Operation Optimization of Microbial Control of Seawater Desalination

Jun LIU; Yongqiang CHEN; Jingjian SUN

doi:10.12096/j.2096-4528.pgt.2018.059

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Operation Optimization of Microbial Control of Seawater Desalination

Power Generation and Environment Protection | 更新时间：2025-06-06

- Operation Optimization of Microbial Control of Seawater Desalination
- Power Generation Technology Vol. 39, Issue 4, Pages: 386-388(2018)
- 作者机构：
  
  辽宁红沿河核电有限公司, 辽宁省瓦房店市 116319
- 作者简介：
- 基金信息：
- DOI：10.12096/j.2096-4528.pgt.2018.059
  CLC：
- Received：19 July 2018，
  
  Published：30 August 2018
- 稿件说明：
移动端阅览
Jun LIU, Yongqiang CHEN, Jingjian SUN. Operation Optimization of Microbial Control of Seawater Desalination[J]. Power Generation Technology, 2018, 39(4): 386-388.
DOI：

Jun LIU, Yongqiang CHEN, Jingjian SUN. Operation Optimization of Microbial Control of Seawater Desalination[J]. Power Generation Technology, 2018, 39(4): 386-388. DOI： 10.12096/j.2096-4528.pgt.2018.059.

摘要

微生物污染是海水淡化系统反渗透膜污染的主要类型之一。2016年春季，红沿河核电厂海水淡化系统一级反渗透膜出现压差频繁快速升高、脱盐率不变、产水量下降的现象，反渗透膜解体解剖分析表明受到微生物污染。分析反渗透膜压差频繁升高、产水量下降的原因，是由于杀菌不彻底造成微生物滋生，从而导致压差升高。通过增加海水预处理杀菌剂次氯酸钠加药量，提高超滤水箱出口残余氯水平，以减少海水中微生物滋生，并在不同的季节，控制不同浓度的加药量。经过运行验证，该措施能够将反渗透系统进水的微生物控制在较低水平，降低反渗透膜压差升高的频率，提高了红沿河核电厂海水淡化系统设备运行可靠性，取得了很好的效果。

Abstract

Microbial pollution is one of the main types of reverse osmosis membrane pollution in seawater desalination system. In the spring of 2016

frequent and rapid increasing of pressure difference

constant desalting rate and decreased water yield happened in the first-order reverse osmosis membrane of the seawater desalination system in Hongyanhe nuclear power plant. After dissection analysis of reverse osmosis membrane

the main reason was microbial contamination. The microbial growth caused by incomplete sterilization lead to an increasing of pressure difference and decreasing of water yield. By increasing the amount of sodium hypochlorite added to the pretreatment fungicide of seawater

the amount of residual chlorine at the outlet of the ultrafiltration water tank was increased in order to decrease the breeding of microorganisms in the sea water. And in different seasons

different concentrations of dosage would be controlled. It is verified that this measure can control the inlet microorganism of the reverse osmosis system at a low level

reduce the increasing frequency of pressure difference

and improve the operation reliability of the equipment of the sea water desalination system of Hongyanhe nuclear power plant.

关键词

Keywords

references

郑猛, 吴青芸, 周浩媛, 等.海水淡化反渗透膜微生物污染及防控研究进展[J].膜科学与技术, 2015, 35(1):123-130.

侯钰, 桑军强, 李本高.反渗透膜污染成因与防治[J].工业用水与废水, 2008, 39(1):23-26.

周军, 方少明, 张宏忠, 等.反渗透膜在水处理中的研究进展[J].过滤与分离, 2006, 16(2):12-15.

姜忠英, 夏明芳.反渗透在水污染控制中的应用[J].污染防治技术, 2003, 16(1):21-23

曹路, 黄慧群, 张诚义, 等.反渗透膜的污染及其化学清洗[J].清洗世界, 2006, 22(8):9-13.

彭新红, 初喜章, 单科, 等.基于海水淡化的生物电化学脱盐技术研究进展及应用前景[J].应用化学, 2015, 32(2):134-142.

王钢, 郭俊, 张志鹏, 等.海水淡化反渗透系统污染分析及化学清洗[J].清洗世界, 2016, 32(11):10-14

张岩岗, 吴礼云, 徐珍良, 等.低温多效海水淡化不锈钢的腐蚀实验研究[J].冶金动力, 2018, (2):1-4.

张贺, 冯向东, 金康华, 等.某电厂海水淡化反渗透膜性能下降原因分析[J].水处理技术, 2018, 44(7):126-128.

张伟星.污水深度回用装置反渗透膜的污染及化学清洗[J].中国氯碱, 2010(11):39-42.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of Steam Ejector on Low-temperature Multi-effect Distillation System Under Wide Load Operation of Power Plant

Related Author

Yousen ZHANG

Jiang FAN

Tao DING

Weixiong CHEN

Shuran ZHAO

Miaomiao LIU

Related Institution

Shenhua Guohua(Beijing) Electric Power Research Institute Co., Ltd., Chaoyang District

State Key Laboratory of Multiphase Flow in Power Engineering(Xi'an Jiaotong University)

AI问答

⁰