燃煤锅炉低负荷工况下乏气提温技术数值模拟研究

刘鹏飞; 范燕荣; 李跃伟; 庞明军; 杨秀军; 张冲; 李成隆; 苏胜

doi:10.19666/j.rlfd.202506113

欢迎来到能源电力期刊网！

English Version 期刊登录

您当前的位置：

首页 >

文章列表页 >

燃煤锅炉低负荷工况下乏气提温技术数值模拟研究

热能科学研究 | 更新时间：2026-06-12

- 燃煤锅炉低负荷工况下乏气提温技术数值模拟研究
- 燃煤锅炉低负荷工况下乏气提温技术数值模拟研究
- 热力发电 2026年55卷第3期页码：44-52
- 作者机构：
  
  1. 烟台龙源电力技术股份有限公司
  2. 华中科技大学煤燃烧与低碳利用全国重点实验室
- 作者简介：
- 基金信息：
  
  国家重点研发计划项目（2023YFB4102902）~~
- DOI：10.19666/j.rlfd.202506113
  中图分类号： TM621.2
- 纸质出版：2026
- 稿件说明：
移动端阅览
[1]刘鹏飞,范燕荣,李跃伟,等.燃煤锅炉低负荷工况下乏气提温技术数值模拟研究[J].热力发电,2026,55(03):44-52.
[1]刘鹏飞,范燕荣,李跃伟,等.燃煤锅炉低负荷工况下乏气提温技术数值模拟研究[J].热力发电,2026,55(03):44-52. DOI： 10.19666/j.rlfd.202506113.

DOI：10.19666/j.rlfd.202506113.

摘要

在新能源大规模消纳及国家“双碳”战略目标驱动下，新型电力系统的构建对煤电机组灵活运行提出了更高要求。然而，煤电机组在低负荷运行时面临燃烧稳定性下降、蒸汽参数偏离设计值等挑战。以某电厂600 MW亚临界切圆燃烧锅炉为研究对象，基于数值模拟方法，系统研究了锅炉在50%负荷下，将小粉仓乏气分别通入炉膛主燃区、还原区、燃尽区不同位置对炉内流场、温度场、组分浓度场以及屏区烟气温度的影响规律，重点分析了乏气通入炉膛不同位置对锅炉低负荷稳燃特性与烟温调控的协同作用策略。研究结果表明：将小粉仓乏气通入炉膛不同位置，炉内均能维持稳定的切圆流场组织及高温区域分布，其对锅炉低负荷稳燃性能未产生明显不利影响；将乏气通入还原区，可促使火焰高温区域适度上移，该特性有利于提升深度灵活调峰工况下蒸汽参数稳定性，烟温协同调控效果更优。研究通过数值计算分析获得了通过小粉仓乏气再利用实现锅炉低负荷稳燃与提升烟温协同调控策略，结果可为同类型火电机组宽负荷灵活调峰运行提供基础与依据。

Abstract

Driven by the large-scale integration of renewable energy and the national “dual-carbon” strategic goals

the construction of a new power system imposes higher requirements on the flexible operation of coal-fired units. However

coal-fired units face challenges such as reduced combustion instability and steam parameters deviating from design values during low-load operation. Therefore

in-depth research on coordinated control characteristics of low-load stable combustion and flue gas temperature in boilers is of significant importance for deep and flexible peak regulation. Taking a 600 MW subcritical tangentially fired boiler in a power plant as the object

the effects of injecting primary air exhaust gas from the pulverized coal conveying system into different locations of the furnace(main combustion zone

reduction zone

burnout zone) on the velocity

temperature and component concentration field

and the flue gas temperature at the platen zone are systematically studied under 50% load condition. The analysis specifically focuses on the synergistic influence mechanism of combustion organization on the combustion stability of the boiler and the regulation of flue gas temperature. The results indicate that injecting primary air exhaust gas into various furnace locations can form a stable tangential flow pattern and high-temperature zone

without significantly affecting the boiler's low-load combustion stability. Injecting the primary air exhaust gas into the reduction zone elevates the high-temperature flame region to some extent

which is beneficial for maintaining steam parameters during deep flexible peak regulation

yielding superior coordinated performance for both lowload stable combustion and flue gas temperature regulation. Through numerical analysis

the coordinated control strategy for achieving stable combustion at low loads and regulating flue gas temperature through the reuse of primary air exhaust gas is determined. The study results can provide a basis for the low-load operation of this type of coal-fired boiler during deep peak shaving.

关键词

Keywords

references

马达夫,刘平元,张守玉,等.超低负荷下运行氧量对切圆锅炉燃烧稳定性和NOx排放特性的影响[J].动力工程学报, 2023, 43(2):174-184.MA Dafu, LIU Pingyuan, ZHANG Shouyu, et al. Effect of boiler operation oxygen on combustion stability and NOx emission characteristics of a tangentially fired[J].Journal of Chinese Society of Power Engineering, 2023,43(2):174-184.

杨中智,卢啸风,角加艺,等.大型CFB锅炉低负荷再热汽温稳定特性[J].洁净煤技术, 2023, 29(6):32-39.YANG Zhongzhi, LU Xiaofeng, JUE Jiayi, et al. Stability characteristics of reheat steam temperature of large-scale CFB boilers at low load[J]. Clean Coal Technology, 2023,29(6):32-39.

韩元,朱愉洁,刘铠瑞,等.超临界锅炉低负荷工况动态特性仿真研究[J].洁净煤技术, 2025, 31(增刊1):276-284.HAN Yuan, ZHU Yujie, LIU Kairui, et al. Simulation study on dynamic characteristics of supercritical boiler under low load conditions[J]. Clean Coal Technology,2025, 31(Suppl.1):276-284.

李子祥,张启超,乌晓江,等. 660 MW高水分褐煤锅炉超低负荷运行特性研究[J].热力发电, 2024, 53(5):82-92.LI Zixiang, ZHANG Qichao, WU Xiaojiang, et al.Investigation on operating characteristics of a 660 MW high moisture lignite-fired boiler under ultra-low load operating conditions[J]. Thermal Power Generation, 2024,53(5):82-92.

郭子岗,刘帆,吴帅帅,等. W火焰锅炉低负荷燃烧调整数值模拟研究[J].热力发电, 2025, 54(2):118-125.GUO Zigang, LIU Fan, WU Shuaishuai, et al. Numerical simulation of combustion adjustment of a W-flame boiler at low loads[J]. Thermal Power Generation, 2025, 54(2):118-125.

关心,李阳,刘欢,等. 660 MW超临界切圆锅炉低负荷运行数值模拟研究[J].电站系统工程, 2023, 39(1):29-30.GUAN Xin, LI Yang, LIU Huan, et al. Study on numerical simulation of low load operation of 660 MW supercritical tangential boiler[J]. Power Steam Engineering, 2023,39(1):29-30.

王乐甘. 1 000 MW超超临界双切圆锅炉低负荷燃烧特性的数值模拟及运行优化[D].南京:东南大学, 2025:1.WANG Legan. Numerical simulation and operation optimization of low load combustion characteristics of1 000 MW ultra supercritical double tangential boiler[D].Nanjing:Southeast University, 2025:1.

尤默,陈磊,尚勇,等.超临界墙式切圆锅炉低负荷燃烧特性[J].洁净煤技术, 2023, 29(10):145-152.YOU Mo, CHEN Lei, SHANG Yong, et al. Low load combustion characteristics of supercritical wall type tangentially fired boiler[J]. Clean Coal Technology, 2023,29(10):145-152.

汪一,邓伟,熊哲,等.基于煤流煤质在线监测的灵活混合式煤粉供应系统:ZL202210594060.0[P]. 2025-03-14[2025-05-20].WANG Yi, DENG Wei, XIONG Zhe, et al. Flexible hybrid pulverized coal supply system based on online monitoring of coal quality in coal flow:ZL202210594060.0[P]. 2025-03-14[2025-05-20].

向军,魏子雅,苏骏,等.小粉仓给粉控制方法及系统:ZL202311340146.6[P]. 2024-11-22[2025-05-20].XIANG Jun, WEI Ziya, SU Jun, et al. Method and system for controlling powder feeding of small powder bin:ZL202311340146.6[P]. 2024-11-22[2025-05-20].

丁思变,谭亲雄,丁宏宇,等.基于增设小粉仓的新型制粉系统方案设计及控制策略研究[J].热力发电,2024, 53(11):79-88.DING Sibian, TAN Qinxiong, DING Hongyu, et al.Scheme design and control strategy of a novel coal pulverizing system based on addition of small pulverized coal silos[J]. Thermal Power Generation, 2024, 53(11):79-88.

LIU H, LIU Y H, YI G Z, et al. Effects of air staging conditions on the combustion and NOx emission characteristics in a 600 MW wall fired utility boiler using lean coal[J]. Energy&Fuels, 2013, 27(10):5831-5840.

LU K, WANG K, WANG S, et al. Numerical study on combustion characteristics of wall-type tangential boiler[J]. IOP Conference Series:Earth and Environmental Science, 2019, 237(2):022043.

WU Y, ZHONG Y L, YIN G M. Study on test of coal cofiring for 600 MW ultra supercritical boiler with four walls tangential burning[C]. 2018 4th International Conference on Energy Materials and Environment Engineering. Malaysia:EDP Sciences, 2018.

KHALDI N, CHOUARI Y, MHIRI H, et al. CFD investigation on the flow and combustion in a 300 MWe tangentially fired pulverized-coal furnace[J]. Heat&Mass Transfer, 2016, 52(9):1881-1890.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于神经网络和遗传算法的气膜冷却孔结构优化

电站间接空冷散热器冬季防冻临界运行参数研究

CO2/H_2O复合工质冷凝传热传质特性数值模拟研究

熔盐蒸发器换热特性研究

基于文丘里引射效应的固-气复合储氢反应器放氢性能优化研究