可再生能源电解水制氢系统电化学建模方法综述

谢桦; 胡一菡; 刘哲; 李海潮; 王锋

doi:doi:10.19912/j.0254-0096.tynxb.2024-2126

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

可再生能源电解水制氢系统电化学建模方法综述

更新时间：2026-07-22

- 可再生能源电解水制氢系统电化学建模方法综述
- Vol. 47, Issue 4, Pages: 561-574(2026)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：doi:10.19912/j.0254-0096.tynxb.2024-2126
  CLC： TQ116
- Online First：08 May 2026，
  
  Published：2026
- 稿件说明：
移动端阅览
谢桦, 胡一菡, 刘哲, et al. 可再生能源电解水制氢系统电化学建模方法综述[J]. 2026, 47(4): 561-574.
DOI：

谢桦, 胡一菡, 刘哲, et al. 可再生能源电解水制氢系统电化学建模方法综述[J]. 2026, 47(4): 561-574. DOI： doi:10.19912/j.0254-0096.tynxb.2024-2126.

摘要

构建合理的电化学模型是进行可再生能源电解水制氢系统规划和控制的基础。该文在调研电解水制氢技术发展现状的基础上

对碱性电解水制氢系统和质子交换膜电解水制氢系统的电化学建模方法进行梳理

旨在为可再生能源电解水制氢系统的规划与控制提供建模参考。首先

分别对不同工作条件下的电解水制氢系统稳态模型和动态模型建模方法进行总结;然后

对比分析各种电化学模型的场景适用性;最后

建议从模型参数适应性、动态机理及统一建模方法等方面开展研究

提升模型适应性。

Abstract

The accurate electrochemical model construction serves as the foundation for the planning and control of renewable energy-powered water electrolysis hydrogen production systems. Based on an investigation of the current development of water electrolysis hydrogen production technology

the electrochemical modeling methods for alkaline water electrolysis hydrogen production systems and proton exchange membrane water electrolysis hydrogen production systems are sorted out

aiming to provide modeling references for the planning and control of renewable energy-powered water electrolysis hydrogen production systems. Firstly

the modeling methods for steady and dynamic models of water electrolysis hydrogen production systems under different operating conditions are summarized respectively. Then

the scenario applicability of various electrochemical models is compared and analyzed. Finally

it is proposed to carry out research on aspects such as model parameter adaptability

electrolysis reaction dynamic mechanisms

and unified modeling methods to enhance model adaptability.

关键词

Keywords

references

周孝信, 赵强, 张玉琼, 等. “双碳”目标下我国能源电力系统发展趋势分析: 绿电替代与绿氢替代[J]. 中国电机工程学报, 2024, 44(17): 6707-6721.

YU L L, ZHANG L H, MENG G J, et al.Research on multi-objective reactive power optimization of power grid with high proportion of new energy[J]. IEEE access, 2022, 10: 116443-116452.

赵卓尧, 王鹏飞, 黄丹极, 等. 拉伸网流道结构对碱性水电解槽流动与电化学特性影响的模拟研究[J]. 工程科学学报, 2026, 48(3): 671-685.

宋洁, 郜捷, 梁丹曦, 等. 质子交换膜电解制氢系统建模研究综述[J]. 电力建设, 2024, 45(2): 58-78.

MAJUMDAR A, HAAS M, ELLIOT I, et al.Control and control-oriented modeling of PEM water electrolyzers: a review[J]. International journal of hydrogen energy, 2023, 48(79): 30621-30641.

OLIVIER P, BOURASSEAU C, BOUAMAMA P B.Low-temperature electrolysis system modelling: a review[J]. Renewable and sustainable energy reviews, 2017, 78: 280-300.

胡可崴, 李浩, 王创, 等. 电解水制氢的多物理场建模与监控技术综述[J]. 电力自动化设备, 2023, 43(12): 3-13.

DING D, WU H L, ZHANG S Q, et al.Review of electrolyser modeling in wind power and photovoltaic electrolysis for hydrogen production[C]//2023 IEEE 2nd International Power Electronics and Application Symposium (PEAS). Guangzhou, China, 2024: 1043-1046.

余紫薇, 孙丹, 刘一鸣, 等. 风电制氢系统阻抗建模及振荡特性分析[J]. 高电压技术, 2024, 50(1): 169-181.

黄启帆, 陈洁, 曹喜民, 等. 基于碱性电解槽和质子交换膜电解槽协同制氢的风光互补制氢系统优化[J]. 电力自动化设备, 2023, 43(12): 168-174.

袁铁江, 张江飞, 滕越. 基于虚拟同步机的新能源制氢系统协调控制策略[J]. 中国电机工程学报, 2025, 45(1): 163-174.

LIN Y F, FU L J.A study for a hybrid wind-solar-battery system for hydrogen production in an islanded MVDC network[J]. IEEE access, 2022, 10: 85355-85367.

ZHANG K, ZHOU B, OR S W, et al.Optimal coordinated control of multi-renewable-to-hydrogen production system for hydrogen fueling stations[J]. IEEE transactions on industry applications, 2022, 58(2): 2728-2739.

陈颖. 电解水制氢技术的研究现状及未来发展趋势[J]. 太阳能, 2024(1): 5-11.

冯江涵, 宋钫. 阴离子交换膜电解池的研究进展[J]. 化工进展, 2023, 42(7): 3501-3509.

YANG W H, YAN J, LIU S, et al.Macromolecular crosslink of imidazole functionalized poly(vinyl alcohol) and brominated poly(phenylene oxide) for anion exchange membrane with enhanced alkaline stability and ionic conductivity[J]. International journal of hydrogen energy, 2021, 46(74): 37007-37016.

陶智能, 邱彤, 王保国. 阴离子交换膜电解水制氢稳态建模[J]. 化工学报, 2025, 76(4): 1711-1721.

周京华, 孟祥飞, 陈亚爱, 等. 基于新能源发电的电解水制氢直流电源研究[J]. 太阳能学报, 2022, 43(6): 389-397.

胡致远, 程浩然, 夏杨红, 等. 碱液电解槽建模与宽范围运行控制[J]. 电力自动化设备, 2024, 44(11): 17-23.

ABDIN Z, WEBB C J, GRAY E M.Modelling and simulation of an alkaline electrolyser cell[J]. Energy, 2017, 138: 316-331.

TOGHYANI S, AFSHARI E, BANIASADI E, et al.Thermal and electrochemical performance assessment of a high temperature PEM electrolyzer[J]. Energy, 2018, 152: 237-246.

禹永帅, 刘永峰, 韩启沃, 等. PEMFC膜水含量及水传输综述[J]. 电池, 2025, 55(1): 146-152.

HUANG W T, ZHANG B H, GE L J, et al.Day-ahead optimal scheduling strategy for electrolytic water to hydrogen production in zero-carbon parks type microgrid for optimal utilization of electrolyzer[J]. Journal of energy storage, 2023, 68: 107653.

李志伟, 赵雨泽, 吴培, 等. 基于制氢设备精细建模的综合能源系统绿氢蓝氢协调低碳优化策略[J]. 电网技术, 2024, 48(6): 2317-2326.

GRIESSHABER W, SICK F.The self-sufficient solar house: remarkable simulation results[C]//ISES Solar World Congress, 1991, 3(1): 2559-2564.

ALI KHAN M, NIELSEN M R, GOLSORKHI M S, et al.Multiphysics modeling of electrolyzers under dynamic converter operation[J]. International journal of hydrogen energy, 2025, 176: 151478.

YANG Z L, YANG J, SUN H R, et al.Integrating multiphysics modeling and machine learning for enhanced efficiency and thermal management in PEM water electrolyzer systems[J]. Applied energy, 2025, 401: 126613.

ULLEBERG Ø.Stand-alone power systems for the future: optimal design, operation and control of solar-hydrogen energy systems[D]. Trondheim: Norwegian University of Science and Technology, 1998.

ULLEBERG Ø.Modeling of advanced alkaline electrolyzers: a system simulation approach[J]. International journal of hydrogen energy, 2003, 28(1): 21-33.

张腾飞. 碱性水电解制氢系统的建模分析与设计优化[D]. 北京: 北京化工大学, 2023.

YUAN T J, WANG J J, GUAN Y H, et al.Virtual inertia adaptive control of a doubly fed induction generator (DFIG) wind power system with hydrogen energy storage[J]. Energies, 2018, 11(4): 904.

潘泽铎, 钟炜. 风光互补发电制氢储能系统多目标优化研究[J]. 天津理工大学学报, 2024, 40(1): 37-43.

周行, 李少华, 王慧, 等. 光伏耦合电解水制氢系统的建模与仿真[J]. 南方能源建设, 2023, 10(3): 104-111.

范新桥, 张宽, 赵波, 等. 面向PEM电解制氢的虚拟同步控制技术研究[J]. 储能科学与技术, 2024, 13(11): 3949-3960.

KESERCIOĞLU M A, BOYACı SAN F G, SÖZBİR N, et al. Performance optimization of PEM electrolyzers: an experimental and Taguchi-based approach[J]. International journal of hydrogen energy, 2025, 152: 150214.

SÁNCHEZ M, AMORES E, RODRÍGUEZ L, et al. Semi-empirical model and experimental validation for the performance evaluation of a 15 kW alkaline water electrolyzer[J]. International journal of hydrogen energy, 2018, 43(45): 20332-20345.

张文韬, 周家辉, 徐钢, 等. 计及电解槽自保温的风光制氢系统研究[J]. 现代化工, 2024, 44(4): 204-208, 215.

张亚健, 陈茨, 薛飞, 等. 电制氢协同的含高比例光伏配电网两阶段电压随机优化控制[J]. 中国电力, 2024, 57(8): 23-35.

KUNTE A, NECHACHE A, KYRITSIS D C, et al.Effect of electrode structure on the energy efficiency and minimum load operation for pressurized alkaline water electrolysis: a numerical study[J]. Applied energy, 2025, 401: 126748.

MAREFATI S, ABDOLLAHPOUR A, MORTAZAVI M.Gas bubbles in proton exchange membrane electrolyzers, part i: mechanisms and effects[J]. Journal of power sources, 2025, 656: 238016.

KOUMI NGOH S, NJOMO D.An overview of hydrogen gas production from solar energy[J]. Renewable and sustainable energy reviews, 2012, 16(9): 6782-6792.

ZHENG Y, YOU S, BINDNER H W, et al.Optimal day-ahead dispatch of an alkaline electrolyser system concerning thermal-electric properties and state-transitional dynamics[J]. Applied energy, 2022, 307: 118091.

孙东阳, 于继轩, 阮俊霖, 等. 基于制氢装置效率特性的风储制氢电厂优化控制策略[J]. 电力自动化设备, 2023, 43(12): 53-61.

MARTINEZ D,ZAMORA R.Electrical implementations of an empirical electrolyser model for improved Matlab/Simulink simulations[J]. International journal of renewable energy research, 2019, 9(2): 1060-1070.

张春雁, 窦真兰, 徐桂芝, 等. PEM电解槽制氢多相传输及转化模型综述[J]. 电池, 2024, 54(4): 569-573.

徐衍会, 陈浩维, 胡俊杰. 光伏电解水制氢典型工况及质子交换膜电解堆性能衰减研究[J]. 电工技术学报, 2024, 39(19): 6228-6243.

柴海东, 任永峰, 云平平, 等. 构网型风氢耦合系统电解槽轮值优化控制[J]. 高压电器, 2024, 60(7): 12-22.

程浩然, 夏杨红, 何杭航, 等. 适用于可再生能源制氢的大容量碱液电解槽建模研究[J]. 太阳能学报, 2024, 45(2): 291-299.

JANG D, CHO H S, KANG S.Numerical modeling and analysis of the effect of pressure on the performance of an alkaline water electrolysis system[J]. Applied energy, 2021, 287: 116554.

HENAO C, AGBOSSOU K, HAMMOUDI M, et al.Simulation tool based on a physics model and an electrical analogy for an alkaline electrolyser[J]. Journal of power sources, 2014, 250: 58-67.

HAMMOUDI M, HENAO C, AGBOSSOU K, et al.New multi-physics approach for modelling and design of alkaline electrolyzers[J]. International journal of hydrogen energy, 2012, 37(19): 13895-13913.

LEROY R L, BOWEN C T, LEROY D J.The thermodynamics of aqueous water electrolysis[J]. Journal of the electrochemical society, 1980, 127(9): 1954-1962.

RODRÍGUEZ J, AMORES E. CFD modeling and experimental validation of an alkaline water electrolysis cell for hydrogen production[J]. Processes, 2020, 8(12): 1634.

GARCÍA-VALVERDE R, ESPINOSA N, URBINA A. Simple PEM water electrolyser model and experimental validation[J]. International journal of hydrogen energy, 2012, 37(2): 1927-1938.

ROY A, WATSON S, INFIELD D.Comparison of electrical energy efficiency of atmospheric and high-pressure electrolysers[J]. International journal of hydrogen energy, 2006, 31(14): 1964-1979.

ABDIN Z, WEBB C J, GRAY E M.Modelling and simulation of a proton exchange membrane (PEM) electrolyser cell[J]. International journal of hydrogen energy, 2015, 40(39): 13243-13257.

李岱泽, 熊树生, 姜琦, 等. 基于IGA-BP神经网络的PEMFC供氢系统模型预测控制算法[J]. 现代机械, 2024(5): 100-106.

BRAUNS J, TUREK T.Alkaline water electrolysis powered by renewable energy: a review[J]. Processes. 2020; 8(2): 248.

童灵华, 孙雷波, 应芳义, 等. PEM电解槽流场的多物理场耦合建模与分析[J]. 重庆理工大学学报(自然科学), 2023, 37(10): 303-311.

邵冲, 胡荣义, 余姣, 等. 考虑荷电与储氢状态的风光氢储系统动态控制仿真模型[J]. 中国电力, 2024, 57(7): 109-124.

胡开永, 赵培羽, 王志明. 光伏-PEM制氢系统建模及不同耦合方式性能对比分析[J]. 综合智慧能源, 2024, 46(9): 37-44.

ESPINOSA-LÓPEZ M, DARRAS C, POGGI P, et al. Modelling and experimental validation of a 46 kW PEM high pressure water electrolyzer[J]. Renewable energy, 2018, 119: 160-173.

韩鹏飞, 徐潇源, 王晗, 等. 基于功率-温度自适应控制的多堆质子交换膜电解制氢系统效率优化[J]. 电工技术学报, 2024, 39(7): 2236-2248.

李军舟, 赵晋斌, 曾志伟, 等. 具有动态调节特性的光伏制氢双阵列直接耦合系统优化策略[J]. 电网技术, 2022, 46(5): 1712-1720.

田雪沁, 姚红雨, 袁铁江, 等. 考虑动态调节特性的光伏直接耦合制氢系统容量优化配置[J]. 中国电机工程学报, 2025, 45(17): 6764-6777.

GU X F, YING Z, ZHENG X Y, et al.Photovoltaic-based energy system coupled with energy storage for all-day stable PEM electrolytic hydrogen production[J]. Renewable energy, 2023, 209: 53-62.

王润东, 黎静华, 韦善阳. 基于多物理场耦合模型的碱性水电解槽工作特性[J]. 高电压技术, 2024, 50(7): 3209-3220.

ADIBI T, SOJOUDI A, SAHA S C.Modeling of thermal performance of a commercial alkaline electrolyzer supplied with various electrical currents[J]. International journal of thermofluids, 2022, 13: 100126.

陈锦洲, 林飞, 何洪文, 等. 质子交换膜燃料电池/电解槽系统建模及负荷追踪策略[J]. 电工技术学报, 2020, 35(S2): 636-643.

郑博, 白章, 袁宇, 等. 多类型电解协同的风光互补制氢系统与容量优化[J]. 中国电机工程学报, 2022, 42(23): 8486-8495.

孔令国, 孙佳琦, 王士博, 等. 波动工况下PEM电解槽负荷一维机理建模及动态响应[J]. 中国电机工程学报, 2025, 45(13): 5074-5086.

YIGIT T, SELAMET O F.Mathematical modeling and dynamic Simulink simulation of high-pressure PEM electrolyzer system[J]. International journal of hydrogen energy, 2016, 41(32): 13901-13914.

OGUMEREM G S, PISTIKOPOULOS E N.Parametric optimization and control for a smart proton exchange membrane water electrolysis(PEMWE) system[J]. Journal of process control, 2020, 91: 37-49.

JIANG H Y, QI B Y, DU E S, et al.Modeling hydrogen supply chain in renewable electric energy system planning[J]. IEEE transactions on industry applications, 2022, 58(2): 2780-2791.

刘元, 肖碧涛, 卢昂, 等. 面向波动可再生能源的质子交换膜电制氢系统最优压强运行[J]. 电力自动化设备, 2024, 44(8): 210-217.

CORREA G, MAROCCO P, MUÑOZ P, et al. Pressurized PEM water electrolysis: dynamic modelling focusing on the cathode side[J]. International journal of hydrogen energy, 2022, 47(7): 4315-4327.

SHEN M Z, BENNETT N, DING Y L, et al.A concise model for evaluating water electrolysis[J]. International journal of hydrogen energy, 2011, 36(22): 14335-14341.

KIM H, PARK M, LEE K S.One-dimensional dynamic modeling of a high-pressure water electrolysis system for hydrogen production[J]. International journal of hydrogen energy, 2013, 38(6): 2596-2609.

FIRTINA-ERTIS I.Thermodynamic and electrochemical assessment of an alkaline electrolyzer (AE) at different operating parameters[J]. Journal of environmental chemical engineering, 2022, 10(2): 107225.

ABOMAZID A M, EL-TAWEEL N A, HANY E Z F. Electrochemical optimization model for parameters identification of PEM electrolyzer[C]//2020 IEEE Electric Power and Energy Conference (EPEC). Edmonton, AB, Canada, 2021: 1-5.

BIAKU C Y, DALE N V, MANN M D, et al.A semiempirical study of the temperature dependence of the anode charge transfer coefficient of a 6 kW PEM electrolyzer[J]. International journal of hydrogen energy, 2008, 33(16): 4247-4254.

KHAJURIA R, LAMBA R, KUMAR R.Optimal parameter identification of PEM electrolyzer using bald eagle search optimization algorithm[C]//2022 IEEE 10th Power India International Conference (PIICON). New Delhi, India, 2023: 1-6.

ABOMAZID A M, EL-TAWEEL N A, FARAG H E Z. Novel analytical approach for parameters identification of PEM electrolyzer[J]. IEEE transactions on industrial informatics, 2022, 18(9): 5870-5881.

SEE D M, WHITE R E.Temperature and concentration dependence of the specific conductivity of concentrated solutions of potassium hydroxide[J]. Journal of chemical & engineering data, 1997, 42(6): 1266-1268.

MA Z W, WITTEMAN L, WRUBEL J A, et al.A comprehensive modeling method for proton exchange membrane electrolyzer development[J]. International journal of hydrogen energy, 2021, 46(34): 17627-17643.

张潇桐, 戈阳阳, 姚红雨, 等. 基于粒子群算法的制氢电解槽运行控制策略[J]. 热力发电, 2023, 52(11): 115-122.

TOGHYANI S, FAKHRADINI S, AFSHARI E, et al.Optimization of operating parameters of a polymer exchange membrane electrolyzer[J]. International journal of hydrogen energy, 2019, 44(13): 6403-6414.

刘国永, 任永峰, 薛宇, 等. 基于PEM电解槽的风氢耦合系统能量管理研究[J]. 太阳能学报, 2024, 45(7): 240-248.

GÖRGÜN H. Dynamic modelling of a proton exchange membrane (PEM) electrolyzer[J]. International journal of hydrogen energy, 2006, 31(1): 29-38.

施正荣, 翁楚, 蔡靖雍, 等. 基于PV/T的质子交换膜电解制氢系统动态性能研究[J]. 太阳能学报, 2023, 44(8): 164-170.

李建林, 梁忠豪, 赵文鼎, 等. 混合电解槽制氢系统选型及评估方法[J]. 高电压技术, 2024, 50(6): 2653-2662.

戴凡博. PEM电解水制氢催化剂及直接耦合光伏发电系统建模研究[D]. 杭州: 浙江大学, 2020.

ABOMAZID A M, EL-TAWEEL N A, FARAG H E Z. Optimal energy management of hydrogen energy facility using integrated battery energy storage and solar photovoltaic systems[J]. IEEE transactions on sustainable energy, 2022, 13(3): 1457-1468.

李建林, 赵文鼎, 梁忠豪, 等. 基于混合电解槽制氢系统的功率分配技术[J]. 电力系统自动化, 2024, 48(13): 9-18.

王舜彦, 任永峰, 张小龙, 等. 基于混合电解槽自适应控制的光伏制绿氢系统研究[J]. 太阳能学报, 2024, 45(7): 20-28.

BELMOKHTAR K, DOUMBIA M L, AGBOSSOU K.Dynamic model of an alkaline electrolyzer based an artificial neural networks[C]//2013 Eighth International Conference and Exhibition on Ecological Vehicles and Renewable Energies (EVER). Monte Carlo, Monaco, 2013: 1-4.

HERNÁNDEZ-GÓMEZ Á, RAMIREZ V, GUILBERT D, et al. Development of an adaptive static-dynamic electrical model based on input electrical energy for PEM water electrolysis[J]. International journal of hydrogen energy, 2020, 45(38): 18817-18830.

GUILBERT D, VITALE G.Dynamic emulation of a PEM electrolyzer by time constant based exponential model[J]. Energies, 2019, 12(4): 750.

李建林, 张则栋, 李光辉, 等. 基于模型层级分析的质子交换膜电解槽建模研究进展[J]. 高电压技术, 2023, 49(3): 1105-1117.

KIM J H, OH C Y, KIM K R, et al.Parameter identification of electrical equivalent circuits including mass transfer parameters for the selection of the operating frequencies of pulsed PEM water electrolysis[J]. Energies, 2022, 15(24): 9303.

HOSSAIN M B, ISLAM M R, MUTTAQI K M, et al.Dynamic electrical circuit modeling of a proton exchange membrane electrolyzer for frequency stability, resiliency, and sensitivity analysis in a power grid[J]. IEEE transactions on industry applications, 2023, 59(6): 7271-7281.

夏杨红, 胡致远, 韦巍, 等. 可再生能源电解制氢宽范围运行控制策略[J]. 太阳能学报, 2024, 45(8): 34-43.

Views

157

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

多模式复合电解槽集群运行状态轮换控制策略

计及氢价指数影响的电制氢系统运行策略优化

OPERATION CONTROL OF RENEWABLE ENERGY/HYDROGEN PRODUCTION SYSTEM BASED ON MULTI-TERMINAL DC

RESEARCH PROGRESS ON RENEWABLE ENERGY SYSTEM COUPLED WITH LARGE-SCALE HYDROGEN PRODUCTION AND STORAGE

MODELING OF LARGE-CAPACITY ALKALINE ELECTROLYZERS FOR HYDROGEN PRODUCTION FROM RENEWABLE ENERGY

Related Author

谭清山

李珂

张横

喻翌

曾龙权

何为

孟涛

刘鸿鹏

Related Institution

Institute of Electrical Engineering Chinese Academy of Sciences

University of Chinese Academy of Sciences

China Electric Power Planning & Engineering Institute

College of Energy Engineering, Zhejiang University

Huadian Heavy Industries Co., Ltd.

AI问答

⁰