To address the difficulty of fault diagnosis in thermal power equipment with multi-parameter coupling and gradual changes
a fault early warning method based on least absolute shrinkage and selection operator (LASSO) regression feature selection and bidirectional long-short term memory (BiLSTM) multivariate regression prediction was proposed. Taking a coal mill in a 1 000 MW power unit as the research subject
feature parameters such as mill current
outlet pressure
and inlet-outlet differential pressure were selected to represent blockage faults. LASSO regression was employed to select the feature variables
and a multivariate regression prediction model was established based on the BiLSTM algorithm. According to the variation mechanism of the feature parameters during mill blockage and the predicted values of the model
a mill blockage fault index was constructed. Finally
the warning threshold was determined using the kernel density estimation method
enabling mill blockage fault warnings. Actual data analysis shows that when the coal mill is operating normally
the average relative error of the BiLSTM multivariate regression prediction model is 1.13%. Compared with the traditional error back-propagation (BP) neural network and support vector regression (SVR) model
it has higher accuracy and the ability to predict the trend of parameter change. When the coal mill is operating abnormally
this method can detect operational abnormalities earlier than the multivariate state estimation technique (MSET) algorithm model
enabling early fault warning under variable operating conditions of the coal mill.
杨婷婷, 高乾, 李浩千, 等. 基于卷积神经网络-长短时记忆神经网络的磨煤机故障预警[J]. 热力发电, 2022, 51(10): 122-129. YANG Tingting, GAO Qian, LI Haoqian, et al. Coal mill fault early warning technology based on CNN-LSTM network[J]. Thermal Power Generation, 2022, 51(10): 122-129.
李晓彬. 低负荷下电站辅机安全监控技术研究与应用[D]. 北京: 华北电力大学, 2020.
杨婷婷, 张蓓, 吕游, 等. 基于MSET的电站风机故障预警技术研究[J]. 热能动力工程, 2017, 32(9): 63-68. YANG Tingting, ZHANG Bei, LV You, et al. Research on early fault warning technology of fan in power plant based on MSET method[J]. Journal of Engineering for Thermal Energy and Power, 2017, 32(9): 63-68.
蔡吉磊, 茅大钧, 李玉珍. 基于改进HAC和MSET的给水泵故障预警方法[J]. 热能动力工程, 2023, 38(8): 176-184. CAI Jilei, MAO Dajun, LI Yuzhen. Feed water pump fault early warning method based on improved HAC and MSET[J]. Journal of Engineering for Thermal Energy and Power, 2023, 38(8): 176-184.
韩万里, 茅大钧, 印琪民. 基于PCA和多元状态估计的引风机故障预警[J]. 热能动力工程, 2020, 35(1): 91-97. HAN Wanli, MAO Dajun, YIN Qimin. Induced draft fan fault warning based on PCA and multivariate state estimation technique[J]. Journal of Engineering for Thermal Energy and Power, 2020, 35(1): 91-97.
宋莹, 张钟镭. 基于多元状态估计和超椭球分析的汽轮机运行状态监测[J]. 动力工程学报, 2020, 40(2): 138-144. SONG Ying, ZHANG Zhonglei. Steam turbine condition monitoring based on multivariate state estimation technique and hyper-ellipsoid analysis[J]. Journal of Chinese Society of Power Engineering, 2020, 40(2): 138-144.
牛玉广, 李晓彬, 张佳辉. 基于多元状态估计与自适应阈值的电站辅机故障预警[J]. 动力工程学报, 2019, 39(9): 717-724. NIU Yuguang, LI Xiaobin, ZHANG Jiahui. Early fault warning for auxiliary equipment of power plants based on multivariate state estimation and adaptive threshold[J]. Journal of Chinese Society of Power Engineering, 2019, 39(9): 717-724.
刘海涛. 中速磨煤机状态监测与故障诊断方法研究[D]. 北京: 华北电力大学, 2015.
杨茜. 基于数据驱动的火电厂关键辅机设备故障诊断技术研究[D]. 杭州: 浙江大学, 2017.
陈波, 王亚欧, 陶谦, 等. 基于长短期记忆神经网络的燃煤机组磨煤机性能预测模型[J]. 热力发电, 2021, 50(6): 121-127. CHEN Bo, WANG Yaou, TAO Qian, et al. LSTM-based performance prediction model for coal mill in a coal-fired unit[J]. Thermal Power Generation, 2021, 50(6): 121-127.
安吉振, 乔世超, 陈衡, 等. 基于多元状态估计和向量相似度的电站磨煤机故障智能预警研究[J]. 热力发电, 2022, 51(12): 64-71. AN Jizhen, QIAO Shichao, CHEN Heng, et al. Research on intelligent early warning of coal mill failure in power station based on multi-state estimation and vector similarity[J]. Thermal Power Generation, 2022, 51(12): 64-71.
TIBSHIRANI R. Regression shrinkage and selection via the Lasso[J]. Journal of the Royal Statistical Society: Series B (Methodological), 1996, 58(1): 267-288.
程侃如, 王玉璋, 杨志鹏, 等. 基于SSA和注意力机制BiLSTM的燃气轮机传感器故障诊断方法研究[J]. 动力工程学报, 2023, 43(9): 1181-1189. CHENG Kanru, WANG Yuzhang, YANG Zhipeng, et al. Gas turbine sensor fault diagnosis method based on SSA and BiLSTM with attention mechanism[J]. Journal of Chinese Society of Power Engineering, 2023, 43(9): 1181-1189.
金志远, 李胜男, 谭鹏, 等. 基于长短时记忆神经网络的锅炉多参数协同预测模型[J]. 热力发电, 2021, 50(5): 120-126. JIN Zhiyuan, LI Shengnan, TAN Peng, et al. Multi-parameter collaborative prediction model of boilers based on long-short-term memory neural network[J]. Thermal Power Generation, 2021, 50(5): 120-126.
HOCHREITER S, SCHMIDHUBER J. Long short-term memory[J]. Neural Computation, 1997, 9(8): 1735-1780.
向玲, 朱浩伟, 丁显, 等. 基于CAE与BiLSTM结合的风电机组齿轮箱故障预警方法研究[J]. 动力工程学报, 2022, 42(6): 514-521. XIANG Ling, ZHU Haowei, DING Xian, et al. Research on fault warning method of wind turbine gearbox based on CAE and BiLSTM[J]. Journal of Chinese Society of Power Engineering, 2022, 42(6): 514-521.
李麒,朱光平. 基于 SWT 和 SVR 的重力坝变形预测研究[J]. 人民长江, 2021, 52(11): 169-174. LI Qi, ZHU Guangping. Deformation prediction of gravity dams based on SWT and SVR[J]. Yangtze River, 2021, 52(11): 169-174.
李昊, 罗云, 李瑞东, 等. 基于粒子群优化算法优化BP神经网络模型的间接空冷散热器性能监测[J]. 动力工程学报, 2019, 39(12): 973-980. LI Hao, LUO Yun, LI Ruidong, et al. Performance monitoring of indirect air-cooled radiators based on particle swarm optimization BP neural network model[J]. Journal of Chinese Society of Power Engineering, 2019, 39(12): 973-980.
吴涛, 王毅, 刘震, 等. 基于多元状态估计-层次分析法的磨煤机故障预警[J]. 热力发电, 2023, 52(5): 14-21. WU Tao, WANG Yi, LIU Zhen, et al. Coal mill fault warning based on multi-state estimation-analytic hierarchy process[J]. Thermal Power Generation, 2023, 52(5): 14-21.
魏书荣, 张鑫, 符杨, 等. 基于GRA-LSTM-Stacking模型的海上双馈风力发电机早期故障预警与诊断[J]. 中国电机工程学报, 2021, 41(7): 2373-2382. WEI Shurong, ZHANG Xin, FU Yang, et al. Early fault warning and diagnosis of offshore wind DFIG based on GRA-LSTM-Stacking model[J]. Proceedings of the CSEE, 2021, 41(7): 2373-2382.
杨婷婷, 李浩千, 陈晓峰, 等. 基于WPT-Transformer的磨煤机故障预警研究[J]. 热力发电, 2023, 52(12): 180-189. YANG Tingting, LI Haoqian, CHEN Xiaofeng, et al. Research on fault early warning of coal mill based on WPT and Transformer[J]. Thermal Power Generation, 2023, 52(12): 180-189.