Adjustment test and optimization strategy study for low reheat steam temperature of tower-type once-through boiler

CHEN Peng; CHANG Jingwei; HUANG Weigang; SUN Lijun; XU Yuangang

doi:10.19666/j.rlfd.202110219

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Adjustment test and optimization strategy study for low reheat steam temperature of tower-type once-through boiler

更新时间：2025-09-28

- Adjustment test and optimization strategy study for low reheat steam temperature of tower-type once-through boiler
- Thermal Power Generation Vol. 51, Issue 4, Pages: 150-157(2022)
- 作者机构：
  
  1. 神华国能哈密电厂
  2. 西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202110219
  CLC： TM621.2
- Published：2022
- 稿件说明：
移动端阅览
CHEN Peng, CHANG Jingwei, HUANG Weigang, et al. Adjustment test and optimization strategy study for low reheat steam temperature of tower-type once-through boiler[J]. Thermal power generation, 2022, 51(4): 150-157.
DOI：

CHEN Peng, CHANG Jingwei, HUANG Weigang, et al. Adjustment test and optimization strategy study for low reheat steam temperature of tower-type once-through boiler[J]. Thermal power generation, 2022, 51(4): 150-157. DOI： 10.19666/j.rlfd.202110219.

摘要

针对某超临界塔式直流锅炉中、低负荷再热汽温偏低的问题，通过低负荷再热汽温调整试验，以及当前中、低负荷再热汽温低的原因分析，提出了低负荷稳燃燃烧器改造、受热面改造以及锅炉运行优化等联合治理整体方案。整体方案实施后，锅炉中、低负荷下的再热汽温明显提高，40%BRL下锅炉再热蒸汽出口温度由537.9℃提升至563.9℃，50%BRL下，锅炉再热蒸汽出口温度由537.9℃提升至559.4℃，这两种负荷下机组供电煤耗分别降低1.64、1.36 g/(kW·h)，合计每年节约锅炉燃料成本约125万元。在锅炉深度调峰负荷（30%BRL）下，再热蒸汽出口温度可由541.6℃提升至560.9℃，提升幅度为19.3℃；过热蒸汽出口温度可由560.8℃提升至571.9℃，提升幅度为11.1℃。

Abstract

Aiming at solving the problem of low reheat steam temperature at medium and low load in a supercritical once-through tower boiler

the low load reheat steam temperature adjustment test was carried out

and the reason for low reheat steam temperature at medium and low load was analyzed. The overall plan for joint treatment of stable combustion burner transformation

heating surface transformation and boiler operation optimization was proposed. After the implementation of the overall plan

the reheat steam temperature of the boiler at medium and low loads significantly increased. The outlet temperature of the reheat steam increased from 537.9 ℃ to 563.9 ℃under 40% BRL condition

and from 537.9 ℃ to 559.4 ℃ under 50% BRL condition

and the coal consumption of power supply of the unit under these two conditions reduced by 1.64 g/(kW·h) and 1.36 g/(kW·h) respectively

and the total annual saving of boiler fuel cost was about 1.25 million yuan. Under 30%BRL condition(the boiler's deep peak load regulation)

the outlet temperature of reheat steam can increase from 541.6 ℃ to 560.9 ℃

with an increase of 19.3 ℃

and the outlet temperature of the superheated steam can increase from 560.8 ℃ to 571.9 ℃

with an increase of 11.1 ℃.

关键词

Keywords

references

Views

140

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

CAUSE ANALYSIS OF HIGH-TEMPERATURE CORROSION ON WATER-WALL OF A 440 t/h BOILER

CAUSE ANALYSIS AND PREVENTION OF BURST-LEAKAGE FROM "FOUR TUBE KINDS" IN A HOME-MADE 670 t/h BOILER

COMBUSTION ADJUSTMENT TEST FOR SUPERCRITICAL BOILER OF 600MW UNIT

APPLICATION ANALYSIS OF MECHANICAL GRATE WASTE INCINERATORS

ANALYSIS OF OVER-TEMPERATURE ON THE PLATEN SUPERHEATER OF ONCE-THROUGH BOILER FOR SUPERCRITICAL 600 MW UNIT

Related Author

SONG Shao-wei1

QIU Xian-tang1

ZHOU Hai-qing1

LIU Xiao-hong2

WANG Guang-bing1 (1.Heze Power Plant

ZONG Zhi-wei(Datang Luoyang Shouyangshan Power Plant

LU Ying

WNAG Da-fengZhejiang Provincial Electric Power Testing & Research Institute

Related Institution

Heze Power Plant

Datang Luoyang Shouyangshan Power Plant

Zhejiang Electric Power Test and Research Institute

Everbright Environmental Energy (Suzhou) Co., Ltd

Anhui Electric Power Science Research Institute

AI问答

⁰