Effect of Ground Granulated Blast Furnace Slag on Properties Based on Analysis of Water Film Thickness Hypothesis

Wen Meng-dan; Chen Jia-jian; Gao Yu-shen; Ma An-min

doi:10.12052/gdutxb.170161

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

Effect of Ground Granulated Blast Furnace Slag on Properties Based on Analysis of Water Film Thickness Hypothesis

更新时间：2026-05-27

- Effect of Ground Granulated Blast Furnace Slag on Properties Based on Analysis of Water Film Thickness Hypothesis
- Vol. 35, Issue 4, Pages: 119-126(2018)
- 作者机构：
  
  佛山科学技术学院　土木工程系,广东,佛山,528000
- 作者简介：
- 基金信息：
- DOI：10.12052/gdutxb.170161
  CLC： TU528.52
- Online First：09 July 2018，
  
  Published：2018
- 稿件说明：
移动端阅览
温梦丹, 陈嘉健, 高御审, 马岸民. 基于水膜厚度假设分析磨细高炉矿渣对水泥浆性能影响[J]. 广东工业大学学报, 2018, 35(4): 119-126.

Wen Meng-dan, Chen Jia-jian, Gao Yu-shen, et al. Effect of Ground Granulated Blast Furnace Slag on Properties Based on Analysis of Water Film Thickness Hypothesis[J]. 2018, 35(4): 119-126.
温梦丹, 陈嘉健, 高御审, 马岸民. 基于水膜厚度假设分析磨细高炉矿渣对水泥浆性能影响[J]. 广东工业大学学报, 2018, 35(4): 119-126. DOI： 10.12052/gdutxb.170161.

Wen Meng-dan, Chen Jia-jian, Gao Yu-shen, et al. Effect of Ground Granulated Blast Furnace Slag on Properties Based on Analysis of Water Film Thickness Hypothesis[J]. 2018, 35(4): 119-126. DOI： 10.12052/gdutxb.170161.

摘要

为探索磨细高炉矿渣对水泥浆性能及其水膜厚度的影响

研究测量了30组不同水胶比、不同磨细高炉矿渣掺量的水泥–矿渣复合浆体的流动性能、黏聚性和抗压强度. 为探索浆体的流变性能控制机理

进一步测量了5组不同磨细高炉矿渣掺量水泥–矿渣复合浆体的填充密度

并基于填充密度测量结果计算出各浆体试样配比的水膜厚度

探索水膜厚度对水泥–矿渣复合浆体流变性能的影响. 实验结果表明

适量磨细高炉矿渣的掺入能提高浆体的流动性能和抗压强度

黏聚性些许减弱

最优配比磨细高炉矿渣掺量为5%

此时水泥–矿渣复合浆体综合性能最好. 磨细高炉矿渣掺入能提高胶凝材料的填充密度

水膜厚度为流动性主要控制因素

水泥浆的流动性能随水膜厚度增大而增大.

Abstract

To study the effect of ground granulated blast furnace slag (GGBS) on the flowability

cohesiveness and strength of cement paste

30 mixes of cement paste samples with different water/cementitious material ratios and different GGBS contents were measured. To reveal the flowability mechanism of GGBS cement paste

the packing density of 5 different cementitious mixes with various GGBS content was measured. The water film thickness of each cement paste mix was calculated based on the packing density test

and the effect of water film thickness on the flowability of GGBS cement paste was discussed. Results demonstrated that addition of moderate GGBS could increase the flowability and compressive strength

but impair the cohesiveness. The best overall performance of cement paste occurs when 5% GGBS is added. The addition of GGBS had positive effect on packing density of cementitious materials. The water film thickness is the major governing factor of flowability of GGBS cement paste

and the flowability of cement paste increases with the increase of water film thickness.

关键词

Keywords

references

PAL S C, MUKHERJEE A, PATHAK S R. Investigation of hydraulic activity of ground granulated blast furnace slag in concrete [J]. Cement and Concrete Research, 2003, 33(9): 1481-1486.

HAWILEH R, ABDALLA J, FARDMANESH F, et al . Performance of reinforced concrete beams cast with different percentages of GGBS replacement to cement [J ] . Archives of Civil and Mechanical Engineering, 2017, 17(3): 511-519.

WANG Q, LI M Y, SHI M X. Hydration properties of cement-steel slag-ground granulated blast furnace slag complex binder [J]. Journal of The Chinese Ceramic Society, 2014, 42(5): 629-634.

李胜男. 掺矿渣粉混凝土的架构理论研究[D]. 大连: 大连理工大学建筑与土木工程学院, 2013.

YANG W W, QIAN J S, FAN Y R. Effect of ground granulated blast furnace slag on both frost-resistance and chloride ions diffusion properties of marine concrete [J]. Journal of The Chinese Ceramic Society, 2009, 37(1): 29-34.

ZHANG W M, BA H J. Effect of ground granulated blast-furnace slag (GGBFS) and silica fume (SF) on chloride migration through concrete subjected to repeated loading [J]. Science China Technology Science, 2012, 42(12): 1449-1455.

李建勇, 姚燕, 田培. 利用超细矿渣和硅灰配制高性能混凝土的研究[J]. 混凝土, 1997(4): 12-22.

ZHU J, The application of polypropylene fiber in high performance concrete[J]. The application of polypropylene fiber in high performance concrete [J]. Journal of Guangdong University of Technology, 2000, 17(3): 15-18.

LUO J, YU B S, ZHA J. Research on test of large volume concrete and high concrete with fine ground slag [J]. Coal Engineering, 2006(1): 78-81.

刘仍光. 水泥矿渣复合胶凝材料的水化机理与长期性能[D]. 北京: 清华大学土木工程学院, 2013.

LIU R G, YAN P Y. Hydration characteristics of slag in cement–slag complex binder [J]. Journal of The Chinese Ceramic Society, 2012, 40(8): 1112-1118.

姚立红, 李瑞林, 刘生超, 等. 水泥净浆流动度与混凝土流动性能相关性研究[J]. 水泥工程, 2016(6): 20-21.

武斌. 水泥净浆和砂浆流动度与混凝土流变性能相关性试验[J]. 广东建材, 2016, 32(9): 63-65.

AITCIN P C. High-performance Concrete[M].London (UK): E FN Spon, 1998.

OKAMURA H, OUNCJI M. Self-compacting concrete [J]. Journal of Advanced Concrete Technology, 2003, 1(1): 5-15.

British Standards Institution. BS EN 445: Grout for Prestressing Tendons-Test Methods[M]. London (UK): BSI, 1997.

CHEN J J, LEI Y X, XU W T, et al . Calculation of water film thickness and the effects on rheology [J ] . Journal of Foshan University (Natural Science Edition), 2014, 32(3): 49-56.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence Analysis of Porosity in Asphalt Pavement on Project Quality

SCA-YOLO: Real-time Target Detection Based on Deformable Convolution and Context-aware Attention

An Optimal Operation Strategy for Community Microgrid Alliances Considering Power Exchange under Multi-package Shared Energy Storage Model

Modeling of 3D NAND Memory Cells with Taper Angle and Programming Strategy Optimization

Research and Implementation of a Pulsed Laser Ranging Method Based on Digital Mixing

Related Author

LUO Zhi-qiang

Related Institution

No data

AI问答

⁰