The model of grout migration height for pressured grouting at pile tip based on time-dependent behavior of viscosity and its engineering application

DAI Guo-liang; WAN Zhi-hui; ZHU Ming-xing; GONG Wei-ming

doi:10.16285/j.rsm.2018.0588

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

The model of grout migration height for pressured grouting at pile tip based on time-dependent behavior of viscosity and its engineering application

更新时间：2026-06-25

- The model of grout migration height for pressured grouting at pile tip based on time-dependent behavior of viscosity and its engineering application
- Vol. 39, Issue 8, Pages: 2941-2950(2018)
- 作者机构：
  
  1. 东南大学混凝土及预应力混凝土结构教育部重点实验室,江苏,南京,210096
  2. 东南大学土木工程学院,江苏,南京,210096
  3. 中国能源建设集团江苏省电力设计院有限公司,江苏,南京,211102
- 作者简介：
- 基金信息：
- DOI：10.16285/j.rsm.2018.0588
  CLC： TU473
- Online First：02 September 2018，
  
  Published：2018
- 稿件说明：
移动端阅览
DAI Guo-liang, WAN Zhi-hui, ZHU Ming-xing, et al. The model of grout migration height for pressured grouting at pile tip based on time-dependent behavior of viscosity and its engineering application[J]. 2018, 39(8): 2941-2950.
DOI：

DAI Guo-liang, WAN Zhi-hui, ZHU Ming-xing, et al. The model of grout migration height for pressured grouting at pile tip based on time-dependent behavior of viscosity and its engineering application[J]. 2018, 39(8): 2941-2950. DOI： 10.16285/j.rsm.2018.0588.

摘要

桩端后压浆浆液上返高度对后压浆桩承载力的计算影响较大。基于幂律型流体的黏度时变性特征，推导了考虑黏度时变性的桩端压力浆液上返的理论计算公式，并给出了参数的确定方法及成层土中浆液上返高度的迭代算法；结合台州湾大桥的接线工程，利用电磁波CT对桩基后压浆的加固效果进行了探测分析。结果表明，采用浆液沿压浆管道阻力损失的拟合值并考虑黏度时变性得到的浆液上返高度的计算结果与实测结果基本吻合且偏于安全，而忽略黏度时变性得到的计算结果偏大，会对后压浆桩的承载力设计造成不利影响。此外，电磁波CT能观测到桩体、水泥浆加固体及土体的分布情况，且能推测出水泥浆液在桩端的扩散范围和沿桩身的上返高度，可用于评价后压浆桩的压浆效果。研究成果可为后压浆桩的设计和效果检测提供参考和指导。

Abstract

The grout migration height has a remarkable influence on the calculation of bearing capacity for post-grouting pile. Based on the time-dependent behaviors of power-law cement grout

a theoretical expression to calculate upward grout migration along the pile side was proposed with consideration of time-dependent behavior of viscosity. The methods to determine the parameters and to iteratively determine the grout migration height in the layered soils were presented

respectively. Moreover

based on post-grouting project of the connecting engineering of Taizhou Bay Bridge in Zhejiang Province

the reinforcement effect of post-grouting piles was analyzed by means of electromagnetic wave CT. The results show that the predicted results of grout migration height on the basis of fitting value of pressure loss along the grouting pipeline and time-dependent behaviors of viscosity are consistent with measured results

which verifies the rationality of proposed expression for grout migration height. However

an overestimated bearing capacity of post-grouting piles may be obtained when ignoring the influence of time-dependent behaviors of viscosity

which has an unfavorable influence on pile design. Additionally

the electromagnetic wave CT can detect the distribution pattern of the pile

injected grout and soil

and can also deduce the diffusion range of cement grout at pile tip

as well as the grout migration height along the pile shaft

which can be applied to assess the grouting effect of grouted pile. The research results can provide reference and guidance for design and effect detection of post-grouting piles.

关键词

Keywords

references

Views

172

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study of column-hemispherical penetration grouting mechanism based on Bingham fluid of time-dependent behavior of viscosity

Penetration grouting mechanism of quick setting slurry considering spatiotemporal variation of viscosity

Enhanced mechanism of post-grouting pile in coral-reef limestone formations

Progressive fracture evolution and mechanical response of cavity-containing sandstone under low-frequency disturbance

Physical-mechanical properties and durability analysis of foamed lightweight soil based on excavated soil and fly ash

Related Author

YANG Zhi-quan1

HOU Ke-peng4

ZHANG Lian-zhen

ZHANG Qing-song

LIU Ren-tai

LI Shu-cai

Related Institution

Institute of Mountain Hazards and Environment, Chinese Academy of Sciences and Ministry of Water Resources

Key Laboratory of Mountain Hazards and Earth Surface Processes, Chinese Academy of Sciences

Graduate University of Chinese Academy of Sciences

Faculty of Land Resources Engineering, Kunming University of Science and Technology

China Nonferrous Metals Industry Survey and Design Institute of Kunming

AI问答

⁰