Progresses on experimental techniques of hypersonic and high-enthalpy wind tunnels

JIANG Zonglin

doi:10.7638/kqdlxxb-2019.0009

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

Progresses on experimental techniques of hypersonic and high-enthalpy wind tunnels

更新时间：2026-05-28

- Progresses on experimental techniques of hypersonic and high-enthalpy wind tunnels
- Vol. 37, Issue 3, Pages: 347-355(2019)
- 作者机构：
  
  1. 中国科学院力学研究所高温气体动力学国家重点实验室,北京,100190
  2. 中国科学院大学工程科学学院宇航工程科学系,北京,100049
- 作者简介：
- 基金信息：
- DOI：10.7638/kqdlxxb-2019.0009
  CLC： V211.7
- Published：2019
- 稿件说明：
移动端阅览
姜宗林. 高超声速高焓风洞试验技术研究进展[J]. 空气动力学学报, 2019, 37(3): 347-355.

JIANG Zonglin. Progresses on experimental techniques of hypersonic and high-enthalpy wind tunnels[J]. 2019, 37(3): 347-355.
姜宗林. 高超声速高焓风洞试验技术研究进展[J]. 空气动力学学报, 2019, 37(3): 347-355. DOI： 10.7638/kqdlxxb-2019.0009.

JIANG Zonglin. Progresses on experimental techniques of hypersonic and high-enthalpy wind tunnels[J]. 2019, 37(3): 347-355. DOI： 10.7638/kqdlxxb-2019.0009.

摘要

高焓风洞及其试验技术是助力人类进入高超声速飞行时代的基石，近年来取得了长足的进展。本文首先重点介绍了四种典型驱动模式的高焓风洞，即直接加热型高超声速风洞、加热轻气体驱动激波风洞、自由活塞驱动激波风洞和爆轰驱动激波风洞。通过这些代表性风洞的介绍，讨论了相关风洞的理论基础和关键技术及其长处与不足。由于高超声速高焓流动具高温热化学反应特征，风洞试验技术研究还包含着针对高焓特色的测量技术发展。本文介绍了三种主要测量技术：气动热测量技术、气动天平技术和光学测量技术。这些技术是依据常规风洞试验测量需求而研制的，又根据高焓风洞的特点得到了进一步的改进和完善。最后对高超声速高焓风洞试验技术发展做了简单展望。

Abstract

The development of high enthalpy wind tunnel and its test technology are the cornerstone to help mankind enter the hypersonic era

and the great progress has been achieved in recent years. High enthalpy wind tunnels with four typical driving modes are introduced. Those are the air-directly-heated hypersonic wind tunnel

the light-gas-heated shock tunnel

the free-piston-driven shock tunnel

and the detonation-driven shock tunnel. Theories and critical techniques for developing these wind tunnels are introduced

and their merits and weakness are discussed based on tunnel performance evaluation. The measurement techniques are usually included into wind tunnel techniques because that the hypersonic and high-enthalpy flow is a chemically-reacting gas motion and its diagnose needs specially-designed instruments. Three measuring techniques are introduced here

including aerodynamic heat flux sensors

aerodynamic balances

and optical diagnose techniques. These techniques were usually developed for conventional hypersonic wind tunnels and combustion research

and are further improved to measure the hypersonic and high-enthalpy flows. The prospect for developing the experimental techniques of hypersonic and high-enthalpy wind tunnels is presented from author's point view.

关键词

Keywords

references

TSIEN H S. Similarity laws of hypersonic flows[J]. J Math Phys, 1946, 25:247-251.

BERTIN J J, CUMMINGS R M. Fifty years of hypersonics:where we've been, where we're going[J]. Progress in Aerospace Sciences, 2003, 39:511-536.

LU F K, MARREN D E. Advanced hypersonic test facilities[J]. Progress in Astronautics and Aeronautics, 1971, (1):64.

ANDERSON J D. Hypersonic and high temperature gas dynamics[M]. McGraw-Hill Book Company, New York, 1989.

BERTIN J J, CUMMINGS R M. Critical hypersonic aerothermodynamic phenomena[J]. Annu Rev Fluid Mech, 2006, 38:129-157.

钱学森.我对今日力学的认识[J].力学与实践, 1995, 17(4):1.

ROMERE P O, KANIPE D B, YOUNG J C, et al. Space shuttle entry aerodynamic comparison of flight preflight predictions[J]. Journal of Spacecraft and Rockets, 1983, 20(1):15-21.

DUMM M G, MOLLER J C, STEELE R C. Development of a new high-enthalpy shock tunnel[R]. AIAA 88-2782, 1988.

HOLDEN M S. Recent advances in hypersonic test facilities and experimental research[R]. AIAA 93-5005, 1993.

HOLDEN M S, WADHAMST P, CANDLER G V. A review of experimental studies in the LENS shock tunnel and expansion tunnel to examine real-gas effects in hypervelocity flows[R]. AIAA 2004-0916, 2004.

HOLDEN M S, CHADWICK K M, KOLLY J M. Hypersonic studies in the LENS facilities[R]. AIAA 95-6040, 1995.

STALKER R J. A study of the free-piston shock tunnel[J]. AIAA J, 1967, 5:2160-2165.

STALKER R T, MORRSON W R D. New generation of free piston shock tunnel facilities[C ] //Proceeding of 17 th International Symposium on Shock Tube and Waves. Bethem, 1989.

HORNUNG H G. The piston motion in a free-piston driver for shock tubes and tunnels[R]. GALCIT Rep. FM88-1, 1988.

HORNUNG H G. Performance data of the new free-pistonshock tunnel at GALCIT[R]. AIAA 92-3943, 1992.

EITELBERG G. First results of calibration and use of theHEG[R]. AIAA 94-2525, 1994.

MIYAJIMA H. Design concept of the NAL/NASDA high-enthalpy shock tunnel[C]//4th Int Workshop on Shock Tube Technologies.

ITOH K, et al. Improvement of a free piston driverfor a high-enthalpy shock tunnel[J]. Shock Waves, 1998, 8(4):215-233.

EITELBEG G. First results of calibration and use of the HEG[R]. AIAA 94-2525, 1994.

HORNUNG H G, CUMMINGS E B, et al. Recent results from hypervelocity research in T5[R]. AIAA 94-2523, 1994.

ITOH K, UEDA S, et al. Improvement of a free piston driver for a high-enthalpy shock tunnel[J]. Shock Waves, 1998, 8(4):215-233.

ITOH K, UEDA S, et al. Hypersonic aerothermodynamic and scramjet research using high-enthalpy shock tunnel[J]. Shock Waves, 2002, 12:93-98.

BIRD G A. A note on combustion driven tubes. royal aircraft establishment[R]. AGARD Report 146, 1957.

COATES P B, GAYDON A G. A simple shock tube with detonating driver gas[C]//Proc Roy Soc London, 1965, A283: 18-32.

YU H, ZHAO W, et al. Performence of shock tunnel with H 2 -O 2 detonation driver[J ] . Aerodynamic Experiment and Measurement and Control, 1993, 7(3):3, 38-42. (in Chinese)

张欣玉, 俞鸿儒, 赵伟, 等.氢氧爆轰直接起始的射流点火方法研究[J].气动实验与测量控制, 1996, 10(2):63-68.

赵伟, 李仲发, 谷笳华, 等.氢氧爆轰波与界面的相互作用[J].气动实验与测量控制, 1996, 10(2):41-46.

ZHAO W, YU H. The double over-critical nozzles device for filling and mixing mixture gases[J]. Acta Aerodynamica Sinica, 1999, 17(3):279-284.

ZHAO W, JIANG Z L, et al. Performance of a detonation driven shock tunnel[J]. Shock Waves, 2005, 14:53-59.

YU H R, CHEN H, ZHAO W. Advances in detonation driving techniques for a shock tube/tunnel[J]. Shock Waves, 2006, 15(6):399-405.

YU H R, ESSER B, LENARTZ M, et al. Gaseous detonation driver for a shock tunnel[J]. Shock Waves, 1992, 2:245-254.

HABERMANN M, OLIVIER H, GRONG H. Operation of a high performance detonation driver in upstream propagation mode for a hypersonic shock tunnel[C ] //Proceedings of the 22 nd International Symposium on Shock Waves, 1999, 1: 447-452.

ERDOS J I, CALLEJA J, TAMAGNO J. Increases in the hypervelocity test envelope of the hypulse shock-expansion tube[R]. AIAA 94-2524, 1994.

BAKOS R J, ERDOS J I. Options for enhancement of the performance of shock-expansion tubes and tunnels[R]. AIAA 95-0799, 1995.

JIANG Z L, YU H R, TAKAYAMA K. Investigation into converging gaseous detonation drivers. ball, hillier and roberts (eds) shock waves[C]//Proceedings of ISSW22. London, UK, 1999.

JIANG Z L, ZHAO W, WANG C. Forward-running detonation drivers for high-enthalpy shock tunnels[J]. AIAA Journal, 2002, 40:2009-2016.

JIANG Z L, LIN J, ZHAO W. Performance tests of JF-10 high-enthalpy shock tunnel with a FDC driver[J]. International Journal of Hypersonics, 2011, 2:29-35.

陈宏, 冯珩, 俞鸿儒.用于激波管/风洞的双爆轰驱动段[J].中国科学(G辑), 2004, 34(2):183-191.

JIANG Z, LI J, ZHAO W, et al. Investigating into techniques for extending the test-duration of detonation-driven shock tunnels[J]. Chinese Journal of Theoretical and Applied Mechanics, 2012, 44(5):824-831. (in Chinese)

SCHULTZ D L, JONES T V. Heat-transfer measurements in short-duration hypersonic facilities[R]. AGARD AG-163, 1973.

YU H, LI Z F, LI J, et al. Plug copper foil calorimeter for heat transfer measurement in shock tube wind tunnel[J]. Advances in Mechanics, 1976, 6(4):117-126. (in Chinese)

BUTTSWORTH D R. Assessment of effective thermal product of surface junction thermocouples on millisecond and microsecond time scales[J]. Experimental Thermal and Fluid Science, 2001, 25:409-420.

HE D X. Wind tunnel balance[M]. Beijing:National Defence Industry Press, 2001.

杨耀栋, 王复.用于脉冲风洞的有惯性补偿的三分量压电天平[J].气动实验测控技术, 1982, 2.

BERNSTEIN L. Force measurement in short-duration hypersonic facilities[R]. AGARD AG-214, 1975.

JIANG Z, YU H. Theories and technologies for duplicating hypersonic flight conditions for ground testing[J]. National Science Review, 2017, 4(3):290-296.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical simulation on formation process of high-enthalpy flow fields in hydrogen-driven shock tunnels

Investigation on the shape optimization of wide-envelop air-breathing hypersonic vehicle

Aerodynamic design optimization of wide-Mach-number-range airfoils for hypersonic vehicles

Prediction of aerodynamic characteristics of hypersonic vehicle by improved k-ω-γ transition model

The hypersonic boundary-layer transition: a perspective from the view of system design

Related Author

XU Hailun

SHEN Zhihao

KONG Xiaoping

WU Xuanyu

GONG Chunlin

WANG Qiang

WEI Zhen

MU Huan

Related Institution

School of Civil Engineering and Architecture, Southwest University of Science and Technology, Mianyang

National Key Laboratory of Aerospace Physics in Fluids, China Aerodynamics Research and Development Center, Mianyang

Shanxi Aerospace Flight Vehicle Design Key Laboratory, School of Astronautics, Northwestern Polytechnical University, Xi’an

Beijing Electro-mechanical Engineering Institute, Beijing

Institute of Aerodynamic and Multidisciplinary Design Optimization, Northwestern Polytechnical University, Xi'an

AI问答

⁰