SCALING ON THROTTLE PLATE OF THE WATER-WALL IN BOILER FOR ULTRA-SUPERCRITICAL UNIT AND DISPOSAL THEREOF

SHAO Tian-youHuaneng Yuhuan Power Plant

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

SCALING ON THROTTLE PLATE OF THE WATER-WALL IN BOILER FOR ULTRA-SUPERCRITICAL UNIT AND DISPOSAL THEREOF

更新时间：2025-09-28

- SCALING ON THROTTLE PLATE OF THE WATER-WALL IN BOILER FOR ULTRA-SUPERCRITICAL UNIT AND DISPOSAL THEREOF
- Thermal Power Generation Vol. 39, Issue 3, Pages: 75-77(2010)
- 作者机构：
  
  华能玉环电厂
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK223.31
- Published：2010
- 稿件说明：
移动端阅览
SHAO Tian-youHuaneng Yuhuan Power Plant. SCALING ON THROTTLE PLATE OF THE WATER-WALL IN BOILER FOR ULTRA-SUPERCRITICAL UNIT AND DISPOSAL THEREOF[J]. Thermal power generation, 2010, 39(3): 75-77.
DOI：

SHAO Tian-youHuaneng Yuhuan Power Plant. SCALING ON THROTTLE PLATE OF THE WATER-WALL IN BOILER FOR ULTRA-SUPERCRITICAL UNIT AND DISPOSAL THEREOF[J]. Thermal power generation, 2010, 39(3): 75-77. DOI：

摘要

介绍了玉环电厂超超临界1 000 MW机组锅炉水冷壁结构特点

分析水冷壁节流孔板Fe3O4结垢堵塞造成超温及爆管现象

认为热力系统中Fe含量均值的变化是事故的主要原因。对此

提出以下预防措施:(1)机组投产前进行化学清洗;(2)给水采用加氧处理方式;(3)机组运行后进行化学清洗。另外

通过加强运行中铁离子监测

锅炉停炉采用带压放水

起动时适当排污

以及对锅炉左右侧墙加装温度测点等方法

减少了锅炉爆管

提高了机组运行的安全可靠性。

Abstract

The structural features of water-wall in boilers for ultra-supercritical 1000 MW unit in Yuhuan Power Plant have been presented

the phenomenon of over-temperature and tube-burst resulted from blockage of Fe3O4 scaling on the throttle plate of water-wall being analysed.It is believed that the cause leading to accident is the average value variation of iron content in the thermodynamic system

and preventive measures being put forward as in the following:(1)before putting unit into operation

chemical cleaning should be carried out;(2)the feed-water has to adopt oxygen treatment mode;(3)after operation of the unit

chemical cleaning has to be carried out.In addition

through strengthening iron ion supervision in operation

adopting water discharge under pressrue during shutdown of the boiler

and suitable blow-down during strart-up

as well as additionally installing temperature-measuring points on left and right wall of the boiler etc.

tube-burst in the boiler has been decreased

enhancing safety and reliability of the unit.

关键词

Keywords

references

Views

162

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

STUDY ON CONSTRUCTION OF HEAT RELEASE SIGNAL FOR ULTRA-SUPERCRITICAL UNITS

Water wall temperature deviation of an ultra-supercritical 1 000 MW unit boiler: analysis and countermeasures

Computational analysis on hydrodynamic characteristics and flow instability of an ultra supercritical 1 000 MW double-reheat unit boiler

Research on coupling calculation method of combustion and hydrodynamics for water walls in ultra-supercritical double-reheat boilers

Experimental investigation on two-phase flow instability of ultra supercritical pressure boiler with spirally water wall tubes

Related Author

SUN Qun-li

LI Jia-chuan

WANG Zhao

MA Yu-miao College of Energy and Power Engineering

ZHANG Shihong

LIU Zhengqiang

NIE Xin

YANG Dong

Related Institution

College of Energy and Power Engineering, North China Electric Power University

国家电投集团河南电力有限公司技术信息中心

国家电投集团河南电力有限公司平顶山发电分公司

西安交通大学动力工程多相流国家重点实验室

西安热工研究院有限公司

AI问答

⁰