A Thermal Economy Analysis of a Network Integrated Membrane Distillation and Industrial Waste Heat

Kang Rui-li; Luo Xiang-long; Huang Xiao-jian; Chen Ying

doi:10.12052/gdutxb.170126

English Version Journal Login

您当前的位置：

首页 >

文章列表页 >

A Thermal Economy Analysis of a Network Integrated Membrane Distillation and Industrial Waste Heat

更新时间：2026-05-27

- A Thermal Economy Analysis of a Network Integrated Membrane Distillation and Industrial Waste Heat
- Vol. 35, Issue 2, Pages: 11-18(2018)
- 作者机构：
  
  广东工业大学　材料与能源学院,广东,广州,510006
- 作者简介：
- 基金信息：
- DOI：10.12052/gdutxb.170126
  CLC： TK284
- Online First：09 March 2018，
  
  Published：2018
- 稿件说明：
移动端阅览
康瑞丽, 罗向龙, 黄晓健, 陈颖. 膜蒸馏与工艺余热网络集成系统的热经济分析[J]. 广东工业大学学报, 2018, 35(2): 11-18.

Kang Rui-li, Luo Xiang-long, Huang Xiao-jian, et al. A Thermal Economy Analysis of a Network Integrated Membrane Distillation and Industrial Waste Heat[J]. 2018, 35(2): 11-18.
康瑞丽, 罗向龙, 黄晓健, 陈颖. 膜蒸馏与工艺余热网络集成系统的热经济分析[J]. 广东工业大学学报, 2018, 35(2): 11-18. DOI： 10.12052/gdutxb.170126.

Kang Rui-li, Luo Xiang-long, Huang Xiao-jian, et al. A Thermal Economy Analysis of a Network Integrated Membrane Distillation and Industrial Waste Heat[J]. 2018, 35(2): 11-18. DOI： 10.12052/gdutxb.170126.

摘要

膜蒸馏水处理技术和换热网络的集成是降低能耗的有效途径

也是典型的水能关系系统. 本文针对膜蒸馏和换热网络集成的系统建立了数学模型

对比了换热网络和膜蒸馏集成前后的经济性

分析了膜蒸馏进料侧温度变化对系统经济性的影响

还对比了膜蒸馏的几种专用膜对系统的影响. 结果表明

换热网络和膜蒸馏集成后的经济性优于原换热网络系统的经济性

而且膜蒸馏进料侧温度越高

系统经济性越好; 在相同膜蒸馏进水温度下

对于相同规模的水处理系统

系统用PTFE膜的经济性优于MD020CP2N膜、GVHP膜和PVDF膜.

Abstract

The integration of membrane distillation and heat transfer network is an effective way to reduce energy consumption and also a typical water energy relation system. A mathematical model is established for the integration of membrane distillation system and heat exchange network. The integrated system is compared with the separate system to test the proposed integration system. The sensitivity analysis of membrane distillation feed water temperature and membrane specifications on the system economic performance are conducted. The results show that the integrated system is better than that of the separate system in economic performance

and the higher the feed water temperature

the better the system economy. The most economical membrane is PTFE membrane

followed by MD020CP2N membrane

GVHP membrane and PVDF membrane under the same inlet temperature and a certain scale of water treatment system.

关键词

Keywords

references

LI H M. The rational allocation of water resources shortage and utilization[J]. Water Resources and Hydropower, 2017(3): 118-124.

WANG X N, SUN C Z, ZOU W. A study on the spatial coupling relationship between water poverty and economic poverty in China[J]. Chinese Soft Science, 2011(12): 180-192.

ZHANG W L, KAN Y. A summary of progress in evaluation of water shortage in China[J]. Jilin Hydraulic Engineering, 2011(7): 36-39.

ROBERT C W. Methodology for analysis of the energy intensity of California’s water systems, and an assessment of multiple potential benefits through integrated water-energy efficiency measures [M]. Santa Barbara, CA: University of California, Environmental Studies Program, 2000.

RONNIE C, BARRY N, GARY W. Energy down the drain-The hidden costs of California’s water supply[R]. Oakland, California: Natural Resources Defense Council, 2004.

WANG P, LONG T R, LU K, et al . Study on energy consumption of urban water treatment plant[J ] . Water Supply and Sewerage, 2005(1): 93-97.

GAO X, LONG T R, GUO J S. Research progress of energy efficiency of municipal wastewater treatment[J]. Journal of Chongqing University (Natural Science Edition), 2002(6): 23.

ALVES V D, COELHOSO I M. Orange juice concentration by osmotic evaporation and membrane distillation: a comparative study[J]. Journal of Food and Engineering, 2006, 74 (1): 125-133.

GUNKO S, VERBYCH S, BRYK M, et al . Concentration of apple juice using direct contact membrane distillation[J ] . Desalination, 2006, 190 (1): 117-124.

NENE S, KAUR S, SUMOD K, et al . Membrane distillation for the concentration of raw cane-sugar syrup and membrane clarified sugarcane juice[J ] . Desalination, 2002, 147 (1): 157-160.

ALKLAIBI A M, LIOR N. Membrane-distillation desalination: status and potential[J]. Desalination, 2005, 171 (2): 111-131.

TOMASZEWSKA M, GRYTA M, MORAWSKI A W. Study on the concentration of acids by membrane distillation[J]. Journal of Membrane Science, 1995, 102 (13): 113-122.

LUO X L, HUANG X J, MAHMOUD M E H, et al . Simultaneous synthesis of utility system and heat exchange network incorporating steam condensate and boiler feedwater[J ] . Energy, 2016, 113: 875-893.

ELSAYED N A, BARRUFET M A, ELHALWAGI M M. Integration of thermal membrane distillation networks with processing facilities[J]. Industrial Engineering Chemistry Research, 2014, 53(13): 5284-5298.

SCHWANTES R, CIPOLLINA A, GROSS F, et al . Membrane distillation: Solar and wasteheat driven demonstration plants for desalination[J ] . Desalination, 2013, 323(16): 93-106.

ZHU Q N, LUO X L, CHEN Y. Complex steam turbine network optimization based on improving the evaluation index of coal consumption[J]. Journal of Guangdong University of Technology, 2017, 34(2): 74-79.

SRISURICHAN S, JIRARATANANON R, FANE A. Mass transfer mechanisms and transport resistance in direct contact membrane distillation process[J]. Journal of Membrane Science, 2006, 277(1): 186-194.

AL-OBAIDANI S, CURCIO E, MACEDONIO F, et al . Potential of membrane distillation in seawater desalination: Thermal efficiency, sensitivity study, and cost estimation[J ] . Journal of Membrane Science, 2008, 323(1): 85-98.

EL-HALWAGI MM. Sustainable design through process integration: Fundamentals and applications to industrial pollution prevention, resource conservation, and profitability enhancement[M]. Oxford, UK: Butterworth-Heinemann, 2012.

PETERS M S, TIMMERHAUS K D, WEST R E, et al. Plant design and economics for chemical engineers[M]. 5th ed. New York, McGraw Hill: [s.n.], 2003.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Ground Deformation Monitoring and Influencing Factors Analysis in Fuzhou City Based on PSI Technology

Robust Design for Artificial Noise-assisted UAV Terahertz Secure Communication

SCA-YOLO: Real-time Target Detection Based on Deformable Convolution and Context-aware Attention

A Resource Allocation Optimization Method for Multi-UAV Integrated Sensing, Computing, and Communication Towards Disaster Relief

A Study of Power Quality Regulation Strategies of Energy Storage Converters

Related Author

No data

Related Institution

No data

AI问答

⁰