Experimental Study on Emission Characteristics of W-flame Pulverized Coal Boiler Under Multi-sound Source Excitation

YANG Yanfeng; MA Jiwei; LIU Liang; YANG Yang; LIANG Jianguo

doi:10.19805/j.cnki.jcspe.2025.240508

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

Experimental Study on Emission Characteristics of W-flame Pulverized Coal Boiler Under Multi-sound Source Excitation

更新时间：2026-07-15

- Experimental Study on Emission Characteristics of W-flame Pulverized Coal Boiler Under Multi-sound Source Excitation
- Chinese Journal of Power Engineering Vol. 45, Issue 11, Pages: 1787-1794(2025)
- 作者机构：
  
  1. 长沙理工大学能源与动力工程学院,湖南,长沙,410114
  2. 阳城国际发电有限责任公司,山西,晋城,048100
- 作者简介：
- 基金信息：
- DOI：10.19805/j.cnki.jcspe.2025.240508
  CLC：
- Online First：17 November 2025，
  
  Published：17 November 2025
- 稿件说明：
移动端阅览
杨延锋,马继伟,刘亮,杨洋,梁建国. 多声源激励下W型煤粉锅炉排放特性试验研究动力工程学报, 2025, 45(11): 1787-1794 https://doi.

org/10.19805/j.cnki.jcspe.2025.240508
杨延锋,马继伟,刘亮,杨洋,梁建国. 多声源激励下W型煤粉锅炉排放特性试验研究动力工程学报, 2025, 45(11): 1787-1794 https://doi. DOI： 10.19805/j.cnki.jcspe.2025.240508.

org/10.19805/j.cnki.jcspe.2025.240508 DOI：

摘要

为探究多声源协同作用下W型煤粉锅炉的排放特性

对机组负荷稳定在265 MW(额定负荷为350 MW)下的W型煤粉锅炉进行声波影响燃烧的试验研究。在锅炉主燃区和燃尽区分别布置12台和4台声波激励装置

在单台电机频率均为35 Hz下按组循环投运

进气压力控制在0.35~0.47 MPa。结果表明

与未投运声波激励装置相比

脱硫装置进口烟气中SO

质量浓度下降0.2%

但脱硝塔A、B侧进口NO

质量浓度分别上升约29.65、22.31 mg/m

;锅炉热效率提高0.53百分点

飞灰含碳量(质量分数)下降1.55百分点。在炉膛内加入声场作用能够强化煤粉的燃烧强度和提高锅炉热效率。

Abstract

To investigate the emission characteristics of a W-flame pulverized coal boiler under multi-sound source excitation

an experimental study on the combustion influence of acoustic waves was conducted on a W-flame pulverized coal boiler with its unit load stabilized at 265 MW (with a rated load of 350 MW). Twelve and four acoustic excitation devices were arranged respectively in the primary combustion zone and the burnout zone of the boiler. Above devices were operated in cyclic groups with each individual motor operating at a frequency of 35 Hz

and the inlet air pressure was controlled within the range of 0.35 to 0.47 MPa. Results show that

compared with the operation condition without acoustic excitation device

the SO

mass concentration in the inlet flue gas of desulfurization device is decreased by 0.2%

while the NO

mass concentrations at A and B side inlets of denitration tower were increased by approximately 29.65 and 22.31 mg/m

respectively. Additionally

the boiler thermal efficiency is improved by 0.53 percentage points

and the carbon content (mass fraction) of fly ash is decreased by 1.55 percentage points. By adding an acoustic field within the furnace

the combustion intensity of pulverized coal can be enhanced and the thermal efficiency of boiler can be improved.

关键词

Keywords

references

吕清刚, 李诗媛, 黄粲然. 工业领域煤炭清洁高效燃烧利用技术现状与发展建议[J]. 中国科学院院刊, 2019, 34(4): 392-400. LYU Qinggang, LI Shiyuan, HUANG Canran. Current situation and development suggestions of coal clean and efficient combustion technology in industry field[J]. Bulletin of Chinese Academy of Sciences, 2019, 34(4): 392-400.

王志轩, 张晶杰, 董博, 等. "双碳"目标下燃煤电厂灵活性改造及政策建议[J]. 电力科技与环保, 2024, 40(3): 213-220. WANG Zhixuan, ZHANG Jingjie, DONG Bo, et al. Research on technology and policy of flexibility renovation for coal-fired power plants under carbon peaking and carbon neutrality goal[J]. Electric Power Technology and Environmental Protection, 2024, 40(3): 213-220.

白旭东, 王建勋. 330 MW锅炉配风方式对NO x 排放浓度和锅炉经济性的影响分析[J ] . 化工进展, 2021, 40(增刊2): 25-29. BAI Xudong, WANG Jianxun. Experimental research of influence of air distribution for a W-flame boiler on NO x emission and economical operation[J ] . Chemical Industry an d Engineering Progress, 2021, 40(Sup2): 25-29.

陈辉, 赖金平, 戴维葆, 等. 贫煤锅炉全烧烟煤燃烧器改造技术研究[J]. 电力学报, 2024, 39(2): 101-110. CHEN Hui, LAI Jinping, DAI Weibao, et al. Study on the transformation technology of bituminous coal burner in lean coal boiler[J]. Journal of Electric Power, 2024, 39(2): 101-110.

杨延锋, 姜根山, 刘亮, 等. 声波对煤粉燃烧特性的影响: 研究进展与展望[J]. 煤炭学报, 2023, 48(10): 3895-3911. YANG Yanfeng, JIANG Genshan, LIU Liang, et al. Research progress and prospects on the influence of sound waves on the combustion characteristics of coal powder[J]. Journal of China Coal Society, 2023, 48(10): 3895-3911.

TYNDALL J. XIV. On sounding and sensitive flames[J]. Philosophical Magazine Science, 1867, 33(221): 92-99.

张玉涛, 林国铖, 张园勃, 等. 横向声波作用下油池火焰燃烧行为模拟[J]. 燃烧科学与技术, 2023, 29(4): 381-389. ZHANG Yutao, LIN Guocheng, ZHANG Yuanbo, et al. Simulation of combustion behavior of pool flame under transverse acoustic wave[J]. Journal of Combustion Science and Technology, 2023, 29(4): 381-389.

SEVILLA-ESPARZA C I, WEGENER J L, TESHOME S, et al. Droplet combustion in the presence of acoustic excitation[J]. Combustion and Flame, 2014, 161(6): 1604-1619.

LOU Peng, GUO Hui, YE Yanghui, et al. Influence of phase of standing wave on suppression of soot from acetylene diffusion flame[J]. Thermal Science and Engineering Progress, 2023, 43: 102006.

LORETERO M E, HUANG R F. Effects of acoustic excitation on a swirling diffusion flame[J]. Journal of Engineering for Gas Turbines and Power, 2010, 132(12): 1113-1122.

王瀛洲, 韩璞. 声场强化煤粉燃烧的试验研究[J]. 动力工程学报, 2014, 34(4): 271-274. WANG Yingzhou, HAN Pu. Research on boiler combustion enhancement by sound field[J]. Journal of Chinese Society of Power Engineering, 2014, 34(4): 271-274.

沈国清, 师云泽, 王彦博, 等. 声波激励对煤粉燃烧NO x 生成的影响[J ] . 燃烧科学与技术, 2015, 21(6): 506-510. SHEN Guoqing, SHI Yunze, WANG Yanbo, et al. Effect of acoustic excitation on NO x generation of coal combustion[J ] . Journal of Combustion Science and Technology, 2015, 21(6): 506-510.

马大猷. 高声强: Ⅱ. 效应和应用[J]. 声学学报, 1992, 17(5): 363-368. MAA Dahyou. High-intensity sound: Ⅱ. Effects and applications[J]. Acta Acustica, 1992, 17(5): 363-368.

黄强华, 方承超, 杨景蕙. 燃煤工业锅炉声波助燃除尘技术的研究[J]. 动力工程, 1995, 15(4): 56-59, 55. HUANG Qianghua, FANG Chengchao, YANG Jinghui. Research on acoustic backed combustion and ash removal in coal fired industial boilers[J]. Power Engineering, 1995, 15(4): 56-59, 55.

高明旭, 金铃铃. 低频强声振荡对燃煤锅炉助燃的研究[J]. 辽宁工业大学学报(自然科学版), 2008, 28(3): 169-171. GAO Mingxu, JIN Lingling. Study of low-frequency strong-voice oscillation in assistant-burning to boiler fuelled by coal[J]. Journal of Liaoning University of Technology (Natural Science Edition), 2008, 28(3): 169-171.

马大猷. 调制气流声源的原理[J]. 物理学报, 1974, 23(1): 17-26. MAA Dahyou. Theory of modulated air stream sound sources[J]. Acta Physica Sinica, 1974, 23(1): 17-26.

张世平, 安连锁, 沈国清, 等. 电站锅炉声学测温中炉膛声场及热态背景噪声特性研究[J]. 华北电力大学学报(自然科学版), 2011, 38(6): 68-74. ZHANG Shiping, AN Liansuo, SHEN Guoqing, et al. Study on characteristic of sound field and hot-state background acoustic noise in boiler furnace of acoustic pyrometry[J]. Journal of North China Electric Power University (Natural Science Edition), 2011, 38(6): 68-74.

王为术, 罗晓宇, 杨智峰, 等. 过量空气系数对旋风锅炉纯高碱煤燃烧及NO x 释放影响特性研究[J ] . 热能动力工程, 2021, 36(4): 73-79. WANG Weishu, LUO Xiaoyu, YANG Zhifeng, et al. Effect of excess air coefficient on combustion and NO x emission of cyclone boiler with pure high alkali coal[J ] . Journal of Engineering for Thermal Energy and Power, 2021, 36(4): 73-79.

何翔, 马达夫, 金晶. 旋流对冲燃烧锅炉降低CO排放的燃烧优化[J]. 动力工程学报, 2021, 41(7): 533-541. HE Xiang, MA Dafu, JIN Jing. Combustion optimization for reducing CO emission in an opposed swirl firing boiler[J]. Journal of Chinese Society of Power Engineering, 2021, 41(7): 533-541.

李胜利. 藻类生物质在O 2 /CO 2 气氛下燃烧的SO 2 排放特性[J ] . 广州化学, 2019, 44(1): 30-35. LI Shengli. SO 2 emission characteristics from algae biomass combustion in O 2 /CO 2 atmosphere[J ] . Guangzhou Chemistry, 2019, 44(1): 30-35.

张健, 曹瑞杰. 煤粉富氧燃烧烟气中飞灰固硫特性试验[J]. 洁净煤技术, 2023, 29(8): 102-108. ZHANG Jian, CAO Ruijie. Experiment of sulfur retention characteristics of fly ash in pulverized coal oxy-fuel-firing flue gas[J]. Clean Coal Technology, 2023, 29(8): 102-108.

李振江, 闫程翔, 张涛, 等. 燃烧调整对工业锅炉NO x 排放影响的试验研究[J ] . 中国金属通报, 2024(1): 234-236. LI Zhenjiang, YAN Chengxiang, ZHANG Tao, et al. Experimental study on the effect of combustion adjustment on NO x emissions of industrial boilers[J ] . China Metal Bulletin, 2024(1): 234-236.

JING Jianping, LI Zhengqi, ZHU Qunyi, et al. Influence of primary air ratio on flow and combustion characteristics and NO x emissions of a new swirl coal burner[J ] . Energy, 2011, 36(2): 1206-1213.

Views

177

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Prediction of SO2 Emission Concentration for CFB Units Under Quick Load Change Conditions Based on MLO-HIKAN

Two-stage Short-term Wind Power Prediction with Multi-factor Joint Correction Considering Spatio-temporal Features

Segmented Mechanism-Data Hybrid Modeling for Outlet SO2 Mass Concentration Prediction in WFGD Systems Under Flexible Peak-shaving Conditions

Experimental Study on the Static Stability of Scallop Damper Seals

Acoustic Tomography Temperature Measurement Based on Grid Non-uniform Discretization

Related Author

YU Tingfang

GENG Ping

HUO Erguang

CAO Mengbing

Related Institution

School of Mechanical and Electrical Engineering, Nanchang University

AI问答

⁰