Effect of ultra-low emission transformation process of WFGD on migration and transformation characteristics of fine particles

ZANG Wuqi; HOU Dawei; YANG Linjun

doi:10.19666/j.rlfd.202109232

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Effect of ultra-low emission transformation process of WFGD on migration and transformation characteristics of fine particles

更新时间：2025-09-28

- Effect of ultra-low emission transformation process of WFGD on migration and transformation characteristics of fine particles
- Thermal Power Generation Vol. 51, Issue 4, Pages: 127-132(2022)
- 作者机构：
  
  1. 东南大学能源热转换及其过程测控教育部重点实验室
  2. 中国大唐集团科学技术研究院有限公司华东电力试验研究院
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202109232
  CLC： X773
- Published：2022
- 稿件说明：
移动端阅览
ZANG Wuqi, HOU Dawei, YANG Linjun. Effect of ultra-low emission transformation process of WFGD on migration and transformation characteristics of fine particles[J]. Thermal power generation, 2022, 51(4): 127-132.
DOI：

ZANG Wuqi, HOU Dawei, YANG Linjun. Effect of ultra-low emission transformation process of WFGD on migration and transformation characteristics of fine particles[J]. Thermal power generation, 2022, 51(4): 127-132. DOI： 10.19666/j.rlfd.202109232.

摘要

经石灰石-石膏湿法烟气脱硫（WFGD）后燃煤烟气中细颗粒物特性会发生显著变化，具体与脱硫工艺有关。基于自行搭建的超低排放实验台及实际电厂测试数据，对WFGD超低排放工艺中细颗粒物的迁移转化特性进行了分析。结果表明：塔入口烟温70℃下塔出口细颗粒物数量与150℃下相比降低约1×106个/cm~3;5层喷淋对细颗粒物数量及质量浓度的去除效率提升11.5%和18.9%左右；增设清水喷淋和托盘、采用双循环工艺均有效降低了塔出口细颗粒物质量浓度，其中双塔双循环系统的去除效果最好，出口细颗粒物质量浓度可达10 mg/m~3以下。

Abstract

The characteristics of fine particles in flue gas after the limestone-gypsum wet desulfurization(WFGD)process are very different from those produced by coal-burning

which is related to the desulfurization process. The migration and transformation characteristics of fine particles in flue gas were analyzed by using test data of selfbuilt ultra-low emission test bench and actual power plant. The results show that

the number of fine particulate matters at the tower outlet at 70 ℃ was about 1×106/cm~3 smaller than that at 150 ℃. Compared with three-layer spraying

the removal efficiency of the number and mass concentration of fine particles of five-layer spraying increased by about 11.5% and 18.9%

respectively. Adding clean water sprayer and tray tower

as well as applying double-cycle system

can effectively reduce the mass concentration of fine particles in flue gas at the tower outlet.Moreover

the double-tower double-cycle desulphurization technology has the best removal effect

the mass concentration of fine particles at the tower outlet can reach lower than 10 mg/m~3.

关键词

Keywords

references

Views

196

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental study on fine particle emission characteristics of ultra-low emission coal-fired units

Migration and transformation characteristics of SO₃ in coal-fired power plants

INFLUENCE OF SMOKE CONCENTRATION UPON ABSORPTION TOWER IN WET DESULPHURATION SYSTEM AND COUNTERMEASURES THEREOF

RETROFIT OF SAMPLE PRE-TREATMENT FACILITY FOR FLUE GAS MEASUREMENT BASED ON DILUTION METHOD

ANALYSIS OF CHEMICAL MECHANISM FOR FOULING IN WET FGD SYSTEM AND ITS CONTROL IN OPERATION

Related Author

CHEN Hongwei

LIANG Zhanwei

ZHAO Bin

GAO Mingfei

ZHANG Meiyou

ZHAO Zhenghui

LIU Xiaomin

QI Jun-tian1

Related Institution

Ningxia Electric Power Company

College of Metallurgy and Energy, North China University of Science and Technology

College of Energy, Power and Mechanical Engineering, North China Electric Power University

Xiamen Huaxia International Power Development Co., Ltd

Shaanxi Tongchuan Aluminum Power Plant

AI问答

⁰