基于生物柴油重整的燃料电池发电系统性能研究

刘洋; 谢俊恩; 陈志超; 修心岩; 于淏名; 秦江

doi:doi:10.19912/j.0254-0096.tynxb.2024-1685

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

基于生物柴油重整的燃料电池发电系统性能研究

更新时间：2026-03-06

- 基于生物柴油重整的燃料电池发电系统性能研究
- Vol. 47, Issue 2, Pages: 626-632(2026)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：doi:10.19912/j.0254-0096.tynxb.2024-1685
  CLC： TK91
- Online First：05 March 2026，
  
  Published：05 March 2026
- 稿件说明：
移动端阅览
刘洋, 谢俊恩, 陈志超, et al. 基于生物柴油重整的燃料电池发电系统性能研究[J]. 2026, 47(2): 626-632.
DOI：

刘洋, 谢俊恩, 陈志超, et al. 基于生物柴油重整的燃料电池发电系统性能研究[J]. 2026, 47(2): 626-632. DOI： doi:10.19912/j.0254-0096.tynxb.2024-1685.

摘要

提出一种基于生物柴油重整的燃料电池发电系统

通过建模仿真计算

研究水碳比、蒸汽重整温度、燃料电池燃料利用率等参数对系统性能的影响

并基于优化算法得到系统最佳工作点。结果表明：降低水碳比会同时提高重整气内H2和CO浓度;提高燃料电池燃料利用率能够有效提高系统效率

但过高燃料利用率会产生用于进料预热的额外功率损耗;发电系统额定功率下的最大工作效率为42.21%

在耗油率和碳排放量方面相较柴油发动机均有较大改善。

Abstract

The paper proposes a fuel cell power generation system based on biodiesel reforming. The effects of parameters such as water-carbon ratio

steam reforming temperature

and fuel cell fuel utilization rate on the system performance are investigated through modelling and simulation calculations. Afterwards

the optimal working point of the system is obtained based on an optimization algorithm. The results show that： lowering the steam-carbon ratio increases both H and CO concentrations in the reformed gas; increasing the fuel utilization rate of the fuel cell effectively improves the system efficiency

but excessively high a fuel utilization rate results in additional power loss for feed preheating; the maximum efficiency of the power generation system at rated power is 42.21%

and the power generation system has improved in terms of fuel consumption and carbon emission compared with the diesel engine.

关键词

Keywords

references

曹湘洪. 氢能开发与利用中的关键问题[J]. 石油炼制与化工, 2017, 48(9): 1-6.

朱秀珠, 纪亚琨, 孙明汉. 全球燃料电池创新态势演变: 基于“国家-企业-专利”多模网络视角[J]. 太阳能学报, 2023, 44(12): 471-480.

袁斌, 潘建欣, 王傲, 等. 燃料电池用柴油重整制氢技术现状与展望[J]. 化工进展, 2020, 39(S1): 107-115.

肖周荣, 李国柱, 王涖, 等. 液体碳氢燃料蒸汽重整制氢催化剂研究进展[J]. 化工进展, 2022, 41(S1): 97-107.

MA F R, HANNA M A.Biodiesel production: a review[J]. Bioresource technology, 1999, 70(1): 1-15.

尧命发, 庞阔, 谷静波, 等. 正丁醇/生物柴油高预混压燃燃烧及排放特性的试验[J]. 内燃机学报, 2013, 31(3): 193-199.

陈冠益, 夏晒歌, 李婉晴, 等. 面向碳中和的生物柴油制备及应用研究进展[J]. 太阳能学报, 2022, 43(9): 343-353.

MARTIN S, WÖRNER A. On-board reforming of biodiesel and bioethanol for high temperature PEM fuel cells: comparison of autothermal reforming and steam reforming[J]. Journal of power sources, 2011, 196(6): 3163-3171.

NAHAR G A.Hydrogen rich gas production by the autothermal reforming of biodiesel(FAME) for utilization in the solid-oxide fuel cells: a thermodynamic analysis[J]. International journal of hydrogen energy, 2010, 35(17): 8891-8911.

WU H W, LIN K W.Thermodynamic analysis of hydrogenrich syngas production with a mixture of aqueous urea and biodiesel[J]. International journal of hydrogen energy, 2018, 43(14): 6804-6814.

LIAO C H, CHEIN R.Thermodynamic analysis of syngas production from biodiesel via chemical looping reforming[J]. International journal of hydrogen energy, 2021, 46(31): 16591-16602.

AUTHAYANUN S, MAMLOUK M, ARPORNWICHANOP A.Maximizing the efficiency of a HT-PEMFC system integrated with glycerol reformer[J]. International journal of hydrogen energy, 2012, 37(8): 6808-6817.

SCOTT K, MAMLOUK M.A cell voltage equation for an intermediate temperature proton exchange membrane fuel cell[J]. International journal of hydrogen energy, 2009, 34(22): 9195-9202.

WU W, ZHAI C, SUI Y R, et al.A novel distributed energy system using high-temperature proton exchange membrane fuel cell integrated with hybrid-energy heat pump[J]. Energy conversion and management, 2021, 235: 113990.

KIM J, KIM M, KANG T, et al.Degradation modeling and operational optimization for improving the lifetime of high-temperature PEM(proton exchange membrane) fuel cells[J]. Energy, 2014, 66: 41-49.

GUO X R, ZHANG H C.Performance analyses of a combined system consisting of high-temperature polymer electrolyte membrane fuel cells and thermally regenerative electrochemical cycles[J]. Energy, 2020, 193: 116720.

陈家城, 周苏. 大功率质子交换膜燃料电池建模及仿真[J]. 太阳能学报, 2024, 45(3): 290-297.

GUO X R, ZHANG H C, GUO Y M, et al.A novel triple-cycle system based on high-temperature proton exchange membrane fuel cell, thermoelectric generator, and thermally regenerative electrochemical refrigerator for power and cooling cogeneration[J]. International journal of energy research, 2022, 46(6): 7529-7541.

COLLINS-MARTINEZ V, ESCOBEDO BRETADO M, MELÉNDEZ ZARAGOZA M, et al. Absorption enhanced reforming of light alcohols (methanol and ethanol) for the production of hydrogen: thermodynamic modeling[J]. International journal of hydrogen energy, 2013, 38(28): 12539-12553.

刘禾, 秦江, 郭发福, 等. 基于吸附强化重整制氢的燃料电池-涡轮混合发电系统性能研究[J]. 工程热物理学报, 2022, 43(9): 2340-2346.

李成杰, 王紫璇, 哈婵, 等. 基于甲醇燃料的航空燃料电池内燃机混合动力系统性能分析[J]. 推进技术, 2024, 45(3): 122-130.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

太阳能辐射数据驱动下光电催化与光伏电解协同制氢的地区适应性分析

直接电加热的SiC泡沫乙醇水蒸气催化重整制氢的数值模拟

基于改进APO-SVMD的海上风电场混合储能容量配置

基于风电制氧的纯氧燃烧减碳系统多场景容量优化配置

光伏耦合制氢系统中电解槽机组协调运行策略

Related Author

党静

戚萌

朱涛林

赵旭扬

邓子健

刘义

宋旭

鲍泽威

Related Institution

College of Chemical Engineering of Zhengzhou University

1,2),Wang Jihui~3,Li Zhaojing~3,Zhou Wei~

同济大学新能源汽车工程中心

华东理工大学资源与环境工程学院

同济大学汽车学院

AI问答

⁰