; 方庆艳; 崔明硕; 张成; 陈刚

doi:10.19666/j.rlfd.202507110

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

生物质低温热解与氧化动力学特性研究

热能科学研究 | 更新时间：2026-06-12

- 生物质低温热解与氧化动力学特性研究
- 生物质低温热解与氧化动力学特性研究
- 热力发电 2026年55卷第4期页码：62-71
- 作者机构：
  
  1. 中国大唐集团科学技术研究总院有限公司华东电力试验研究院
  2. 中国大唐集团科学技术研究总院有限公司
  3. 华中科技大学能源与动力工程学院
- 作者简介：
- 基金信息：
  
  国家重点研发计划政府间国际科技创新合作资助项目（2021YFE0107300）~~
- DOI：10.19666/j.rlfd.202507110
  中图分类号： TK6
- 纸质出版：2026
- 稿件说明：
移动端阅览
[1]周福,潘存华,邓中乙,等.生物质低温热解与氧化动力学特性研究[J].热力发电,2026,55(04):62-71.
[1]周福,潘存华,邓中乙,等.生物质低温热解与氧化动力学特性研究[J].热力发电,2026,55(04):62-71. DOI： 10.19666/j.rlfd.202507110.

DOI：10.19666/j.rlfd.202507110.

摘要

生物质在储存与运输过程中易发生自燃，传统生物质自燃研究中热重分析/量热实验常采用粉末状样品，这与生物质的实际储存状态存在较大差异。另外，现有的生物质反应动力学模型在250℃以下温度区间的适应性较差。基于此，搭建了生物质低温热解与氧化特性测试平台，在不同氧气气氛下对不同颗粒尺寸（原始大颗粒、2.0 mm颗粒以及0.2 mm颗粒）的稻草秆与大豆壳的热失重行为开展测试。构建了热解-组分独立氧化模型与热解-总包氧化模型，并进行了参数优化，实现了生物质在低温区间热解与氧化行为的准确预测。结果表明：生物质反应速率随温度升高显著提升，但当生物质消耗到一定程度后，升温对生物质反应速率的促进作用逐渐减弱。提高氧气含量可加快生物质的反应速率，但其对反应速度的促进作用弱于温度升高的影响；在相同温度和氧含量条件下，2.0 mm颗粒样品的反应速率最高，原始样品的反应速率最低，0.2 mm颗粒样品的反应速率介于两者之间；对原始颗粒尺寸的生物质样品开展实验并针对性地构建生物质自燃反应动力学模型更符合实际情况；该热解-总包氧化模型能较好地预测不同粒径的稻草秆和大豆壳在不同氧含量下随温度升高过程中质量损失规律，适用于低温区间生物质热解及氧化反应的预测。

Abstract

Biomass resources in China are widely distributed and highly abundant

holding great potential for substituting traditional fossil fuels and promoting the achievement of carbon peak and carbon neutrality goals. During storage and transportation

biomass is prone to self-heating. When the accumulated heat raises the internal temperature of biomass to a certain level

chemical reactions will gradually accelerate

leading to biomass selfignition. In traditional biomass self-ignition studies

thermogravimetric/calorimetric experiments typically employ powdered samples. However

this approach significantly deviates from the actual storage conditions of biomass. Moreover

existing biomass reaction kinetics models exhibit poor adaptability below 250 ℃. To address these issues

a testing platform for the low-temperature pyrolysis and oxidation characteristics of biomass was established. The thermal degradation behavior of rice straw and soybean shell samples with different particle sizes(original large particles

2.0 mm particles

and 0.2 mm particles) was investigated under various oxygen concentrations. Two kinetic models

namely the pyrolysis-independent component oxidation model and the pyrolysis-lumped oxidation model

were developed and optimized. These models accurately predicted the pyrolysis and oxidation behavior of biomass in the low-temperature range. The results indicated that the reaction rate increased significantly with temperature. However

as biomass consumption progressed

the promoting effect of temperature on the reaction rate gradually diminished. Increasing the oxygen concentration also accelerated the reaction rate

but its impact was weaker than that of temperature elevation. Under the same temperature and oxygen concentration conditions

the 2.0 mm particle samples exhibited the highest reaction rate

while the original samples had the lowest rate

with the 0.2 mm particle samples falling in between. Experiments on biomass samples with original particle sizes and the development of targeted kinetic models are more representative of real-world conditions. The pyrolysis-lumped oxidation model effectively predicted the mass loss behavior of rice straw and soybean shell samples with different particle sizes under various oxygen concentrations as the temperature increased

demonstrating its applicability for predicting low-temperature pyrolysis and oxidation reactions of biomass.

关键词

Keywords

references

杨传文,邢帆,朱建春,等.中国秸秆资源的时空分布、利用现状与碳减排潜力[J].环境科学, 2023, 44(2):1149-1162.YANG Chuanwen, XING Fan, ZHU Jianchun, et al.Temporal and spatial distribution, utilization status, and carbon emission reduction potential of straw resources in China[J]. Environmental Science, 2023, 44(2):1149-1162.

SU X, FANG Q, MA L, et al. Efficient and low-NO combustion in a grate-fired boiler by feeding biomass nonuniformly along grate width:an integrated modeling study with experimental validation[J]. Energy, 2024, 312:133583.

WANG J, MA L, FANG Q, et al. Accurate machinelearning-based prediction of aerodynamic and heat transfer coefficients for cylindrical biomass particles[J].Chemical Engineering Journal, 2024, 498:155192.

赵彦,张成,马仑,等.温度对松木刨花CO2气化过程NOx和SO2排放特性影响[J].洁净煤技术, 2024,30(11):44-50.ZHAO Yan, ZHANG Cheng, MA Lun, et al. Effect of temperatures on emission characteristics of NOx and SO2for pine shaving under CO2 gasification[J]. Clean Coal Technology, 2024, 30(11):44-50.

孙昊,孙云娟,马名哲,等.林业资源热解气化供热发电产业发展趋势与战略对策[J].生物质化学工程,2022, 56(2):40-48.SUN Hao, SUN Yunjuan, MA Mingzhe, et al. Development trend and strategic countermeasures of forestry resources gasification, heat supply and power generation industry[J]. Biomass Chemical Engineering, 2022, 56(2):40-48.

SHENG C, YAO C. Review on self-heating of biomass materials:understanding and description[J]. Energy&Fuels, 2022, 36(2):731-761.

KRIGSTIN S, WETZEL S, JAYABALA N, et al. Recent health and safety incident trends related to the storage of woody biomass:a need for improved monitoring strategies[J]. Forests, 2018, 9(9):538.

MURASAWA N, KOSEKI H, IWATA Y, et al.Examination of the fires caused by fermentation in disaster waste after the 2011 earthquake[J]. Waste and Biomass Valorization, 2019, 10:2559-2573.

MURASAWA N, KOSEKI H, IWATA Y, et al.Investigation of the heat generation and spontaneous ignition of disaster waste generated after the 2011 Great East Japan Earthquake[J]. Fire Safety Journal, 2013, 59:178-187.

CHEN X, YAN H, MA L, et al. Comprehensive experimental study of microbial respiration during selfheating in biomass storage piles[J]. Fuel, 2024, 362:130746.

CHEN X, YAN H, MA L, et al. Moisture content effects on self-heating in stored biomass:an experimental study[J]. Energy, 2023, 285:129391.

ZHU Y, ZHANG H, SHENG C. Characterizing selfheating of cereal straws by isothermal microcalorimetry[J]. Thermochimica Acta, 2021, 698:178881.

GUO W, TRISCHUK K, BI X, et al. Measurements of wood pellets self-heating kinetic parameters using isothermal calorimetry[J]. Biomass and Bioenergy, 2014,63:1-9.

HAO Z, SUN M, DUCOSTE J J, et al. Heat generation and accumulation in municipal solid waste landfills[J].Environmental Science&Technology, 2017, 51(21):12434-12442.

LUO Q, LIANG D, SHEN H. Evaluation of self-heating and spontaneous combustion risk of biomass and fishmeal with thermal analysis(DSC-TG)and self-heating substances test experiments[J]. Thermochimica Acta,2016, 635:1-7.

YANG H, YAN R, CHEN H, et al. Characteristics of hemicellulose, cellulose and lignin pyrolysis[J]. Fuel,2007, 86(12):1781-1788.

MOHIT A, REMYA N. Pyrolysis characteristics and kinetics study of native polyculture microalgae using thermogravimetric analysis[J]. Biomass Conversion and Biorefinery, 2023, 14(16):19825-19833.

TARABA B, PODSTAWKA T, MUCHA M. Towards indication gases of spontaneous heating of biomass[J].Fuel, 2018, 222:610-616.

GIL M V, CASAL D, PEVIDA C, et al. Thermal behaviour and kinetics of coal/biomass blends during cocombustion[J]. Bioresource Technology, 2010, 101(14):5601-5608.

GROTKJ T. An experimental study of biomass ignition[J].Fuel, 2003, 82:825-833.

程辉,余剑,姚梅琴,等.木质素慢速热解机理[J].化工学报, 2013, 64(5):1757-1765.CHENG Hui, YU Jian, YAO Meiqin, et al. Mechanism analysis of lignin slow pyrolysis[J]. CIESC Journal, 2013,64(5):1757-1765.

张万里,刘平,殷广智,等.核壳基生物质热解炭特性及其改性研究[J].太阳能学报, 2024, 45(6):10-21.ZHANG Wanli, LIU Ping, YIN Guangzhi, et al.Characteristics and modification of pyrolysis carbon of core-shell based biomass[J]. Acta Energiae Solaris Sinica,2024, 45(6):10-21.

GUO W, BI X, LIM C J, et al. Investigation of wood pellets self-heating kinetics and thermal runaway phenomena using lab scale experiments[J]. The Canadian Journal of Chemical Engineering, 2020, 98(1):127-137.

PAUNER M A, BYGBJERG H. Spontaneous ignition in storage and production lines:investigation on wood pellets and protein powders[J]. Fire and Materials, 2007,31(8):477-494.

RESTUCCIA F, FERNANDEZ-ANEZ N, REIN G.Experimental measurement of particle size effects on the self-heating ignition of biomass piles:homogeneous samples of dust and pellets[J]. Fuel, 2019, 256:115838.

FAN P, FAN S, SHENG C. Low temperature oxidation and its kinetics of cornstalk chars[J]. Fuel, 2016, 184:915-921.

SOEST V. Use of detergents in the analysis of fibrous feeds. II. a rapid method for the determination of fiber and lignin[J]. Journal of the AOAC, 1990, 73(4):491-497.

SCHWARZER L, SÁROSSY Z, JENSEN P A, et al.Kinetic parameters for biomass under self-ignition conditions:low-temperature oxidation and pyrolysis[J].Energy&Fuels, 2019, 33(9):8606-8619.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

农业生物质稻草与烟煤混烧特性及动力学分析

煤掺烧生物质耦合CCS电厂的碳排放核算与分析

生物质多孔介质气体流动阻力特性实验研究与数值模拟

准东高钙粉煤灰的常压直接湿法碳酸化工艺研究

O2/CO2气氛下煤/生物质混燃特性实验研究