双螺旋管相变蓄热单元的实验研究及结构优化

燕燕; 刘泽澎; 曾丽萍; 贺颖; 李小华; 陈晓

doi:doi:10.19912/j.0254-0096.tynxb.2024-1999

您当前的位置：

首页 >

文章列表页 >

双螺旋管相变蓄热单元的实验研究及结构优化

更新时间：2026-04-08

- 双螺旋管相变蓄热单元的实验研究及结构优化
- Vol. 47, Issue 3, Pages: 525-534(2026)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：doi:10.19912/j.0254-0096.tynxb.2024-1999
  CLC： TK02
- Online First：07 April 2026，
  
  Published：2026
- 稿件说明：
移动端阅览
燕燕, 刘泽澎, 曾丽萍, et al. 双螺旋管相变蓄热单元的实验研究及结构优化[J]. 2026, 47(3): 525-534.
DOI：

燕燕, 刘泽澎, 曾丽萍, et al. 双螺旋管相变蓄热单元的实验研究及结构优化[J]. 2026, 47(3): 525-534. DOI： doi:10.19912/j.0254-0096.tynxb.2024-1999.

摘要

该文研究了复合相变材料在双螺旋管蓄热装置中的蓄热能力和相变过程。通过实验探究不同运行工况（流量与入口温度）对蓄热装置在熔化阶段的影响;采用数值模拟的方法探究蓄热单元内部温度场的演化

对蓄热单元结构进行优化

解决蓄热单元出现的熔化缓慢区域的问题。结果表明：流量的变化对复合相变材料熔化和功率的影响不大;入口温度对相变材料的熔化较明显

温度从80 ℃增大到90 ℃

复合相变材料的熔化时间缩短30.23%;最大储存能量为5.26 MJ。实验与模拟显示存在熔化缓慢区域

分析不同盘管直径与压缩比对蓄热单元热性能的影响。结果表明：当盘管直径为88 mm

压缩比为21∶10∶21时

蓄热单元换热更均匀

完全熔化时间缩短71.3%

平均热流密度提升42.5%

熔化缓慢区域在22578 s完全熔化。

Abstract

Phase change heat storage technology can solve the problem of solar energy intermittency and instability

and is a very promising energy storage technology. However

the efficiency of the heat storage unit is related to the phase change material and the heat transfer structure. In this paper

the heat storage capacity and phase change process of composite phase change materials in a double helical tube heat storage device were studied. The effects of different operating conditions （flow rate and inlet temperature） on the heat storage device in the melting stage were investigated by experiments. The numerical simulation method is used to explore the evolution of the temperature field inside the heat storage unit

and the structure of the heat storage unit is optimized to solve the problem of slow melting area in the heat storage unit. The results show that the change of flow rate has little effect on the melting and power of composite phase change materials. The inlet temperature has a significant effect on the melting of phase change materials. When the temperature increases from 80 ℃ to 90 ℃

the melting time of the composite phase change material is shortened by 30.23%. The maximum storage energy is 5.26 MJ. Experiments and simulations show that there is a slow melting zone. The effects of different coil diameters and compression ratios on the thermal performance of the heat storage unit are analyzed. The results show that when the coil diameter is 88 mm and the compression ratio is 21∶10∶21

the heat transfer of the heat storage unit is more uniform

the complete melting time is shortened by 71.3%

the average heat flux density is increased by 42.5%

and the slow melting zone is completely melted in 22578 s.

关键词

Keywords

references

肖强强. 光热转化相变材料的制备、性能及在太阳能热水系统中的应用[D]. 广州: 华南理工大学, 2020.

李晓滨, 程远达, 赵旭东, 等. 相变材料在太阳能热水系统中的应用研究综述[J]. 太原理工大学学报, 2018, 49(5): 691-697.

CESARI S, BACCEGA E, EMMI G, et al.Enhancement of a radiant floor with a checkerboard pattern of two PCMs for heating and cooling: results of a real-scale monitoring campaign[J]. Applied thermal engineering, 2024, 246: 122887.

蒋琼艳. 板式换热器结构优化及传热流动特性分析[D]. 济南: 山东大学, 2023.

WANG D B, ZHANG H R, WANG G H, et al.Experimental and numerical study on the heat transfer and flow characteristics of convex plate heat exchanger based on multi-objective optimization[J]. International journal of heat and mass transfer, 2023, 202: 123755.

侯俊英, 杨金星, 郝建军, 等. 十八醇/ZIF-8定形复合相变材料制备及其蓄热器模拟[J]. 太阳能学报, 2023, 44(11): 434-442.

于静梅, 刘耀鸿, 张凤忠, 等. 翅片强化相变储能蓄热性能的数值研究[J]. 太阳能学报, 2023, 44(6): 78-83.

徐裕民, 孙伟珂, 于哲, 等. 换热器螺旋管冷凝换热的数值模拟与实验研究[J]. 科学技术与工程, 2023, 23(32): 13845-13853.

方桂花, 刘颖杰, 王峰,等.基于螺旋盘管蓄热装置放热实验研究[J]. 太阳能学报, 2022, 43(12): 166-171.

LIU Z P, YAN Y, ZENG L P, et al.Experimental and numerical investigation of a double spiral tube heat exchanger in a novel composite phase change material[J]. Applied thermal engineering, 2025, 258: 124703.

WANG P L, YAO H, LAN Z P, et al.Numerical investigation of PCM melting process in sleeve tube with internal fins[J]. Energy conversion and management, 2016, 110: 428-435.

ZHANG J, ZHU X W, MONDEJAR M E, et al.A review of heat transfer enhancement techniques in plate heat exchangers[J]. Renewable and sustainable energy reviews, 2019, 101: 305-328.

WANG W W, WANG L B, HE Y L.Parameter effect of a phase change thermal energy storage unit with one shell and one finned tube on its energy efficiency ratio and heat storage rate[J]. Applied thermal engineering, 2016, 93: 50-60.

RAHIMI M, HOSSEINI M J, GORZIN M.Effect of helical diameter on the performance of shell and helical tube heat exchanger: an experimental approach[J]. Sustainable cities and society, 2019, 44: 691-701.

ZHENG X J, XIE N, CHEN C X, et al.Numerical investigation on paraffin/expanded graphite composite phase change material based latent thermal energy storage system with double spiral coil tube[J]. Applied thermal engineering, 2018, 137: 164-172.

LIU Z Y, XU K, QI L F, et al.A high efficiency electric heater based on dual-helical tube and screw-tape for instant water heating[J]. Applied thermal engineering, 2019, 160: 114018.

LIN W Z, LING Z Y, ZHANG Z G, et al.Experimental and numerical investigation of sebacic acid/expanded graphite composite phase change material in a double-spiral coiled heat exchanger[J]. Journal of energy storage, 2020, 32: 101849.

ANISH R, MARIAPPAN V, SURESH S, et al.Experimental investigation on the energy storage/discharge performance of xylitol in a compact spiral coil heat exchanger[J]. International journal of thermal sciences, 2021, 159: 106633.

CHEN Y H, WU Z X, ZHANG Y, et al.Numerical investigation of latent heat storage unit with dual helical tube[J]. Applied thermal engineering, 2024, 241: 122440.

徐裕民. 空调-热水器一体机螺旋管换热器的结构优化与实验研究[D]. 福州: 福建农林大学, 2023.

姜林欣, 李博. 结构特征对螺旋管换热器性能的影响[J]. 包装工程, 2020, 41(13): 197-203.

HWA J O, KYU M S, HYUN A S, et al.Heat transfer characteristics of the coil heat exchanger using helium according to the shape and mass flow rate change[J].Transactions of the Korean Society of Mechanical Engineers B, 2021, 45(2): 73-82.

杨先亮, 杜双庆, 袁威, 等. 不同压缩比螺旋翅片对相变储能罐蓄热的影响机制[J]. 太阳能学报, 2024, 45(9): 690-696.

毛前军, 曹燕. 非等距螺旋管壳式相变系统的蓄热性能研究[J]. 中南大学学报(自然科学版), 2022, 53(12): 4789-4798.

程家文, 曾丽萍, 生梦瑶, 等. MWCNTs-水合盐复合相变材料的蓄热性能研究[J]. 太阳能学报, 2023, 44(8): 10-16.

CHENG J W, SHENG M Y, ZENG L P, et al.Thermal energy storage properties of carbon nanotubes/sodium acetate trihydrate/sodium monohydrogen phosphate dodecahydrate composite phase-change materials as promising heat storage materials[J]. Applied thermal engineering, 2023, 228: 120469.

LIN W Z, LING Z Y, FANG X M, et al.Experimental and numerical research on thermal performance of a novel thermal energy storage unit with phase change material[J]. Applied thermal engineering, 2021, 186: 116493.

LIU Z P, ZENG L P, SHENG M Y, et al.Experimental and numerical research on thermal characteristics of phase change thermal storage device[J]. Case studies in thermal engineering, 2024, 58: 104358.

SARRAFHA H, KASAEIAN A, JAHANGIR M H, et al.Transient thermal response of multi-walled carbon nanotube phase change materials in building walls[J]. Energy, 2021, 224: 120120.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

INFLUENCE MECHANISM OF SPIRAL FINS OF DIFFERENT COMPRESSION RATIO ON HEAT STORAGE OF PHASE-CHANGE ENERGY STORAGE TANK

不同压缩比螺旋翅片对相变储能罐放热的影响机制

基于瞬态模拟的中置蓄热式Trombe墙热性能分析

STUDY ON HEAT TRANSFER CHARACTERISTICS OF MULTISTAGE PHASE CHANGE MATERIALS VENTILATION CEILING FOR SOLAR HEATING

TEMPERATURE CONTROL CHARACTERISTICS AND HEAT DISSIPATION STRUCTURE OPTIMIZATION DESIGN OF PHOTOVOLTAIC PHASE CHANGE SYSTEM

Related Author

Yang Xianliang

Du Shuangqing

Yuan Wei

Qiu Yulong

袁威

韩瑞元

杜双庆

杨先亮

Related Institution

Hebei Key Laboratory of Low Carbon and High Efficiency Power Generation Technology, North China Electric Power University

School of Energy Power and Mechanical Engineering, North China Electric Power University

State Key Laboratory of Green Building in Western China

School of Building Equipment Science and Engineering, Xi'an University of Architecture and Technology

School of Chemical Engineering/Xi'an Key Laboratory of Special Energy Materials, Northwest University

AI问答

⁰