Experimental study on reheat steam temperature deviation adjustment for boiler co-firing coal with gases

YAN Junfu; ZHAO Xuebin

doi:10.19666/j.rlfd.201805153

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Experimental study on reheat steam temperature deviation adjustment for boiler co-firing coal with gases

更新时间：2025-09-28

- Experimental study on reheat steam temperature deviation adjustment for boiler co-firing coal with gases
- Thermal Power Generation Vol. 48, Issue 2, Pages: 108-113(2019)
- 作者机构：
  
  山西兴能发电有限责任公司
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.201805153
  CLC： TM621.2
- Published：2019
- 稿件说明：
移动端阅览
YAN Junfu, ZHAO Xuebin. Experimental study on reheat steam temperature deviation adjustment for boiler co-firing coal with gases[J]. Thermal power generation, 2019, 48(2): 108-113.
DOI：

YAN Junfu, ZHAO Xuebin. Experimental study on reheat steam temperature deviation adjustment for boiler co-firing coal with gases[J]. Thermal power generation, 2019, 48(2): 108-113. DOI： 10.19666/j.rlfd.201805153.

摘要

为了研究混燃高炉煤气对炉膛上部烟气速度偏差的影响

对不同高炉煤气热量混燃比工况进行了数值模拟

得到炉膛上部烟气速度偏差随着高炉煤气热量混燃比的增加而增大。针对混燃高炉煤气引起的再热汽温偏差问题进行了分离燃尽风水平摆角优化调整实验

得到了最佳摆角组合。结果表明:分离燃尽风(SOFA)的1号、2号、3号、4号喷口水平偏转角度依次为–7.5°、+7.5°、+7.5°、–7.5°时

再热汽温偏差由17.10℃降低到了2.55℃

再热汽温为536.4℃

主蒸汽汽温偏差为4.15℃

主蒸汽温度为538.7℃。

Abstract

In order to study the effect of co-firing blast furnace gas on flue gas velocity deviation of upper furnace

numerical simulation was carried out under conditions with different heat adding ratios of blast furnace gas. It finds that the deviation of flue gas velocity increased with the heat adding ratio of blast furnace gas.Aiming at solving the problem of reheat steam temperature deviation caused by co-firing blast furnace gas

the experiment of adjusting the horizontal yaw angles of separated overfire air was carried out

and the optimal pattern of yaw angles was obtained. The results show that

when the separated overfire air yaw angles of No.1

No.2

No.3 and No.4 nozzle were adjusted to –7.5°

+7.5°

+7.5° and –7.5°

the deviation of reheat steam temperature reduced from 17.1 ℃ to 2.55 ℃

the reheat steam temperature was 536.4 ℃

the main steam temperature deviation was 4.15 ℃

and the main steam temperature was 538.7 ℃.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

FEED WATER FLOW MEASUREMENT DEVIATION IN ONCE-THROUGH BOILER:REASON ANALYSIS AND SOLUTIONS

OPTIMIZATION OF DEFLECTOR AND SPRAY AMMONIA IN SCR SYSTEM

Improvement and experimental study of the DCS main steam flow computational model

Wear in low temperature reheater and low reheat steam temperature:reason analysis and retrofitting

A review on utilization of combustible waste gas(Ⅰ):blast furnace gas,converter gas and coke oven gas

Related Author

GE Yan2 1.Institute of Electric Power

JIN Fei1

ZHANG Xiaotao1

TIAN Yingqing School of Environmental Science and Engineering

WANG Shan

SUN Yu

LI Yuan

HU Manyin

Related Institution

China Power Investment Henan Electric Power Co., Ltd. Kaifeng Power Generation Branch

College of Electric Power, North China University of Water Resources and Electric Power

College of Environmental Science and Engineering, North China Electric Power University

School of Electric Power, Inner Mongolia University of Technology

Xi'an Thermal Power Research Institute Co., Ltd

AI问答

⁰