EN不同太阳能热源下混合工质ORC系统性能分析
Performance Analysis of ORC System for Non-Zeotropic Mixtures Under Different Solar Energy Sources
- 发电技术 2018年39卷第2期 页码：177-187
- 作者机构：
华北电力大学国家火力发电工程技术研究中心, 北京市 昌平区 102206
- 作者简介：
[ "顾煜炯(1968), 男, 教授, 博士生导师, 主要研究方向为电站设备状态维修理论与技术、可再生能源的利用与开发, guyujiong@263.net" ]
[ "陈礼敏(1994), 女, 硕士研究生, 主要研究方向为中低温太阳能热发电有机朗肯循环系统" ]
[ "耿直(1991), 男, 博士研究生, 主要研究方向为太阳能热发电技术、有机朗肯循环及热力系统优化, huadiangengzhi@163.com" ]
- 基金信息：北京市自然科学基金(3172031);中央高校基本科研业务费专项资金(2016XS24);中央高校基本科研业务费专项资金(2017MS017)
DOI：10.12096/j.2096-4528.pgt.2018.028
中图分类号：收稿：2017-12-10，
纸质出版：2018-04-28
- 稿件说明：
移动端阅览
顾煜炯, 陈礼敏, 耿直. 不同太阳能热源下混合工质ORC系统性能分析[J]. 发电技术, 2018,39(2):177-187.
Yujiong GU, Limin CHEN, Zhi GENG. Performance Analysis of ORC System for Non-Zeotropic Mixtures Under Different Solar Energy Sources[J]. Power Generation Technology, 2018, 39(2): 177-187.
顾煜炯, 陈礼敏, 耿直. 不同太阳能热源下混合工质ORC系统性能分析[J]. 发电技术, 2018,39(2):177-187. DOI： 10.12096/j.2096-4528.pgt.2018.028.
Yujiong GU, Limin CHEN, Zhi GENG. Performance Analysis of ORC System for Non-Zeotropic Mixtures Under Different Solar Energy Sources[J]. Power Generation Technology, 2018, 39(2): 177-187. DOI： 10.12096/j.2096-4528.pgt.2018.028.
摘要
工质性质是影响有机朗肯循环(organic Rankine cycle，ORC)系统性能的重要因素之一。在不同热源温度下，对采用R601、R245fa作为组分的9种不同质量配比工质的ORC系统热力性和经济性进行计算，然后采用灰色关联法对系统性能进行分析及综合评价，并与纯工质的性能进行对比。研究表明，混合工质系统的热力学指标与温度滑移大小近似成反比。当温度滑移大于5K时，纯工质性能更优，且经济性也优于混合工质系统。综合来看，热源温度一定时，灰色关联度随着蒸发温度的升高呈现先增大后减小的趋势；混合工质R601/R245fa(0.1/0.9)的温度滑移最小，其性能也最优。采用R601和R245fa混合作为工质的系统在热源温度为160℃时，灰色关联度最大，系统性能更优。
Abstract
The characteristic of working fluids is one of the important factors that affect organic Rankine cycle (ORC) system.Under the different heat source temperature
11 substances were adopted as the subcritical ORC working fluids
R245fa and R601
as well as 9 non-zeotropic binary mixtures in different mass ratios.The thermal and economic model of the ORC had carried on the analysis.Finally
the method of grey correlation was used to evaluate the system performance.The study shows that the thermodynamic indexes of non-zeotropic binary mixtures are approximately inverse proportional to the temperature glides.When the temperature slip is greater than 5℃
the pure industrial performance is better.The system using the non-zeotropic mixtures is less economical than the pure working fluids.Incombination
when the heat source temperature is fixed
the grey correlation grade increases first and then decreases with the increase of evaporation temperature.The temperature glide of R601/R245fa(0.1/0.9) is the best and its performance is optimal.Using mixed R601 and R245fa as working fluid
system performance is best when the heat source temperature is 160℃.
关键词
Keywords
references
国家能源局. 国能新能[2016 ] 354号太阳能发展"十三五"规划[EB/OL ] . http://zfxxgk.nea.gov.cn/auto87/201612/t20161216_2358.htm http://zfxxgk.nea.gov.cn/auto87/201612/t20161216_2358.htm .
黄建新, 唐梓彭, 魏超.线聚光太阳能集热器发展综述[J].发电与空调, 2016, 37(1):21-25.
Huang Jianxin, Tang Zipeng, Wei Chao.A review of linear concentrated solar collectors' development[J].Power Machineryand Air Condition, 2016, 37(1):21-25(in Chinese).
Delgado-Torres A M, Garcia-Rodriguez L.Analysis and optimization of the low-temperature solar organic Rankine cycle(ORC)[J].Energy Conversion and Management, 2010, 51(12):2846-2856.
严晋跃, 路岭, 马一太, 等.循环工质与变温热源匹配的热力学分析[J].工程热物理学报, 1987(4):314-316.
Wang X D, Zhao L.Analysis of zeotropic mixtures used in low-temperature solar Rankine cycles for power generation[J].Solar Energy, 2009, 83:605-613.
Chen Huijuan, Goswami D Y, Rahman M M, et al.A supercritical Rankine cycle using zeotropic mixture working fluids for the conversion of low-grade heat into power[J].Energy, 2011, 36(1):549-555.
Li Yourong, Du Meitang, Wu Chunmei, et al.Potential of organic Rankine cycle using zeotropic mixtures as working fluids for waste heat recovery[J].Energy, 2014, 77(1):509-519.
Cayer E, Galanis N, Desilets M, et al.Analysis of a carbon dioxide transcritical power cycle using a low temperature source[J].Apply Energy, 2009, 86(7):1055-63.
Zhang Shengjun, Wang Huaixin, Guo Tao.Performance comparison and parametric optimization of subcritical organic Rankine cycle(ORC) and transcritical power cycle system for low-temperature geothermal power power generation[J].Applied Energy, 2011, 88(8):2740-2754.
Karellas S, Schuster A.Supercritical fluid parameters in organic rankine cycle applications[J].International Journal of Thermodynamics, 2008, 11(3):101-108.
Nafey A S, Sharaf M A.Combined solar organic Rankine cycle with reverse osmosis desalination process:Energy, exergy, and cost evaluations[J].Renewable Energy, 2010, 35(11):2571-2580.
Cayer E, Galanis N, Nesreddine H.Parametric study and optimization of a transcritical power cycle using a low temperature source[J].Applied Energy, 2010, 87(4):1349-1357.
Turton R, Bailie R C, Whiting W B, et al.Analysis, synthesis and design of chemical processes[M].Pearson Education, 2008.
Mago P J, Charmra L M, Sriivasan K, et al.An examination of regenerative organic cycle Rankine cycles using dry fluids[J].Applied Thermal Engineering, 2008, 28(8-9):998-1007.
王羽平, 汤磊, 杨平, 等.近(亚)临界有机物朗肯循环的性能分析[J].中国电机工程学报, 2014, 34(20):3251-3256.
Wang Yuping, Tang Lei, Yang Ping, et al.Characteristic Analysis of near-critical (subcritical) organic Rankine cycle[J].Proceedings of the CSEE, 2014, 34(20):3251-3256(in Chinese).
Heberle F, Preißinger M, Brüggemann D.Zeotropic mixtures as working fluids in Organic Rankine Cycles for low-enthalpy geothermal resources[J].Renewable Energy, 2012, 37(1):364-370.
郭亚军.综合评价理论与方法[M].北京:科学出版社, 2007.
刘思峰, 党耀国, 高志耕, 等.灰色系统理论及其应用[M].北京:科学出版社, 2004.
0
浏览量
0
下载量
0
CSCD
- 网络PDF下载
- Meta-XML下载
- BibTeX下载
- Endnote下载
- RefMan 下载
- NoteExpress下载
- NoteFirst下载
关联资源
相关文章
相关作者
相关机构
AI问答- 技术支持由北京北大方正电子有限公司提供 京ICP备09064830号-19
京公网安备11010802024621 - 本系统建议在Chrome、 IE9+ 以上版本浏览器阅读本站内容，360浏览器请切换至极速模式
- Cookies帮助我们提供服务并提供个性化体验。使用本网站，即表示您同意我们使用Cookies