Distribution law of ash and sulfur in tail flue of high sulfur coal-fired unit

ZHANG Zhixiang; XU Dangqi; CHE Hongwei; JIA Zhaopeng; LI Wenfeng; ZOU Xiaogang; LI Nan

doi:10.19666/j.rlfd.201912242

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Distribution law of ash and sulfur in tail flue of high sulfur coal-fired unit

更新时间：2025-09-28

- Distribution law of ash and sulfur in tail flue of high sulfur coal-fired unit
- Thermal Power Generation Vol. 49, Issue 9, Pages: 104-108(2020)
- 作者机构：
  
  1. 西安西热锅炉环保工程有限公司
  2. 西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201912242
  CLC： TK314
- Published Online：15 August 2020，
  
  Published：2020
- 稿件说明：
移动端阅览
ZHANG Zhixiang, XU Dangqi, CHE Hongwei, et al. Distribution law of ash and sulfur in tail flue of high sulfur coal-fired unit[J]. Thermal power generation, 2020, 49(9): 104-108.
DOI：

ZHANG Zhixiang, XU Dangqi, CHE Hongwei, et al. Distribution law of ash and sulfur in tail flue of high sulfur coal-fired unit[J]. Thermal power generation, 2020, 49(9): 104-108. DOI： 10.19666/j.rlfd.201912242.

摘要

为了研究高硫煤机组尾部烟道中灰和硫的分布规律

搭建了高硫煤机组低低温省煤器试验台

测试了低低温省煤器进出口烟道不同截面上的飞灰和SO3质量浓度。试验结果表明:低低温省煤器前水平烟道内飞灰质量浓度下高上低

SO3质量浓度下低上高

灰硫比下高上低;低低温省煤器后水平烟道内SO3质量浓度在不同断面上无明显差别

在垂直烟道内外高内低;当低低温省煤器布置在水平烟道时推荐安全灰硫比为150

布置在竖直烟道时推荐安全灰硫比为100;飞灰对SO3的物理吸附率在15.69%～32.45%

飞灰对SO3的物理吸附率与飞灰的质量浓度成正比

总的SO3质量浓度越高

飞灰对SO3的物理吸附率越低。

Abstract

To investigate the distribution rules of ash and sulfur in tail flue of high sulfur coal-fired boiler

an ultra low temperature economizer test bench for high sulfur coal-fired power unit was built up

on which the mass concentration of fly ash and SO3 on different sections at inlet and outlet flue of the ultra low temperature economizer were tested. The results show that

the fly ash mass concentration in horizontal flue pipe in front of the ultra low temperature economizer was high at the bottom and low at the top

while the SO3 mass concentration was high at the top and low at the bottom

and the ash-sulfur ratio was high at the bottom and low at the top. There was no significant difference in SO3 mass concentration in different sections of the horizontal flue pipe behind the ultra low temperature economizer. The SO3 mass concentration in vertical flue pipe behind the ultra low temperature economizer was high at the side and low in the center. The recommended safe ash-sulfur ratio is 150 when the ultra low temperature economizer is arranged in horizontal flue pipe and 100 when it is arranged in vertical flue pipe. The physical adsorption rate of fly ash to SO3 was 15.69%～32.45%. The physical adsorption rate of fly ash to SO3 was proportional to the mass concentration of fly ash. The higher the total SO3 mass concentration

the lower the physical adsorption rate of fly ash to SO3.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental study on SO₃ migration rule of high sulfur coal unit

Study on ash deposition characteristics of ultra low temperature economizer of high sulfur power plant

Experimental research on simultaneous removal of SO₃ by low-low temperature economizer in units firing high-sulfur coal

Estimation methods for acid dew point of flue gas

Experimental study on NO formation mechanism during co-combustion of coal and petroleum coke

Related Author

LI Nan

ZOU Xiaogang

LU Jun

XU Dangqi

ZHANG Zhixiang

CHE Hongwei

LI Nan

ZHANG Zhixiang

Related Institution

State Power Investment Corporation of China, Xiexin Binhai Power Generation Co., Ltd

College of Energy, Power and Mechanical Engineering, North China Electric Power University

State Key Laboratory of Clean Energy Utilization, Zhejiang University

Sinopec Shanghai Petrochemical Co., Ltd

China Datang Corporation Science and Technology Research Institute Co., Ltd. East China Electric Power Test and Research Institute

AI问答

⁰