Performance Diagnosis and Optimization of Flue Flow Field of 1060 MW Coal-Fired Unit

Haiyan MA; Lei ZHOU; Tingwen WANG; Jing ZHOU; Houzhang TAN; Limei JIN

doi:10.12096/j.2096-4528.pgt.2018.039

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Performance Diagnosis and Optimization of Flue Flow Field of 1060 MW Coal-Fired Unit

Power Generation and Environmental Protection | 更新时间：2025-06-06

- Performance Diagnosis and Optimization of Flue Flow Field of 1060 MW Coal-Fired Unit
- Power Generation Technology Vol. 39, Issue 3, Pages: 253-258(2018)
- 作者机构：
  
  1.华电宁夏灵武发电有限公司, 宁夏回族自治区银川市 751400
  2.热流科学与工程教育部重点实验室(西安交通大学), 陕西省西安市 710049
  3.西安格瑞电力科技有限公司, 陕西省西安市 710043
- 作者简介：
- 基金信息：
  
  Key Research Program of Zhejiang Province(2018C03036)
- DOI：10.12096/j.2096-4528.pgt.2018.039
  CLC：
- Received：07 December 2017，
  
  Published：28 June 2018
- 稿件说明：
移动端阅览
Haiyan MA, Lei ZHOU, Tingwen WANG, et al. Performance Diagnosis and Optimization of Flue Flow Field of 1060 MW Coal-Fired Unit[J]. Power Generation Technology, 2018, 39(3): 253-258.
DOI：

Haiyan MA, Lei ZHOU, Tingwen WANG, et al. Performance Diagnosis and Optimization of Flue Flow Field of 1060 MW Coal-Fired Unit[J]. Power Generation Technology, 2018, 39(3): 253-258. DOI： 10.12096/j.2096-4528.pgt.2018.039.

摘要

燃煤机组烟道结构和布置形式不仅决定了烟风系统阻力的大小，而且影响相关设备的运行状态。某2×1060 MW机组引风机至脱硫塔之间的烟道设计不合理，使两台并联引风机中的一台振动严重，致机壳开裂，导致机组长期低负荷运行，影响机组的可靠性和经济性。该文采用流体动力学计算软件对该部分烟道的流场进行数值模拟，分析烟道设计结构中存在的主要问题，结合现场条件提出最优改造方案。改造实施后，该部分烟道的整体阻力降低为300 Pa，并联引风机出口静压偏差低于3%，将引风机振动由4.6 mm/s以上降为2.5 mm/s左右，控制在安全运行允许的范围内。该次优化解决了引风机振动问题并使烟道阻力大幅降低，为电厂创造了经济效益。

Abstract

The structure and layout of flue gas system of coal-fired units not only determine the resistance of the smoke wind system

but also affect the operation state of related equipment. Due to the unreasonable flue structure between induced draft fan and desulfurization tower in a 2×1060 MW unit

one of the two parallel induced draft fans oscillated badly

affected the reliability and economy of the unit. A numerical simulation of the flow field of this part of the flue gas was carried out by the software of fluid dynamics. The problems existing in the flue gas were analyzed

and the optimum plan was proposed to reform the flue in combination with the field conditions. After technological transformation

the flue resistance of this part decreases to 300 Pa

parallel deviation is less than 3%

and the vibration detection value of the fan is reduced from more than 4.6 mm/s to 2.5 mm/s. This creates huge economic benefits for power plants.

关键词

Keywords

references

刘明, 孟桂祥, 严俊杰, 等.火电厂除尘器前烟道流场性能诊断与优化[J].中国电机工程学报, 2013, 33(11):1-6.

魏宏鸽, 张杨, 杜振, 等.燃煤机组超低排放改造对机组能耗增加的影响分析及节能优化措施探讨[J].发电与空调, 2017, 38(6):14-17, 33.

车得福, 庄正宁, 李军, 等.锅炉[M].西安:西安交通大学出版社, 2008.

段小云.引风机振动大的原因分析及治理[J].电力安全技术, 2008, 10(10):11-13.

冯庭有.1000 MW机组调试期间引风机振动大的原因分析[J].发电设备, 2009, 6:447-450.

梁绍华, 宁新宇, 张恩先, 等.双炉膛四角切圆煤粉锅炉分层掺烧数值模拟及性能试验研究[J].中国电机工程学报, 2011, 31(26):9-15.

王超, 程乐鸣, 周星龙, 等.600 MW超临界循环流化床锅炉炉膛气固流场的数值模拟[J].中国电机工程学报, 2011, 31(14):1-7.

赵大周, 郑文广, 何胜, 等.基于CFD的脱硫塔内部流场优化[J].发电与空调, 2016, 37(1):35-38.

张凯峰.480 t/h锅炉空气分级燃烧优化数值模拟[J].发电与空调, 2014, 35(2):8-11.

杨俊波, 候庆伟, 祁金胜, 等.引风机前烟道阻力特性分析[J].电站系统工程, 2011, 27(1):69-70.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Simulation of Fly Ash Deposition Characteristics and Flow Field Optimization for SCR External Flue

Analysis of Influence of Coal-Ammonia Co-firing on the Heat Transfer Characteristics of Heating Surfaces in Coal-Fired Boiler

Study on Numerical Simulation of Dynamic Deposition and Shedding Characteristics of Zhundong Coal Ash

Numerical Simulation Study on Effect of Deflectors on Aerodynamic Characteristics of Horizontal Axis Wind Turbines

Reconstruction of Temperature Distribution in Acoustic Tomography Based on Robust Regularized Extreme Learning Machine

Related Author

LI Kai

ZHANG Pingheng

MENG Zhihao

CAO Yunning

XU Yao

LIU Li

LI Lianming

XU Yiwei

Related Institution

College of Energy Engineering, Zhejiang University

Jiaxing New Jies Thermal Power Co., Ltd.

Ningxia Jingneng Ningdong Power Generation Co., Ltd., Lingwu 751400, Ningxia Hui Autonomous Region

Key Laboratory of Low-Grade Energy Utilization Technology and System (Chongqing University), Ministry of Education, Shapingba District

Guoshen Technical Support Center, CHN ENERGY Investment Group Co., Ltd.

AI问答

⁰