LOW-CYCLE FATIGUE PROPERTY OF SA299 STEEL PLATES USED FOR BOILER DRUMS

doi:10.19666/j.rlfd.2001.06.006

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

LOW-CYCLE FATIGUE PROPERTY OF SA299 STEEL PLATES USED FOR BOILER DRUMS

更新时间：2025-09-28

- LOW-CYCLE FATIGUE PROPERTY OF SA299 STEEL PLATES USED FOR BOILER DRUMS
- Thermal Power Generation Issue 6, Pages: 23-26(2001)
- 作者机构：
  
  1. 国家电力公司热工研究院
  2. 石家庄热电厂
  3. 国营黄河机器制造厂,陕西,西安,710032
  4. 河北石家庄0500413.
  5. ,陕西,西安
- 作者简介：
- 基金信息：
- DOI：10.19666/j.rlfd.2001.06.006
  CLC： TK225
- Published：2001
- 稿件说明：
移动端阅览
LOW-CYCLE FATIGUE PROPERTY OF SA299 STEEL PLATES USED FOR BOILER DRUMS[J]. Thermal power generation, 2001, (6): 23-26.
DOI：

LOW-CYCLE FATIGUE PROPERTY OF SA299 STEEL PLATES USED FOR BOILER DRUMS[J]. Thermal power generation, 2001, (6): 23-26. DOI： 10.19666/j.rlfd.2001.06.006.

摘要

对碳含量有差异的SA2 99钢板母材及其焊缝材料的化学成分、显微组织、拉伸性能和冲击韧性进行试验

测定了碳含量不同的钢板的脆性形貌转变温度 (FATT)

重点对其低周疲劳特性进行了研究。结果表明 :对于碳含量有差异的钢板

其显微组织、晶粒度及夹杂物等级均属正常

焊缝中未发现淬硬组织 ;钢板的纵向和横向拉伸强度、塑性指标差异不大

冲击韧性满足有关标准要求 ;高含碳量钢板的FATT低于正常碳含量的钢板

其室温下的材料低周疲劳 (LCF)寿命相近

焊缝材料 370℃下的LCF寿命高于室温。

Abstract

Tests for chemical composition

micro-structure

tensile behavior and impact toughness of SA299 steel plate matrix and its weld-seam material possessing different carbon contents have been carried out

the fragility appearance transform temperature（FATT） of said steel plates has been measured

the investigation of low-cycle fatigue property having been emphasized. The obtained results indicate that the microstructure

grain-size and inclusion level of said steel plates were normal

hardened structure induced from quench had not been found; longitudinal and horizontal tensile strength as well as plasticity index of the said steel plates had no remarkable difference; their impact toughness could meet the requirements of related standards; the FATT of steel plates possessing higher carbon content was lower than that of steel plates possessing normal carbon content; their low-cycle fatigue lifes at room temperature were approximately the same

but the low-cycle fatigue life of weld-seam material at 370℃ was higher than that at room temperature.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

STUDY ON COMPLEX STRESS SITUATION AND LOW-CYCLE FATIGUE LIFE FOR BOILER DRUMS

Finite element analysis of transient stress in boiler drum during hot start-up process

Linear auto disturbance rejection control system for water level in drum

PREDICTIVE CONTROL OF WATERLEVEL IN THE BOILER DRUM

ON-LINE MONITORING AND MANAGEMENT OF SERVICE LIFE FOR BOILER DRUMS BASED ON DCS AND MIS

Related Author

LU Keyun11.East China Electric Power Testing and Research Institute Co Ltd

JIANG Yun1

LI Jiong1

YANG Jing1

ZHOU Xinya2

DUAN Peng1

XU Kaicheng

LI Yong

Related Institution

East China Electric Power Test and Research Institute Co., Ltd

East China Power Grid Co., Ltd

School of Energy and Power Engineering, Northeast Dianli University

School of Control and Computer Engineering, North China Electric Power University

Southeast University

AI问答

⁰