Experimental Study on the Removal of NO/SO<sub>2</sub>/Hg<sup>0</sup> by the Combination of Surface Dielectric Barrier Discharge and Catalysts

LI Zhaobing; YANG Zeyong; HU Dehao; SONG Jie; LAI Jinping; MI Gaoli; YU Jie

doi:10.19805/j.cnki.jcspe.2025.230744

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Experimental Study on the Removal of NO/SO₂/Hg⁰ by the Combination of Surface Dielectric Barrier Discharge and Catalysts

更新时间：2026-01-21

- Experimental Study on the Removal of NO/SO₂/Hg⁰ by the Combination of Surface Dielectric Barrier Discharge and Catalysts
- Chinese Journal of Power Engineering Vol. 45, Issue 2, Pages: 292-299(2025)
- 作者机构：
  
  1. 国能南京电力试验研究有限公司,江苏,南京,210046
  2. 国能九江发电有限公司,江西,九江,332000
  3. 华中科技大学能源与动力工程学院煤燃烧与低碳利用全国重点实验室,湖北,武汉,430074
- 作者简介：
- 基金信息：
- DOI：10.19805/j.cnki.jcspe.2025.230744
  CLC： X701;O643.36
- Published Online：15 February 2025，
  
  Published：2025
- 稿件说明：
移动端阅览
李朝兵,杨泽勇,胡德浩,宋捷,赖金平,米高丽,于洁. 沿面介质阻挡放电协同催化剂脱除NO/SO₂/Hg⁰实验研究动力工程学报, 2025, 45(2): 292-299 https://doi.

org/10.19805/j.cnki.jcspe.2025.230744
李朝兵,杨泽勇,胡德浩,宋捷,赖金平,米高丽,于洁. 沿面介质阻挡放电协同催化剂脱除NO/SO₂/Hg⁰实验研究动力工程学报, 2025, 45(2): 292-299 https://doi. DOI： 10.19805/j.cnki.jcspe.2025.230744.

org/10.19805/j.cnki.jcspe.2025.230744 DOI：

摘要

通过选取并制备纳米TiO

、Mn-TiO

和Mn-Ce-TiO

3种催化剂

研究了不同反应温度、烟气中氧体积分数以及气体停留时间条件下

各催化剂对NO、SO

及Hg

3种污染物的催化氧化性能;分析了低温等离子体条件下

不同催化剂对NO、SO

及Hg

的氧化机制。结果表明:反应温度升高能够促进NO、SO

及Hg

的氧化转化;增加反应气在催化反应器中的停留时间同样可以促进上述污染物的转化

但停留时间过长会引发副反应;在不同氧化还原气氛下

NO、SO

及Hg

表现的催化脱除机理不同;相比于TiO

和Mn-TiO

催化剂

Mn-Ce-TiO

催化剂对NO、SO

及Hg

的脱除效果最优;相比于单独使用沿面型介质阻挡放电和催化剂

两者之间的耦合能够更好地脱除NO、SO

及Hg

并且协同Mn-Ce-TiO

催化剂具有最优的污染物脱除性能。

Abstract

The effect of reaction temperature

oxygen volume fraction

and gas residence time on the catalytic oxidation of NO/SO

/Hg

by the prepared nano TiO

Mn-TiO

and Mn-Ce-TiO

catalysts was studied. The oxidation mechanism of NO/SO

/Hg

by these catalysts was ana

lyzed in low temperature plasma. Results show that the oxidation rates of NO

and Hg

are enhanced with the elevated temperature and gas residence time in the catalytic reactor. However

prolonged residence time might induce side reactions. The removal mechanism of NO/SO

/Hg

varies between the absence and presence of oxygen. Compared to TiO

and Mn-TiO

the Mn-Ce-TiO

catalyst exhibits superior performance in removing NO/SO

/Hg

. Synergistic treatment by surface dielectric barrier discharge (SDBD) and catalysts shows greater removal efficacy of NO/SO

/Hg

compared to the individual

specifically

the combination of SDBD and Mn-Ce-TiO

关键词

Keywords

references

朱法华, 徐静馨, 王圣, 等. 中国燃煤电厂大气污染物治理历程及展望[J]. 电力科技与环保, 2023, 39(5): 371-384. ZHU Fahua, XU Jingxin, WANG Sheng, et al. Processes and prospects of air pollutant control in coal-fired power plants in China[J]. Electric Power Technology and Environmental Protection, 2023, 39(5): 371-384.

ZHOU Changsong, WANG Ben, SONG Zijian, et al. DFT studies of Hg 0 oxidation by gaseous advanced oxidation method: H 2 O 2 /Fe 3 O 4 (1 1 1) and hydroxyl pre-adsorbed Fe 3 O 4 (1 1 1) surface[J ] . Fuel, 2017, 202: 318-327.

余刚, 余奇, 翟晓东, 等. 等离子体脱硝与等离子体催化联合脱硝的对比实验研究[J]. 动力工程, 2005, 25(2): 284-288. YU Gang, YU Qi, ZHAI Xiaodong, et al. A comparison test of plasma denitration with and without catalysts added[J]. Chinese Journal of Power Engineering, 2005, 25(2): 284-288.

邵晶, 刘海玉, 乔晓磊, 等. 不同空速下微波放电对活性焦同时脱硫脱硝的影响[J]. 动力工程学报, 2020, 40(12): 1014-1018, 1034. SHAO Jing, LIU Haiyu, QIAO Xiaolei, et al. Effect of microwave discharge on simultaneous desulfurization and denitrification of activated coke at different space velocities[J]. Journal of Chinese Society of Power Engineering, 2020, 40(12): 1014-1018, 1034.

孙尊强, 舒喜, 马修元, 等. 小型热电厂脱硝超低排放改造技术路线研究[J]. 电力科技与环保, 2020, 36(6): 23-26. SUN Zunqiang, SHU Xi, MA Xiuyuan, et al. Research on technical route of denitrification ultra-low emission transformation in small thermal power plant[J]. Electric Power Technology and Environmental Protection, 2020, 36(6): 23-26.

汪涛, 孙保民, 肖海平, 等. 介质材料对介质阻挡放电脱除NO的影响[J]. 动力工程学报, 2012, 32(12): 966-970. WANG Tao, SUN Baomin, XIAO Haiping, et al. Effect of dielectric material on NO removal by DBD[J]. Journal of Chinese Society of Power Engineering, 2012, 32(12): 966-970.

OBRADOVI B M, SRETENOVI G B, KURAICA M M. A dual-use of DBD plasma for simultaneous NO x and SO 2 removal from coal-combustion flue gas[J ] . Journal of Hazardous Materials, 2011, 185(2/3): 1280-1286.

NIU Qiang, LUO Jinjing, SUN Shiqiang, et al. Effects of flue gas components on the oxidation of gaseous Hg 0 by dielectric barrier discharge plasma[J ] . Fuel, 2015, 150: 619-624.

QI G, YANG R T. Low-temperature selective catalytic reduction of NO with NH 3 over iron and manganese oxides supported on titania[J ] . Applied Catalysis B: Environmental, 2003, 44(3): 217-225.

SHAO Jiaming, LIN Fawei, WANG Zhihua, et al. Low temperature catalytic ozonation of toluene in flue gas over Mn-based catalysts: effect of support property and SO 2 /water vapor addition[J ] . Applied Catalysis B: Environmental, 2020, 266: 118662.

盛小红. 低温等离子体协同增强Mo基脱硝催化剂的制备及其SCR脱硝性能研究[D]. 重庆: 重庆理工大学, 2023.

朱军山, 周进. Ag-TiO 2 协同低温等离子体氧化降解NO x 的研究[J ] . 安全、健康和环境, 2023, 23(9): 52-58. ZHU Junshan, ZHOU Jin. Study on NO x degradation b y Ag-TiO 2 in coordination with low temperature plasma oxidation[J ] . Safety Health & Environment, 2023, 23(9): 52-58.

GAO Xiang, JIANG Ye, ZHONG Yi, et al. The activity and characterization of CeO 2 -TiO 2 catalysts prepared by the sol-gel method for selective catalytic reduction of NO with NH 3 [J ] . Journal of Hazardous Materials, 2010, 174(1/3): 734-739.

孙朋琨, 张宇晴, 童华. Ce掺杂对MnO x 在低温等离子体协同下的脱硝性能影响[J ] . 环境工程学报, 2023, 17(5): 1533-1542. SUN Pengkun, ZHANG Yuqing, TONG Hua. Effect of Ce doping on the denitrification performance of MnO x in the presence of low temperature plasma[J ] . Chinese Journal of Environmental Engineering, 2023, 17(5): 1533-1542.

游华伟. MnO x -CeO 2 /γ-Al 2 O 3 催化剂脱硝脱汞的实验研究[D ] . 武汉: 华中科技大学, 2012.

陈振, 包浩琪, 万聪, 等. 低温等离子体氧化NO的研究[J]. 能源环境保护, 2023, 37(4): 76-82. CHEN Zhen, BAO Haoqi, WAN Cong, et al. Investigation of NO oxidation by non-thermal plasma[J]. Energy Environmental Protection, 2023, 37(4): 76-82.

NASONOVA A, PHAM H C, KIM D J, et al. NO and SO 2 removal in non-thermal plasma reactor packed with glass beads-TiO 2 thin film coated by PCVD process[J ] . Chemi cal Engineering Journal, 2010, 156(3): 557-561.

YANG Xingdong, QU Jiyan, WANG Linxi, et al. In-plasma-catalysis for NO x degradation by Ti 3+ self-doped TiO 2- x /γ-Al 2 O 3 catalyst and nonthermal plasma[J ] . RSC Advances, 2021, 11(39): 24144-24155.

于贤群, 鲍静静, 姜小祥, 等. Mn-TiO 2 催化剂烟气脱汞性能及反应机理[J ] . 中国电机工程学报, 2015, 35(13): 3331-3337. YU Xianqun, BAO Jingjing, JIANG Xiaoxiang, et al. Performance and mechanism of catalytic oxidation for mercury by Mn-doped TiO 2 catalysts in flue gas[J ] . Proceedings of the CSEE, 2015, 35(13): 3331-3337.

PENG Yue, LI Junhua, SI Wenzhe, et al. Ceria promotion on the potassium resistance of MnO x /TiO 2 SCR catalysts: an experimental and DFT study[J ] . Chemical Engineering Journal, 2015, 269: 44-50.

姜全军, 邵炜. V 2 O 5 -CeO 2 /TiO 2 低温催化脱除氮氧化物与二噁英研究[J ] . 电力科技与环保, 2020, 36(3): 11-16. JIANG Quanjun, SHAO Wei. Synergistic removal of nitrogen oxides and dioxins by V 2 O 5 -CeO 2 /TiO at low temperature[J ] . Electric Power Technology and Environmental Protection, 2020, 36(3): 11-16.

CALVERT J G, LINDBERG S E. Mechanisms of mercury removal by O 3 and OH in the atmosphere[J ] . Atmospheric Environment, 2005, 39(18): 3355-3367.

ZHANG Tianqi, LI Xiaosong, LIU Jinglin, et al. Plasma nitrogen fixation: NO x synthesis in MnO x /Al 2 O 3 packed-bed dielectric barrier discharge[J ] . Plasma Chemistry and Plasma Processing, 2023, 43(6): 1907-1919.

GAO Fan, JIN Xingpeng, WANG Guicheng, et al. Removal of NO by carbon-based catalytic reduction bed loaded with Mn induced by dielectric barrier discharge at low temperature[J]. Environmental Engineering Research, 2023, 28(1): 210500.

JIANG Boqiong, ZHAO Shuang, WANG Yaolin, et al. Plasma-enhanced low temperature NH 3 -SCR of NO x over a Cu-Mn/SAPO-34 catalyst under oxygen-rich conditions[J ] . Applied Catalysis B: Environmental, 2021, 286: 119886.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

WANG Tao

WAN Zhentian

XIAO Haiping

YANG Xiaochu

SUN Baomin

LIU Xiaowei

GUI Ben

GUO Junzhe

Related Institution

MOE's Key Laboratory of Condition Monitoring and Control for Power Plant Equipment, North China Electric Power University

State Key Laboratory of Coal Combustion,Huazhong University of Science and Technology

Central Southern China Electric Power Design Institute Co., Ltd. of China Power Engineering Consulting Group

School of Energy and Power Engineering, Changsha University of Science and Technology

Engineering Laboratory for Energy System Process Conversion & Emission Control Technology of Jiangsu Province, School of Energy and Mechanical Engineering, Nanjing Normal University

AI问答

⁰

Experimental Study on the Removal of NO/SO2/Hg0 by the Combination of Surface Dielectric Barrier Discharge and Catalysts

DOI：10.19805/j.cnki.jcspe.2025.230744

摘要

Abstract

关键词

Keywords

references

Experimental Study on the Removal of NO/SO₂/Hg⁰ by the Combination of Surface Dielectric Barrier Discharge and Catalysts