Effects of Intake Humidification Combined with Exhaust Gas Recirculation on Combustion and Emissions of a High Pressure Direct Injection Dual Fuel Low Speed Marine Engine

李长锟; 孙凯; 王怀印

doi:10.13949/j.cnki.nrjgc.2021.01.001

您当前的位置：

首页 >

文章列表页 >

Effects of Intake Humidification Combined with Exhaust Gas Recirculation on Combustion and Emissions of a High Pressure Direct Injection Dual Fuel Low Speed Marine Engine

更新时间：2026-04-16

- Effects of Intake Humidification Combined with Exhaust Gas Recirculation on Combustion and Emissions of a High Pressure Direct Injection Dual Fuel Low Speed Marine Engine
- Vol. 42, Issue 1, Pages: 1-6(2021)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：10.13949/j.cnki.nrjgc.2021.01.001
  CLC：
- Published：2021
- 稿件说明：
移动端阅览
李长锟，王天友，孙凯，王怀印.进气加湿结合废气再循环技术对高压直喷双燃料低速机燃烧及排放的影响[J].内燃机工程,2021,42(1):1-6.

李长锟, 孙凯, 王怀印. Effects of Intake Humidification Combined with Exhaust Gas Recirculation on Combustion and Emissions of a High Pressure Direct Injection Dual Fuel Low Speed Marine Engine[J]. 2021, 42(1): 1-6.
李长锟，王天友，孙凯，王怀印.进气加湿结合废气再循环技术对高压直喷双燃料低速机燃烧及排放的影响[J].内燃机工程,2021,42(1):1-6. DOI： 10.13949/j.cnki.nrjgc.2021.01.001.

李长锟, 孙凯, 王怀印. Effects of Intake Humidification Combined with Exhaust Gas Recirculation on Combustion and Emissions of a High Pressure Direct Injection Dual Fuel Low Speed Marine Engine[J]. 2021, 42(1): 1-6. DOI： 10.13949/j.cnki.nrjgc.2021.01.001.

摘要

基于CONVERGE软件建立了高压直喷双燃料船用发动机三维仿真模型，研究了空气加湿技术和废气再循环（exhaust gas recirculation

EGR）对发动机燃烧过程及排放的影响，并通过耦合进气加湿、EGR和天然气喷射策略等技术，最终得到满足Tier Ⅲ排放法规的可行性技术路线。结果表明，进气加湿降低NOx排放潜力较大（约55%），且对燃料经济性恶化程度较小（约1.6%）；单独采用进气加湿技术难以满足Tier Ⅲ排放标准，60%进气加湿程度结合较低程度EGR率（20%）可进一步提高降低NOx排放的潜力（78%）；为降低进气加湿和EGR带来的功率损失，在20%EGR率耦合60%进气加湿氛围下，提前2°曲轴转角喷射天然气可使天然气消耗率可降低约1g/(kW·h)，同时NOx排放满足Tier Ⅲ排放法规要求。

Abstract

Based on CONVERGE

a three dimensional simulation model of high pressure direct injection (HPDI) dual fuel marine engine was established. The effects of humid air motor (HAM) and exhaust gas recirculation (EGR) on engine combustion process and emissions were studied. With key technologies of intake humidification

EGR and natural gas injection strategy

a viable technical route was finally achieved to meet the Tier Ⅲ emission regulations. The results show that the intake humidification has great potential in reducing NOx (by about 55%) and it has a little impact on fuel economy (by about 1.6%). It is difficult to meet the Tier Ⅲ emission regulations by using the intake humidification technology alone. The combination of 60% intake humidification and a lower EGR rate (20%) can further reduce NOx emissions (by 78%). In order to reduce the power loss caused by the intake humidification and EGR when taking the measure of 20% EGR rate coupled with 60% intake humidification

the natural gas injection timing is advanced by 2° in crank angle

which can reduce the natural gas consumption by nearly 1g/(kW·h) while NOx emissions meet the Tier Ⅲ emission regulations.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effects of Different Intake Atmosphere Coupled with Exhaust Gas Recirculation on the Working Process of Dual Fuel Engines

Influences of Injection Strategies on Combustion and Emissions of a Diesel Engine with Two Injectors

Combustion and Emission Characteristics of a 2-Butanone/Diesel Dual-Fuel Engine

Effects of Intake Temperatures on Performances of the Engine Fueled with M15 Methanol Gasoline

Effects of Fuel Injection Strategy and In-Cylinder Temperature on Ammonia Diesel Dual Fuel Engines

Related Author

CHEN Guisheng

WEI Feng

LI Bing

WANG Zhenjiang

HUANG Zhen

LUO Ying

HUANG Li

LIU Rui

Related Institution

Troops of the PLA

Yunnan Key Laboratory of Internal Combustion Engine， Kunming University of Science and Technology

Shanghai Marine Diesel Engine Research Institute

National Key Laboratory of Marine Engine Science and Technology

Key Laboratory for Power Machinery & Engineering of Ministry of Education，Shanghai Jiao Tong University

AI问答

⁰