污秽超疏水硅橡胶表面的润湿闪络特性研究

doi:10.13334/j.0258-8013.pcsee.200280

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

污秽超疏水硅橡胶表面的润湿闪络特性研究

更新时间：2025-07-03

- 污秽超疏水硅橡胶表面的润湿闪络特性研究
- Issue 17, Pages: 5690-5700(2020)
- 作者机构：
  
  电力设备电气绝缘国家重点实验室(西安交通大学)
- 作者简介：
- 基金信息：
- DOI：10.13334/j.0258-8013.pcsee.200280
  CLC： TM216
- Published：2020
- 稿件说明：
移动端阅览
[J]. 2020, (17): 5690-5700.
DOI：

[J]. 2020, (17): 5690-5700. DOI： 10.13334/j.0258-8013.pcsee.200280.

摘要

超疏水表面具有优越的憎水性和自清洁特性

该文制备了相同材质的超疏水硅橡胶表面和普通疏水硅橡胶表面

设计并进行了雾水润湿条件下污秽表面的闪络试验

观测2种污秽表面的润湿状态、交流电场作用下水滴的动态行为和闪络电压

并对其机理进行探究。结果表明:经过雾水润湿

超疏水硅橡胶表面的污秽区域形成接触角大于90°的分离水滴

非污秽区域的水滴由于维持自身稳定的特性

其体积小于普通疏水表面。相较于干净水滴

污秽水滴的介电常数减小

导致所受电场力增大

但同时摩擦阻力也增大

影响其动态行为。交流电场作用下大部分污秽水滴振动、变形

一些极小污秽水滴及干净水滴滚动、合并。制备出的超疏水表面具有良好的闪络耐受能力

在倾角分别为0°、10°、20°放置时的闪络电压比普通疏水硅橡胶表面高58%

109%

108%。研究结果可以为超疏水表面在电力设备中的推广应用提供参考。

Abstract

The super-hydrophobic surface has excellent hydrophobicity and self-cleaning properties. In this paper

the super-hydrophobic and hydrophobic silicone rubber surface with the same material were prepared

and the flashover test of polluted surface was designed and then carried out under fog wetting condition. The wetting state of the polluted surface

the dynamic behavior of water droplets and flashover voltage with AC electric field were observed

and the mechanism was investigated. The results show that after being wetted by fog

discrete droplets with a contact angle greater than 90° are formed on the polluted area of the super-hydrophobic surface

and droplets on the non-polluted area of the super-hydrophobic surface are smaller than the hydrophobic surface due to their need for stability. Under AC electric field

the decrease of the dielectric constant of the polluted water droplet leads to the increase of the electric field force

but at the same time the friction increases too

which further affects its dynamic behavior. Most polluted water droplets vibrate and deform

and some very small polluted droplets and clean droplets roll and coalesce. The flashover voltage of the prepared superhydrophobic surface is 58%

109%

108% higher than that of the hydrophobic surface when placed at the angle of 0°

10°

20°. The results are of great significance for the application of super-hydrophobic surface in power equipment.

关键词

Keywords

references

颜薪瞩,李立浧,李剑,黄正勇,魏远,吴卓霖.甲基硅树脂超疏水涂层的防污闪性能[J].高电压技术,2018(09).

蒋兴良,杨忠毅,韩兴波,张东东,K.L.WONG.硅橡胶复合绝缘子在不同可溶污秽成分下的闪络特性研究[J].中国电机工程学报,2018(01).

李剑,王湘雯,黄正勇,赵学童,王飞鹏.超疏水绝缘涂层制备与防冰、防污研究现状[J].电工技术学报,2017(16).

魏远,李剑,卢明,黄正勇,颜薪瞩.人工雾霾环境下超疏水涂层绝缘子运行性能研究[J].高电压技术,2017(07).

梁曦东,高岩峰,王家福,李少华.中国硅橡胶复合绝缘子快速发展历程[J].高电压技术,2016(09).

戴罕奇,赵晨龙,梁建瑜,周军,王黎明.染污硅橡胶在不同憎水性时的污闪特性[J].电工技术学报,2016(10).

梁曦东,仵超,姚一鸣,高岩峰,王家福,刘瑛岩.受潮过程中复合绝缘子的有效附盐密度研究[J].中国电机工程学报,2015(21).

蒋兴良,赵世华,毕茂强,黎振宇,向泽.污秽绝缘子闪络特性与泄漏电流特性研究[J].中国电机工程学报,2013(31).

杨金鑫,文秀芳,皮丕辉,杨卓如.室温硫化硅橡胶的研究及其在防污闪涂料中的应用[J].涂料工业,2009(04).

张锐.硅橡胶在电力系统外绝缘中的应用[J].有机硅材料,2007(04).

王建武,文习山,刘海燕,欧阳剑萍.憎水性表面水珠的电场计算及放电研究[J].高电压技术,2006(11).

樊灵孟,刘平原,郑晓光,何宏明.广东电网污闪原因分析和防污对策[J].电瓷避雷器,2006(02).

蒋兴良,陈爱军,张志劲,胡建林,孙才新.盐密和灰密对110kV复合绝缘子闪络电压的影响[J].中国电机工程学报,2006(09).

张志劲,蒋兴良,孙才新.污秽绝缘子闪络特性研究现状及展望[J].电网技术,2006(02).

宿志一.防止大面积污闪的根本出路是提高电网的基本外绝缘水平——对我国电网大面积污闪事故的反思[J].中国电力,2003(12).

关志成.硅橡胶材料在电力设备外绝缘上的应用[J].环境技术,1994(04).

关志成,于素竹,贾志东.RTV硅橡胶涂层耐污闪性能及憎水迁移特性[J].高电压技术,1993(04).

关志成[等]著.绝缘子及输变电设备外绝缘[M].清华大学出版社,2006.

Run Zhao,Yu Chen,Guozhen Liu,Yucheng Jiang,Kunlin Chen.Fabrication of self-healing waterbased superhydrophobic coatings from POSS modified silica nanoparticles[J].Materials Letters,2018.

Tatsuya Sakoda,Kosei Tabira,Takuma Miyake,Noriyuki Hayashi,Kenich Haji,Yoshiaki Aka,Tomikazu Anjiki,Takato Fukano.Discharge behavior and dielectric performance of artificially polluted hydrophobic silicone rubber[J].Journal of Electrostatics,2018.

Jian Li,Yuan Wei,Zhengyong Huang,Feipeng Wang,Xinzhu Yan,Zhuolin Wu.Electrohydrodynamic behavior of water droplets on a horizontal super hydrophobic surface and its self-cleaning application[J].Applied Surface Science,2017.

Views

171

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

交流电弧沿染污绝缘表面发展过程的研究

高海拔条件下绝缘子污秽闪络特性及其校正

染污光滑圆柱绝缘子沿面电场分布对闪络过程的影响

绝缘子玻璃态表面化学吸附层的结构及特性研究

支柱绝缘子污秽闪络机理分析

Related Author

HU Jian-lin

ZHANG Zhi-jin

ZHANG Yong-ji

SHU Li-chun

JIANG Xing-liang

屠幼萍

杨堃

李成榕

Related Institution

Key Laboratory of High Voltage and Electrical New Technology of Ministry of Education,Chongqing University,Shapingba District

重庆大学高电压与电工新技术教育部重点实验室重庆市沙坪坝区400044

Beijing Key Laboratory of High Voltage & EMC,North China Electric Power University,Changping District

华北电力大学高电压与电磁兼容北京市重点实验室北京市昌平区 102206

Hebei Provincial Key Laboratory of Power Transmission Equipment Security Defense,North China Electric Power University

AI问答

⁰