EN电厂宽负荷运行下蒸汽喷射器对低温多效蒸馏系统的影响
Influence of Steam Ejector on Low-temperature Multi-effect Distillation System Under Wide Load Operation of Power Plant
- 发电技术 2020年41卷第4期 页码：369-377
- 作者机构：
1.神华国华(北京)电力研究院有限公司, 北京市 朝阳区 100025
2.动力工程多相流国家重点实验室(西安交通大学), 陕西省 西安市 710049
- 作者简介：
[ "张友森(1986), 男, 高级工程师, 主要从事海水淡化、水处理及两相流相关研究, zhangyousen@126.com" ]
[ "范江(1995), 男, 硕士研究生, 主要从事热力系统优化相关研究, 1179988030@qq.com" ]
[ "丁涛(1978), 男, 高级工程师, 主要从事低温多效海水淡化研究, 16850083@chnenergy.com.cn" ]
陈伟雄(1985), 男, 副教授, 博导, 主要研究方向为汽液两相流、强化传热和热力系统节能, 本文通信作者, chenweixiong@mail.xjtu.edu.cn
[ "赵舒然(1995), 男, 硕士研究生, 主要从事水处理、海水淡化及对流换热相关研究, 1346587682@qq.com" ]
[ "刘苗苗(1996), 女, 硕士研究生, 主要从事新一代热电联产系统研究, liumiao3@stu.xjtu.edu.cn" ]
- 基金信息：国家重点研发计划项目(2018YFB0604303)
DOI：10.12096/j.2096-4528.pgt.19167
中图分类号： TM621收稿：2019-11-25，
纸质出版：2020-08-31
- 稿件说明：
移动端阅览
张友森, 范江, 丁涛, 等. 电厂宽负荷运行下蒸汽喷射器对低温多效蒸馏系统的影响[J]. 发电技术, 2020,41(4):369-377.
Yousen ZHANG, Jiang FAN, Tao DING, et al. Influence of Steam Ejector on Low-temperature Multi-effect Distillation System Under Wide Load Operation of Power Plant[J]. Power Generation Technology, 2020, 41(4): 369-377.
张友森, 范江, 丁涛, 等. 电厂宽负荷运行下蒸汽喷射器对低温多效蒸馏系统的影响[J]. 发电技术, 2020,41(4):369-377. DOI： 10.12096/j.2096-4528.pgt.19167.
Yousen ZHANG, Jiang FAN, Tao DING, et al. Influence of Steam Ejector on Low-temperature Multi-effect Distillation System Under Wide Load Operation of Power Plant[J]. Power Generation Technology, 2020, 41(4): 369-377. DOI： 10.12096/j.2096-4528.pgt.19167.
摘要
淡水资源匮乏问题日益严重，火电厂耦合低温多效蒸馏（low-temperature multi-effect distillation，LT-MED）海水淡化技术因可有效降低制水成本而被广泛利用。利用Ebsilon软件对某电厂和低温多效蒸馏海水淡化耦合系统进行建模，分析了电厂宽负荷下蒸汽喷射器对水电联产系统热经济性的影响规律。研究结果表明：基于单级蒸汽喷射器的水电联产系统，以电厂75% THA工况设计下的蒸汽喷射器的性能最佳。对于带两级蒸汽喷射器的水电联产系统，当电厂负荷在75% THA工况时系统的制水电耗量相比单级蒸汽喷射器系统降低了13.65%，并且电厂负荷在50% THA工况以上时，带两级蒸汽喷射器系统的制水电耗量较单级蒸汽喷射器系统的低。
Abstract
The problem of lack of fresh water resources becomes more and more serious. The coupling of low-temperature multi-effect distillation (LT-MED) seawater desalination technology in thermal power plants is widely used
because it can effectively reduce the cost of water production. Ebsilon software was used to model the power plant and a LT-MED seawater desalination coupling system. The influences of steam ejectors on the thermal economy of the water and power cogeneration system under wide load were analyzed. The results show that the coupled system has the optimal performance for single-stage steam ejector at the 75% THA condition design of the power plant. For a cogeneration system with a two-stage steam ejector
the system's electricity loss for water production (ELWP) is reduced by 13.65% than the system with single-stage steam ejector
when the plant load is at 75% THA. And the two-stage steam's ELWP is also lower than that of the single stage steam ejector system when the plant load is above 50% THA.
关键词
Keywords
references
杨宝红.新形势下火电厂节水减排工作特点及关键[J].热力发电, 2016, 45(9):95-99.
Yang B H.Characteristics and key points of water saving and emission reduction in thermal power plants under the new situation[J].Thermal Power Generation, 2016, 45(9):95-99.
叶治安, 张江涛, 孙军峰, 等.沿海火电厂水岛设计及要点分析[J].中国电力, 2018, 51(12):180-184.
Ye Z A, Zhang J T, Sun J F, et al.Coastal thermal power plant water channel design and key points analysis[J].Electric Power, 2018, 51(12):180-184.
王琪, 郑根江, 谭永文.中国海水淡化工程运行状况[J].水处理技术, 2011, 37(10):12-14.
Wang Q, Zheng G J, Tan Y W.Operation status of China's seawater desalination project[J].Technology of Water Treatment, 2011, 37(10):12-14.
沈胜强, 杨洛鹏.低温多效蒸馏海水淡水-发电联产系统经济性分析[J].热能动力工程, 2006, 21(1):22-26.
Sheng S Q, Yang L P.Economic analysis of LT-MED of seawater freshwater-power generation cogeneration system[J].Thermal Power Engineering, 2006, 21(1):22-26.
周少祥.热电联产低温多效蒸馏海水淡化系统的节能分析[J].热能动力工程, 1997, 12(3):164-166.
Zhou S X.Energy-saving analysis of LT-MED system with combined heat and power[J].Thermal Power Engineering, 1997, 12(3):164-166.
柴晓军.电厂低温多效海水淡化系统优化设计[J].电力技术, 2010, 19(3):42-45.
Chai X J.Optimized design of LT-MED system in power plant[J].Electric Power Technology, 2010, 19(3):42-45.
杨洛鹏, 沈胜强, Klaus Genthner.低温多效海水淡化系统热力分析[J].化学工程, 2006, 34(11):20-24.
Yang L P, Sheng S Q, Klaus G.Thermal analysis of LT-MED system[J].Chemical Engineering, 2006, 34(11):20-24.
周士鹤, 郭亚丽, 沈胜强, 等.低温多效蒸发海水淡化装置中流动阻力对传热温差的影响[J].西安交通大学学报, 2015, 49(5):30-35.
Zhou S H, Guo Y L, Sheng S Q, et al.Influence of flow resistance on temperature difference of heat transfer in LT-MED unit[J].Journal of Xi'an Jiaotong University (Social Sciences), 2015, 49(5):30-35.
马露露, 代勇, 许家琪, 等.低温多效蒸馏海水淡化与热力发电厂联产方式选择[J].发电技术, 2015, 161(36):30-42.
Ma L L, Dai Y, Xu J Q, et al.LT-MED and selection of cogeneration of thermal power plant[J].Power Generation Technology, 2015, 161(36):30-42.
沈胜强, 孙甜悦, 刘晓华, 等.TVC在MED海水淡化装置中的作用和性能分析[J].热科学与技术, 2010, (9)2: 144-148.
Sheng S Q, Sun T Y, Liu X H, et al.Analysis of the function and performance of TVC in MED seawater desalination plant[J].Journal of Thermal Science and Technology, 2010, (9)2: 144-148.
解利昕, 王红菊, 王世昌.平流流程多效蒸馏海水淡化系统有效能分析[J].水处理技术, 2012, 38(11)::51-54.
Xie L X, Wang H J, Wang S C.Analysis of effective energy of seawater desalination system with multi-effect distillation in advection process[J].Technology of Water Treatment, 2012, 38(11):51-54.
Chen W X, Liu M, Chong D T, et al.A 1D model to predict ejector performance at critical and sub-critical operational regimes[J].International Journal of Refrigeration, 2013, 36(6):1750-1761.
高从堦, 阮国岭.海水淡化技术与工程[M].北京:化学工业出版社, 2016:113.
Gao C K, Ruan G L.Seawater desalination technology and engineering[M].Beijing, China:Chemical Industry Press, 2016:113.
孙小军, 庞毅, 桑俊珍, 等.低温多效海水淡化不同进料方式的造水比研究[J].热力发电, 2010, 39(5):108-112.
Sun X J, Pang Y, Sang J Z, et al.Study on water production ratio of different feed methods for LT-MED[J].Thermal Power Generation, 2010, 39(5):108-112.
徐海涛, 桑芝富.蒸汽喷射器喷射系数计算的热力学模型[J].化工学报, 2004, 55(5):704-710.
Xu H T, Sang Z F.Thermodynamic model for calculation of injection coefficient of steam ejector[J].Journal of Chemical Industry and Engineering (China), 2004, 55(5):704-710.
王永青.低温多效压汽蒸馏海水淡化系统热力分析[J].化学工程, 2010, 38(2):55-58.
Wang Y Q.Thermal analysis of low temperature multi-effect pressure steam distillation seawater desalination system[J].Chemical Engineering, 2010, 38(2):55-58.
0
浏览量
0
下载量
0
CSCD
- 网络PDF下载
- Meta-XML下载
- BibTeX下载
- Endnote下载
- RefMan 下载
- NoteExpress下载
- NoteFirst下载
关联资源
相关文章
相关作者
相关机构
AI问答- 技术支持由北京北大方正电子有限公司提供 京ICP备09064830号-19
京公网安备11010802024621 - 本系统建议在Chrome、 IE9+ 以上版本浏览器阅读本站内容，360浏览器请切换至极速模式
- Cookies帮助我们提供服务并提供个性化体验。使用本网站，即表示您同意我们使用Cookies