Sliding Mode Coordinated Control and Experimental Study of Dual Permanent Magnet Synchronous Motor

Zhou Lin-na; Jin Nan-nan; Wang Hai; Yang Chun-yu

doi:10.12052/gdutxb.220059

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

Sliding Mode Coordinated Control and Experimental Study of Dual Permanent Magnet Synchronous Motor

更新时间：2026-05-27

- Sliding Mode Coordinated Control and Experimental Study of Dual Permanent Magnet Synchronous Motor
- Vol. 39, Issue 5, Pages: 83-92(2022)
- 作者机构：
  
  中国矿业大学信息与控制工程学院,江苏,徐州,221116
- 作者简介：
- 基金信息：
- DOI：10.12052/gdutxb.220059
  CLC： TP273
- Published：2022
- 稿件说明：
移动端阅览
周林娜, 金南南, 王海, 杨春雨. 双永磁同步电机滑模协调控制及实验研究[J]. 广东工业大学学报, 2022, 39(5): 83-92.

Zhou Lin-na, Jin Nan-nan, Wang Hai, et al. Sliding Mode Coordinated Control and Experimental Study of Dual Permanent Magnet Synchronous Motor[J]. 2022, 39(5): 83-92.
周林娜, 金南南, 王海, 杨春雨. 双永磁同步电机滑模协调控制及实验研究[J]. 广东工业大学学报, 2022, 39(5): 83-92. DOI： 10.12052/gdutxb.220059.

Zhou Lin-na, Jin Nan-nan, Wang Hai, et al. Sliding Mode Coordinated Control and Experimental Study of Dual Permanent Magnet Synchronous Motor[J]. 2022, 39(5): 83-92. DOI： 10.12052/gdutxb.220059.

摘要

针对现有的双永磁同步电机协调控制方法无法兼顾扰动抑制和协调控制精度的问题，研究具有不确定性和非匹配扰动的双永磁同步电机系统协调控制。首先，基于系统不确定性和非匹配扰动，建立双电机系统的数学模型；其次，将交叉耦合控制与传统PI控制相结合，得到协调控制模型；再次，提出一种基于干扰观测器的积分滑模方法设计协调控制器，以有效抑制系统的非匹配扰动；最后，在基于dSPACE的多电机实验平台进行半实物仿真实验。实验结果表明，该方法能有效提高系统在启动和负载突变时的转速同步和转矩同步性能。

Abstract

Aiming at the problem that the existing coordinated control methods of dual permanent magnet synchronous motor can not give consideration to disturbance suppression and coordinated control precision

the coordinated control of dual permanent magnet synchronous motor system with uncertainty and unmatched disturbance is studied. Firstly

the mathematical model of dual motor system is established based on system uncertainty and unmatched disturbance. Secondly

the coordinated control model is obtained by combining cross coupling control with traditional PI control. Thirdly

an integral sliding mode method based on disturbance observer is proposed to design a coordination controller to suppress the unmatched disturbances effectively. Finally

a semi-physical simulation is carried out on a multi-motor experimental platform based on dSPACE. The experimental results show that the proposed method can effectively improve the speed synchronization and torque synchronization performance of the system under startup and load mutation.

关键词

Keywords

references

YU Z, GAO J L. A research on an implementation method of speed sensorless control for dual three-phase permanent magnet synchronous motor [J]. Journal of Guangdong University of Technology, 2019, 36(3): 83-90.

ZHOU L N, JIN N N, WANG H, et al . Design of permanent magnet synchronous motor control semi-physical simulation system [J ] . Research and Exploration in Laboratory, 2022, 41(2): 89-93.

CHEN Q, YU X, SUN M, et al . Adaptive repetitive learning control of PMSM servo systems with bounded nonparametric uncertainties: theory and experiments [J ] . IEEE Transactions on Industrial Electronics, 2020, 68(9): 8626-8635.

WU G, HUANG S, WU Q, et al . Robust predictive torque control of N* 3-phase PMSM for high-power traction application [J ] . IEEE Transactions on Power Electronics, 2020, 35(10): 10799-10809.

LIU X, YU H. Continuous adaptive integral-type sliding mode control based on disturbance observer for PMSM drives [J]. Nonlinear dynamics, 2021, 104(2): 1429-1441.

WANG M, DONG X, REN X, et al . SDRE based optimal finite-time tracking control of a multi-motor driving system [J ] . International Journal of Control, 2021, 94(9): 2551-2563.

SUN X, HU C, ZHU J, et al . MPTC for PMSMs of EVs with mult i-motor driven system considering optimal energy allocation [J ] . IEEE Transactions on Magnetics, 2019, 55(7): 1-6.

ZHOU L N, WANG Z, LIU J H, et al . Rigid-flexible coupling multi-motor control experiment platform based on dSPACE [J ] . Experiment Technology and Management, 2020, 37(11): 120-124.

YANG C Y, MENG F Y, XU Y M, et al . Coordinated control Methods for multi-motor drive systems of large inertia load: a survey [J ] . Electric Machines and Control Application, 2019, 46(3): 1-7.

SHI T, LIU H, GENG Q, et al . Improved relative coupling control structure for multi-motor speed synchronous driving system [J ] . IET Electric Power Applications, 2016, 10(6): 451-457.

TLV Y, REN X, NA J. Online Nash-optimization tracking control of multi-motor driven load system with simplified RL scheme [J]. ISA Transactions, 2020, 98(3): 251-262.

SANT A V, KHADKIKAR V, XIAO W, et al . Four-axis vector-controlled dual-rotor PMSM for plug-in electric vehicles [J ] . IEEE Transactions on Industrial Electronics, 2015, 62(5): 3202-3212.

CHU X, NIAN X, WAN G H, et al . Distributed fault tolerant tracking control for large-scale multi-motor web-winding systems [J ] . IET Control Theory Applications, 2019, 13(4): 543-553.

SAGITOV P I, ALMURATOVA N K, TOYGOZHINOVA Z Z, et al . Mathematical modeling and optimization of the control system for multi-motor electric drive of conveyor belt [J ] . Int. J of Engineering Research and Technology, 2019, 12(6): 899-911.

LUO X, TANG Q, SHEN A, et al . PMSM sensorless control by injecting HF pulsating carrier signal into estimated fixed-frequency rotating reference frame [J ] . IEEE Transactions on Industrial Electronics, 2016, 63(4): 2294-2303.

UTKIN V, POZNYAK A, ORLOV Y, et al . Conventional and high order sliding mode control [J ] . Journal of the Franklin Institute, 2020, 357(15): 10244-10261.

HU J, ZHANG H, LIU H, et al . A survey on sliding mode control for networked control systems [J ] . International Journal of Systems Science, 2021, 52(6): 1129-1147.

QU S, ZHAO L, XIONG Z. Cross-layer congestion control of wireless sensor networks based on fuzzy sliding mode control [J]. Neural Computing and Applications, 2020, 32(17): 13505-13520.

WANG S, NA J, CHEN Q. Adaptive predefined performance sliding mode control of motor driving systems with disturbances [J]. IEEE Transactions on Energy Conversion, 2020, 36(3): 1931-1939.

WANG Y, XIE X, CHADLI M, et al . Sliding-mode control of fuzzy singularly perturbed descriptor systems [J ] . IEEE Transactions on Fuzzy Systems, 2020, 29(8): 2349-2360.

TU Z, FEI F, DENG X. Untethered flight of an at-scale dual-motor hummingbird robot with bio-inspired decoupled wings [J]. IEEE Robotics and Automation Letters, 2020, 5(3): 4194-4201.

ZOU M, FANG P, PENG H, et al . Study on synchronization characteristics for self-synchronous vibration system with dual-frequency and dual-motor excitation [J ] . Journal of Mechanical Science and Technology, 2019, 33(3): 1065-1078.

KHALIFEH J M, DIBBLE C F, DY C J, et al . Cost-effectiveness analysis of combined dual motor nerve transfers versus alternative surgical and nonsurgical management strategies to restore shoulder function following upper brachial plexus injury [J ] . Neurosurgery, 2019, 84(2): 362-377.

ZHENG W, WANG Y, JIAN C, et al . Fault-tolerant contr ol of NPC three-level inverters-fed double-stator-winding PMSM drives based on vector space decomposition [J ] . IEEE Transactions on Industrial Electronics, 2017, 64(99): 8446-8458.

MYNAR Z, VESELY L, VACLAVEK P. PMSM model predictive control with field-weakening implementation [J]. IEEE Transactions on Industrial Electronics, 2016, 63(8): 5156-5166.

FENG G, LAI C, MUKHERJEE K, et al . Current injection-based online parameter and VSI nonlinearity estimation for PMSM drives using current and voltage DC components [J ] . IEEE Transactions on Transportation Electrification, 2016, 2(2): 119-128.

BELDA K, VOMIK D. Explicit generalized predictive control of speed and position of PMSM drives [J]. IEEE Transactions on Industrial Electronics, 2016, 63(6): 3889-3896.

KONTARCEK A, BAJEC P, NEMEC M, et al . Cost-effective three-phase PMSM drive tolerant to open-phase fault [J ] . IEEE Transactions on Industrial Electronics, 2015, 62(11): 6708-6718.

MAZZOLETTI M A, BOSSIO G R, ANGELO C, et al . A model-based strategy for interturn short-circuit fault diagnosis in PMSM [J ] . IEEE Transactions on Industrial Electronics, 2017, 64(9): 7218-7228.

JIAN H, YANG Q, HUI L. Adaptive robust nonlinear feedback control of chaos in PMSM system with modeling uncertainty [J]. Applied Mathematical Modelling, 2016, 40(19-20): 8265-8275.

WEI W, ZHANG J, MING C. A Dual-Level Hysteresis current control for one five-leg VSI to control two PMSMs [J]. IEEE Transactions on Power Electronics, 2016, 32(1): 804-814.

SHI T, WANG Z, XIA C. Speed measurement error suppression for PMSM control system using self-adaption kalman observer [J]. IEEE Transactions on Industrial Electronics, 2015, 62(5): 2753-2763.

WIBOWO W K, JEONG S K. Improved estimation of rotor position for sensorless control of a PMSM based on a sliding mode observer [J]. Journal of Central South University, 2016, 23(7): 1643-1656.

ULLAH S, MEHMOOD A, KHAN Q, et al . Robust integral sliding mode control design for stability enhancement of under-actuated quadcopter [J ] . International Journal of Control, Automation and Systems, 2020, 18(7): 1671-1678.

SAMAT A A, ISHAK D, IQBAL S, et al . Comparison between takagi sugeno FIS and PI controller: an adaptation scheme of MRAS for speed sensorless control of PMSM [J ] . Applied Mechanics Materials, 2015, 785(2): 193-197.

SALEH, KAMEL, SUMNER, et al . Modeling and simulation of sensorless control of four-leg inverter PMSM drives in the case of a single-phase open circuit fault. [J ] . Turkish Journal of Electrical Engineering Uter Sciences, 2016, 24(5): 3807-3820.

ZHOU Q, CHEN G D, LU R Q, et al . Disturbance-observer-based event-triggered control for multi-agent systems with input saturation [J ] . Sci Sin Inform, 2019, 49(11): 1502-1516.

VADIVEL R, JOO Y H. Reliable fuzzy H∞ control for permanent magnet synchronous motor against stochastic actuator faults [J]. IEEE Transactions on Systems, Man, and Cybernetics: Systems, 2019, 51(4): 2232-2245.

YANG B, ZHOU Q, CAO L, et al . Event-triggered control for multi-agent systems with prescribed performance and full state constraints [J ] . Acta Automatica Sinica, 2019, 45(8): 1527-1535.

XIA J, LI Z, YU D, et al . Robust speed and current control with parametric adaptation for surface-mounted PMSM considering system perturbations [J ] . IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, 9(3): 2807-2817.

GAO Y, SUN B, LU G. Passivity-based integral sliding-mode control of uncertain singularly perturbed systems [J]. IEEE Transactions on Circuits Systems II Express Briefs, 2011, 58(6): 386-390.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Ground Deformation Monitoring and Influencing Factors Analysis in Fuzhou City Based on PSI Technology

Efficient Temporal Modeling for RGB-T Tracking

A Study of Power Quality Regulation Strategies of Energy Storage Converters

Modeling of 3D NAND Memory Cells with Taper Angle and Programming Strategy Optimization

Energy Management Strategy of Hybrid Locomotive Based on Road Condition Parameters

Related Author

No data

Related Institution

No data

AI问答

⁰