Phenomenon and mechanism of fly ash deposition in circulating fluidized bed boilers with high circulation rate

TAN Bo; ZHANG Xingshun; ZHENG Yuangang; LIU Xiance; SONG Lingpo; LAN Tian

doi:10.19666/j.rlfd.201910257

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Phenomenon and mechanism of fly ash deposition in circulating fluidized bed boilers with high circulation rate

更新时间：2025-09-28

- Phenomenon and mechanism of fly ash deposition in circulating fluidized bed boilers with high circulation rate
- Thermal Power Generation Vol. 49, Issue 6, Pages: 38-45(2020)
- 作者机构：
  
  1. 兖矿集团洁净煤技术工程研究中心
  2. 兖矿科技有限公司
  3. 山东华聚能源股份有限公司兴隆庄矿电厂
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201910257
  CLC： TK16
- Published Online：24 May 2020，
  
  Published：2020
- 稿件说明：
移动端阅览
TAN Bo, ZHANG Xingshun, ZHENG Yuangang, et al. Phenomenon and mechanism of fly ash deposition in circulating fluidized bed boilers with high circulation rate[J]. Thermal power generation, 2020, 49(6): 38-45.
DOI：

TAN Bo, ZHANG Xingshun, ZHENG Yuangang, et al. Phenomenon and mechanism of fly ash deposition in circulating fluidized bed boilers with high circulation rate[J]. Thermal power generation, 2020, 49(6): 38-45. DOI： 10.19666/j.rlfd.201910257.

摘要

针对高倍率循环流化床(CFB)锅炉飞灰沉积现象严重问题

本文以燃料相同、运行工况相似、飞灰沉积现象截然相反的2台高、中倍率CFB锅炉为研究对象

对其飞灰样品进行了系统的化学成分、扫描电镜及流变特性分析

并建立了飞灰沉积、剥离计算模型。结果表明:高、中倍率煤泥CFB锅炉的燃烧条件对飞灰形成、组成的影响相似

两者在飞灰沉积特性方面无明显差异;高倍率CFB锅炉飞灰粒径趋小和分布变窄使得沉积飞灰的脱离能量低是造成高倍率煤泥CFB锅炉飞灰沉积的主要因素。

Abstract

In view of the serious problem of fly ash deposition in circulating fluidized bed(CFB) boilers with high circulation rate

this paper systematically analyzes the chemical composition

SEM image and rheological characteristics of the fly ash samples collected from two CFB boilers(high and medium circulation rate) with the same fuel

similar operation conditions and opposite fly ash deposition phenomenon.Moreover

it establishes the mathematic model of fly ash deposition and stripping.The results show that

the combustion conditions of high and medium rate CFB boilers have similar effects on the formation and composition of fly ash

and there is no obvious difference in the characteristics of fly ash deposition between them.The main factor for the fly ash deposition in high circulating rate CFB boiler is the low separation energy of deposited fly ash due to the smaller particle size and narrower distribution of fly ash in the boiler.

关键词

Keywords

references

Views

137

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental study on large proportion coal slurry co-firing in a 440 t/h CFB boiler

Investigation on combustion and SO₂ emission instabilities of top feeding coal slime fired circulating fluidized bed boilers

Vibration safety assessment for central full partition wall in a 700 MW high-efficiency ultra-supercritical CFB boiler

Online optimization for collaborative treatment of CO and multi-pollutant emission reduction based on particle swarm optimization

DESIGN OF CONTROL SYSTEM FOR HOMEMADE 410 t/h CFB BOILERS

Related Author

SHAO Wei1

YUAN Longji2

GUO Xiaoyong1

LI Qiang3 1.Shangdong Yankuang Ji-three Power Co.

WANG Chuanzhi

LIU Zhongpan

LYU Zhuo

LU Jiayi

Related Institution

Shandong Yankuang Jisan Electric Power Co., Ltd

School of Electric Power Engineering, China University of Mining and Technology

Xi'an Thermal Power Research Institute Co., Ltd

Sichuan Key Laboratory of Clean Combustion and Smoke Purification

Dongfang Boiler Co., Ltd. of Dongfang Electric Group

AI问答

⁰