熔盐蒸发器换热特性研究

成汭珅; 范长哲; 鲁晓宇; 赵文沛; 白永岗; 周科; 杜勇博; 车得福

doi:10.19666/j.rlfd.202507039

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

熔盐蒸发器换热特性研究

储能技术 | 更新时间：2026-06-12

- 熔盐蒸发器换热特性研究
- 熔盐蒸发器换热特性研究
- 热力发电 2026年55卷第4期页码：12-20
- 作者机构：
  
  1. 西安热工研究院有限公司
  2. 西安交通大学能源与动力工程学院
- 作者简介：
- 基金信息：
  
  煤炭重大专项（2024ZD1700300）;工信部重点项目（TC220H072）~~
- DOI：10.19666/j.rlfd.202507039
  中图分类号： TM621
- 纸质出版：2026
- 稿件说明：
移动端阅览
[1]成汭珅,范长哲,鲁晓宇,等.熔盐蒸发器换热特性研究[J].热力发电,2026,55(04):12-20.
[1]成汭珅,范长哲,鲁晓宇,等.熔盐蒸发器换热特性研究[J].热力发电,2026,55(04):12-20. DOI： 10.19666/j.rlfd.202507039.

DOI：10.19666/j.rlfd.202507039.

摘要

熔盐储热技术能够提升火电机组的灵活性，熔盐蒸发器利用熔盐的热能将锅炉给水加热成过热蒸汽，是整个系统的核心部件，然而，熔盐的特殊热物性与换热器的复杂结构导致已有传热关联式难以准确计算其换热特性。熔盐换热器的实验研究成本高昂，现有数值模拟方法难以实现单相熔盐侧与相变工质侧的耦合换热计算。在给定入口给水参数的条件下，通过设定沿程工质焓值分布，建立熔盐侧换热的数值模型，再根据模拟的热负荷分布计算出工质焓值变化，并与初始设定值对比修正。经过多次迭代，实现了对熔盐蒸汽换热器换热过程的准确计算，并以此方法研究了换热器的运行特性。研究结果表明：在工作压力2 MPa下，水由入口过冷态至完全汽化过程中，工质汽化速率逐渐提高，热负荷在水汽化完成处增大至86 295.12 W/m

后迅速下降，最后稳定至5 000 W/m

左右；熔盐在流动横截面上存在显著的温度不均匀性，热偏差最高达216%，随着入口熔盐温度降低，温度场的不均匀性有所缓解。

Abstract

Molten salt thermal energy storage technology can improve the flexibility of thermal power units. The molten salt evaporator

a core component of the system

utilizes the thermal energy of molten salt to convert boiler feedwater into superheated steam. However

the unique thermophysical properties of molten salt and the complex structure of the heat exchanger render existing heat transfer correlations inadequate for accurately predicting its thermal performance. Experimental studies on molten salt heat exchangers are costly

while existing numerical simulations cannot achieve coupled heat transfer calculations between the single-phase molten salt side and the phase-change working fluid side. In this study

with given feedwater inlet parameters

a numerical model for the mo

lten salt side heat transfer is established by assuming an initial enthalpy distribution along the flow path. The heat flux distribution obtained from the simulation is then used to calculate the enthalpy variation of the working fluid

which is iteratively compared and corrected against the initially assumed values. Through multiple iterations

an accurate computation of the heat transfer process in the molten salt steam generator is achieved

enabling a detailed investigation of its operational characteristics. The results indicate that at an operating pressure of 2 MPa

during the transition from subcooled water to complete vaporization

the vaporization rate gradually increases. The heat flux peaks at 86 295.12 W/m

upon complete vaporization

then decreases rapidly and eventually stabilizes around 5 000 W/m

. Significant temperature non-uniformity is observed across the flow cross-section of the molten salt

with a maximum thermal deviation of 216%. This temperature non-uniformity is alleviated as the inlet molten salt temperature decreases.

关键词

Keywords

references

WANG Z, LIU M, YAN H, et al. Improving flexibility of thermal power plant through control strategy optimization based on orderly utilization of energy storage[J]. Applied Thermal Engineering, 2024, 240:122231.

赵攀,苟非非,许文盼,等.风-火-储耦合系统储能容量配置优化对比[J].西安交通大学学报, 2024, 58(8):38-48.ZHAO Pan, GOU Feifei, XU Wenpan, et al. Comparison of storage capacity configuration optimization in wind thermal power-storage coupling system[J]. Journal of Xi’an Jiaotong University, 2024, 58(8):38-48.

王珠,刘双白,胡娱欧,等.集成熔盐储能的燃煤机组多区间变负荷瞬态特性[J].西安交通大学学报, 2025,59(5):12-22.WANG Zhu, LIU Shuangbai, HU Yuou, et al. Load cycling performance analysis of a coal-fired power plant integrated with the molten salt energy storage system under different load intervals[J]. Journal of Xi’an Jiaotong University, 2025, 59(5):12-22.

杜志强,宋中越.新型熔盐结合吸收式热泵大温差储能供暖系统的研究[J].建筑科学, 2020, 36(4):86-89.DU Zhiqiang, SONG Zhongyue. Study on a new large temperature difference energy storage heating system using molten salt and absorption heat pump[J]. Building Science, 2020, 36(4):86-89.

宋晓辉,韩伟,王兴,等.基于高温熔盐储热系统的火电机组深度调峰方案对比及分析[J].热能动力工程,2023, 38(11):63-74.SONG Xiaohui, HAN Wei, WANG Xing, et al.Comparison and analysis of deep peak shaving schemes for thermal power units based on high-temperature molten salt heat storage system[J]. Journal of Engineering for Thermal Energy and Power, 2023, 38(11):63-74.

左芳菲,韩伟,姚明宇.熔盐储能在新型电力系统中应用现状与发展趋势[J].热力发电, 2023, 52(2):1-9.ZUO Fangfei, HAN Wei, YAO Mingyu, et al. Application status and development trend of molten salt energy storage in novel power systems[J]. Thermal Power Generation,2023, 52(2):1-9.

陈珣,陈正器,周科,等. 1 000 MW燃煤机组耦合熔盐储热系统构型分析[J].热力发电, 2025, 54(4):33-41.CHEN Xun, CHEN Zhengqi, ZHOU Ke, et al. Configuration analysis of coupled molten salt heat storage system for 1 000 MW coal-fired unit[J]. Thermal Power Generation, 2025, 54(4):33-41.

邹小刚,刘明,肖海丰,等.火电机组耦合熔盐储热深度调峰系统设计及性能分析[J].热力发电, 2023,52(2):146-153.ZOU Xiaogang, LIU Ming, XIAO Haifeng, et al. Design and performance analysis of deep peak shaving system of thermal power units coupled with molten salt heat storage[J]. Thermal Power Generation, 2023, 52(2):146-153.

HUANG Z J, ZOU Y K, DING J, et al. Experimental investigation of heat transfer in coiled tube type molten salt steam generator[J]. Applied Thermal Engineering,2019, 148(5):1131-1138.

贾振国,王顺,管洪军,等.耦合熔盐储热系统的火电机组调峰性能与热经济性研究[J].热力发电, 2024,53(10):72-80.JIA Zhenguo, WANG Shun, GUAN Hongjun, et al. Study on peaking performance and thermal economy of thermal power unit coupled with molten salt thermal storage system[J]. Thermal Power Generation, 2024, 53(10):72-80.

王然.熔盐式蒸汽发生器流动与传热特性的数值研究[D].太原:太原理工大学, 2019:1.WANG Ran. Numerical study on flow and heat transfer characteristics of molten salt steam generator[D]. Taiyuan:Taiyuan University of Technology, 2019:1.

张智博.换热工质参数对熔盐蒸汽发生系统性能的影响研究[J].太阳能, 2021(3):32-38.ZHANG Zhibo. Research on influence of heat exchange working fluid parameters on the performance of molten salt steam generation system[J]. Solar Energy, 2021(3):32-38.

张俊峰,田家铭,王黎明,等.太阳能光热电站熔盐蒸汽发生系统性能提升及运行安全性研究[J].西北水电,2025(1):117-124.ZHANG Junfeng, TIAN Jiaming, WANG Liming, et al.Research on performance improvement and operation safety of the molten salt steam generation system in a solar thermal power plant[J]. Northwest Hydropower, 2025(1):117-124.

张荣发.塔式与槽式光热电站蒸汽发生系统可靠性研究[J].电站辅机, 2021, 42(3):5-9.ZHANG Rongfa. Study on reliability of steam generation system in central receiver tower and parabolic through CSP plants[J]. Power Station Auxiliary Equipment, 2021,42(3):5-9.

江晶亮,顾磊,陈世通.塔式熔盐太阳能光热电站蒸汽发生器传热数值模拟设计计算[J].锅炉技术, 2021,52(1):14-20.JIANG Jingliang, GU Lei, CHEN Shitong. Numerical simulation calculation of heat transfer of steam generator in tower type concentrated solar power station with molten salt[J]. Boiler Technology, 2021, 52(1):14-20.

LI X, DU Y, WANG P, et al. Numerical investigation on heat transfer characteristics of high-pressure syngas in the membrane helical-coil cooler of a 2 000 t/d gasifier[J].Numerical Heat Transfer, Part A:Applications, 2017,72(9):708-720.

徐星宇,李早阳,史睿菁,等.真空加热炉温度均匀性提升研究[J].电子与封装, 2025, 25(12):96-100.XU Xingyu, LI Zaoyang, SHI Ruijing, et al. Study on the improvement of temperature uniformity in vacuum heating furnace[J]. Electronics&Packaging, 2025, 25(12):96-100.

宋园园,周科,鲁晓宇,等.模块化熔盐储热换热器流动传热特性研究及安全性分析[J].西安交通大学学报,2025, 59(7):118-128.SONG Yuanyuan, ZHOU Ke, LU Xiaoyu, et al. Study of flow heat transfer characteristics and safety analysis of modular molten salt energy storage heat exchanger[J].Journal of Xi’an Jiaotong University, 2025, 59(7):118-128.

鲁海龙.节流孔圈在电厂超超临界直流锅炉中的运用[J].水电科技, 2018, 1(1):1-3.LU Hailong. Orifice plate application in ultra-supercritical once-through boilers for power plants[J]. Hydroelectric Science and Technology, 2018, 1(1):1-3.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

螺旋扭曲扁管换热器壳程湍流传热的数值分析

矩形偏心翅片椭圆管流动与换热的数值研究

超临界压力下二氧化碳在套管换热器内传热特性数值模拟

回转式空气预热器蓄热元件流动传热数值模拟

基于神经网络和遗传算法的气膜冷却孔结构优化