Performance analysis and evaluation of deep peak-regulating for circulating fluidized bed units

YU Haoyang; GAO Mingming; ZHANG Man; YANG Hairui; SONG Juncheng; GONG Chen

doi:10.19666/j.rlfd.202002035

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Performance analysis and evaluation of deep peak-regulating for circulating fluidized bed units

更新时间：2025-09-28

- Performance analysis and evaluation of deep peak-regulating for circulating fluidized bed units
- Thermal Power Generation Vol. 49, Issue 5, Pages: 65-72(2020)
- 作者机构：
  
  1. 新能源电力系统国家重点实验室(华北电力大学控制与计算机工程学院)
  2. 清华大学电力系统及发电设备控制和仿真国家重点实验室
  3. 华电国际电力股份有限公司天津开发区分公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.202002035
  CLC： TK229.6
- Published Online：27 April 2020，
  
  Published：2020
- 稿件说明：
移动端阅览
YU Haoyang, GAO Mingming, ZHANG Man, et al. Performance analysis and evaluation of deep peak-regulating for circulating fluidized bed units[J]. Thermal power generation, 2020, 49(5): 65-72.
DOI：

YU Haoyang, GAO Mingming, ZHANG Man, et al. Performance analysis and evaluation of deep peak-regulating for circulating fluidized bed units[J]. Thermal power generation, 2020, 49(5): 65-72. DOI： 10.19666/j.rlfd.202002035.

摘要

某330 MW循环流化床机组进行深度调峰改造后

能长期保持30%负荷段运行

但深度调峰时机组存在热效率差、单位发电成本高、难以投入自动的问题。本文通过分析该机组深度调峰运行数据

建立深度调峰性能分析评价流程;在对机组深度调峰时的热力性能、发电成本等问题的分析过程中

研究了入炉煤粒径与流化风量对炉膛物料分布的影响

并计算了深度调峰的经济性。结果表明:循环流化床机组在深度调峰条件下具有天然优势与可行性;深度调峰改造后

该330 MW循环流化床机组每日可稳定调峰6 h以上

初步计算每年可以获得约1 700万元的效益。本文研究结果可以为今后循环流化床机组深度调峰运行的改造提供参考。

Abstract

After deep peak-regulating retrofitting

a 330 MW circulating fluidized(CFB) bed unit can maintain 30% load segment operation for a long time. However

the problems of poor thermal efficiency

high power generation cost and difficulty in putting into automatic operation are more prominent in deep peak-regulating. By analyzing the deep peak-regulating operation data

the performance evaluation process of deep peak-regulating was established in this paper. In the process of analyzing the thermal performance and generation cost of the unit and other problems during deep peak-regulating

the influence of coal particle size and fluidized air volume on furnace material distribution was studied. Moreover

the economics of deep peak-regulating were calculated. The results show that

the CFB unit has natural advantages and feasibility under deep peak-regulating conditions. After the retrofitting

the 330 MW CFB unit can perform stable peak-regulating for more than 6 hours per day

and get about 17 million yuan in benefits. The research results in this paper can provide a reference for the future transformation of deep peak-regulating of CFB units.

关键词

Keywords

references

Views

225

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

ECONOMIC ANALYSIS OF USING STRAW-BURNING BOILER FOR DRIVING SMALL TURBINE OF FEED-WATER PUMP FOR ULTRA-SUPERCRITICAL UNIT

Economical efficiency of waste heat recovery from a 12MW steam turbine by absorption heat pump

A clean and efficient system for coal-fired power stations based on coal pre-drying and exhaust steam gas-gas heater

Economic analysis of increasing reheat steam temperature and SCR flue gas temperature by coupling straw direct-fired boiler with utility boiler

Optimization and economic study on waste heat utilization for oxygen-enriched combustion system

Related Author

LIANG Tiebo21.North-west China Electric Power Design Institute

LIU Qishou2

HUANG Jintao2

JIANG An1

HONG Zhenhan

WANG Hongjuan

TU Shan

LU Jingni

Related Institution

School of Energy and Power Engineering, Xi'an Jiaotong University

Northwest Electric Power Design Institute

National Thermal Power Engineering Technology Research Center, North China Electric Power University

State Key Laboratory of Clean and Efficient Coal fired Power Generation and Pollution Control

College of Energy, Power and Mechanical Engineering, North China Electric Power University

AI问答

⁰