新型湿式相变凝聚除尘、节水及烟气余热回收一体化系统性能研究

谭厚章; 毛双华; 刘亮亮; 林国辉; 曹瑞杰; 杜天民; 阮仁晖

doi:10.19666/j.rlfd.201712168

欢迎来到能源电力期刊网！

English Version 读者登录期刊登录

您当前的位置：

首页 >

文章列表页 >

新型湿式相变凝聚除尘、节水及烟气余热回收一体化系统性能研究

热能科学研究 | 更新时间：2025-09-28

- 新型湿式相变凝聚除尘、节水及烟气余热回收一体化系统性能研究
- Performance research on the new integrated system of wet phase transition agglomeration dust collector, water saving and flue gas waste heat recovery
- 热力发电 2018年47卷第6期页码：16-22
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院
  2. 浙江巨化热电有限公司
  3. 西安格瑞电力科技有限公司
  4. 河北远征环保科技有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201712168
  中图分类号： X51;TM621.9
- 网络出版日期：2018-06-06，
  
  纸质出版日期：2018
- 稿件说明：
移动端阅览
谭厚章, 毛双华, 刘亮亮, 等. 新型湿式相变凝聚除尘、节水及烟气余热回收一体化系统性能研究[J]. 热力发电, 2018,47(6):16-22.

TAN Houzhang, MAO Shuanghua, LIU Liangliang, et al. Performance research on the new integrated system of wet phase transition agglomeration dust collector, water saving and flue gas waste heat recovery[J]. Thermal power generation, 2018, 47(6): 16-22.
谭厚章, 毛双华, 刘亮亮, 等. 新型湿式相变凝聚除尘、节水及烟气余热回收一体化系统性能研究[J]. 热力发电, 2018,47(6):16-22. DOI： 10.19666/j.rlfd.201712168.

TAN Houzhang, MAO Shuanghua, LIU Liangliang, et al. Performance research on the new integrated system of wet phase transition agglomeration dust collector, water saving and flue gas waste heat recovery[J]. Thermal power generation, 2018, 47(6): 16-22. DOI： 10.19666/j.rlfd.201712168.

摘要

基于高湿烟气降温时大量水蒸气冷凝过程中的相变团聚和潜热释放

设计开发了集除尘、节水和汽化潜热回收一体化的湿式相变凝聚系统

并在首次独立应用后

实现了280 t/h燃煤锅炉粉尘超低排放。该系统布置在湿法烟气脱硫系统(WFGD)与烟囱之间

采用锅炉补水(除盐水)作为冷却介质

在脱除烟气颗粒物同时

实现深度节水和烟气余热回收。实际应用结果表明:在90%负荷和75%负荷2个测试工况下

该系统对颗粒物的脱除效率分别为53.05%、71.11%

颗粒物排放质量浓度均低于5 mg/m~3

最大收水量为4.32 t/h

最高回收热量为3.59 MW。

Abstract

The wet phase transition agglomeration system(WPTA) integrating dust removal

water saving

and latent heat recovery for vaporization is designed and developed based on the phase transition agglomeration and latent heat release during the condensation of large quantities of water vapor when the high humidity smoke is cooled. After the first independent application

ultra-low dust emission from 280 t/h coal-fired boiler is achieved.The system is arranged between the wet flue gas desulfurization system(WFGD) and the chimney

and the make-up water for boiler is used as the cooling medium. The system removes particulates from smoke and achieves deep water saving and waste heat recovery. After application of WPTA

the field measurement results show that under two test conditions of 90% load and 75% load

the particulate removal efficiencies of WPTA is 53.05% and 71.11%

respectively. The particulate emission concentration is lower than 5 mg/m~3

the maximum mass of recovery water is 4.32 t/h and the maximum mass of heat recovery is 3.59 MW.

关键词

Keywords

references

浏览量

348

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

超低排放改造后烟气余热利用设备存在问题及防治措施

新形势下火电厂节水减排工作特点及关键

超低排放燃煤电厂引风机叶片硫酸盐沉积分析

600MW燃煤机组大气污染物超低排放技术应用

燃煤电厂氨法联合脱硫脱碳研究