SCR deNO<sub>x</sub> retrofitting technology for gas-steam combined cycle unit

DONG Chen; ZENG Yangbo; JIANG Jian; WANG Qingren; LI Jun; HU Jiajing; NIU Guoping; WANG Xiaobing; WANG Weifeng; YUAN Zhuang; SHU Kai

doi:10.19666/j.rlfd.202002084

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

SCR deNO_x retrofitting technology for gas-steam combined cycle unit

更新时间：2025-09-28

- SCR deNO_x retrofitting technology for gas-steam combined cycle unit
- Thermal Power Generation Vol. 49, Issue 11, Pages: 40-46(2020)
- 作者机构：
  
  1. 西安热工研究院有限公司
  2. 广东惠州天然气发电有限公司
  3. 西安益通热工技术服务有限责任公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202002084
  CLC： X511
- Published Online：03 November 2020，
  
  Published：2020
- 稿件说明：
移动端阅览
DONG Chen, ZENG Yangbo, JIANG Jian, et al. SCR deNO_x retrofitting technology for gas-steam combined cycle unit[J]. Thermal power generation, 2020, 49(11): 40-46.
DOI：

DONG Chen, ZENG Yangbo, JIANG Jian, et al. SCR deNO_x retrofitting technology for gas-steam combined cycle unit[J]. Thermal power generation, 2020, 49(11): 40-46. DOI： 10.19666/j.rlfd.202002084.

摘要

以某9F级燃气-蒸汽联合循环机组余热锅炉为原型

进行了选择性催化还原(SCR)脱硝系统改造设计研究

根据脱硝系统所需氨耗量和烟气参数设计了氨水蒸发系统

根据余热锅炉的具体尺寸和实际运行烟温参数确定了催化剂的布置位置和参数

并采用数值模拟方法研究了改造后余热锅炉脱硝系统的烟气流场。结果表明:对于高位布置的燃气轮机

在扩口段烟道可不设置导流板;采用分区可调的多组一体式氨注射混合器

能在较短距离内加强氨气和NO_x的混合;项目改造完成后进行了喷氨优化调整试验

最终脱硝系统出口截面上的NO_x分布相对标准偏差从29.6%降至19.6%

氨逃逸量从3.46mL/L降至2.89mL/L

改善效果明显。

Abstract

The retrofitting scheme for selective catalytic reduction(SCR) deNO_x system of heat recovery boiler are designed for a 9F gas-steam combined cycle unit. The ammonia evaporation system is designed to provide enough ammonia using the heat of flue gas from heat recovery boiler. The parameters and position of catalyst layer are designed based on the operation parameters and actual dimensions of the heat recovery boiler. Moreover

numerical simulations are carried out to study the flow field of the deNO_x system after the retrofitting. The results show that

guide plates are not necessary in inlet flue duct of the heat recovery boiler if the outlet duct of gas turbine is placed in the central axis of the heat recovery boiler. An integral ammonia injection mixer is applied in this project

which can adjust the ammonia flow rates of different zones. Specially

the structure of the integral ammonia injection mixer can realize effective mixing of ammonia and NO_x in short distance. At last

optimization test of the integral ammonia injection mixer was carried out

and the result shows that the distribution of NO_x mass concentration in the outlet cross section was improved

and the ammonia escape amount reduced.

关键词

Keywords

references

Views

239

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

TECHNICAL AND ECONOMICAL ANALYSIS OF INLET AIR COOLING SYSTEM FOR THE GAS-STEAM COMBINED CYCLE

STUDY ON BEHAVIOR OF CATALYCTS FOR SCR DENITRIFICATION USING DIFFERENT TiO₂ AS CARRIER

ANALYSIS OF INFLUENCE PRODUCED FROM HIGH CALCIUM VISCOUS FLY ASH UPON SCR CATALYST

Numerical simulation of inner abrasion in a selective catalytic reduction deNO_x device

Adding groove intertial separator at SCR reactor inlet:numerical simulation and design optimization

Related Author

JIANG Zhou-shu1

HU Ya-cai2

MIAO Sheng-hua3(1.Hangzhou University of Electronic Science & Technolog

ZHU Chong-bing

LI Feng

JIN Bao-sheng

CHENG Ling-xia South-east China University

WANG Yibing

Related Institution

Hangzhou University of Electronic Science and Technology

Zhejiang University

Hangzhou Tianyuan Electric Power Technology Co., Ltd

Southeast University

Huaneng International Power Co., Ltd

AI问答

⁰

SCR deNOx retrofitting technology for gas-steam combined cycle unit

DOI：10.19666/j.rlfd.202002084

摘要

Abstract

关键词

Keywords

references

SCR deNO_x retrofitting technology for gas-steam combined cycle unit