Influence of cancelling bypass duct on wet FGD system and countermeasures thereof

SHAN Zixin Huaneng Nantong Power Plant

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Influence of cancelling bypass duct on wet FGD system and countermeasures thereof

更新时间：2025-09-28

- Influence of cancelling bypass duct on wet FGD system and countermeasures thereof
- Thermal Power Generation Vol. 42, Issue 3, Pages: 92-94(2013)
- 作者机构：
  
  华能南通电厂
- 作者简介：
- 基金信息：
- DOI：
  CLC： X701.3
- Published：2013
- 稿件说明：
移动端阅览
SHAN Zixin Huaneng Nantong Power Plant. Influence of cancelling bypass duct on wet FGD system and countermeasures thereof[J]. Thermal power generation, 2013, 42(3): 92-94.
DOI：

SHAN Zixin Huaneng Nantong Power Plant. Influence of cancelling bypass duct on wet FGD system and countermeasures thereof[J]. Thermal power generation, 2013, 42(3): 92-94. DOI：

摘要

分析了燃煤机组脱硫系统取消旁路烟道对静电除尘器、脱硫增压风机、气气换热器(GGH)、脱硫吸收塔等设备的影响

并以某350MW机组为例

通过试验确定了湿法烟气脱硫系统取消旁路烟道后应采取的应对措施为:在送风机、引风机起动时增加增压风机运行、脱硫系统进、出口挡板收到开信号;单侧送引风机跳闸后

应联跳增压风机

机组RB工况下可以稳定在50%负荷运行;所有送引风机跳闸后

联跳增压风机;增压风机润滑油系统故障后

联跳增压风机、锅炉MFT;建议取消增压风机

对2台引风机进行增容改造;更换GGH换热原件

减小脱硫系统阻力等。

Abstract

The influence of cancelling bypass duct on such equipments as electrostatic precipitator

desulfurization booster fan

gas-gas heat exchanger(GGH) and desulfurization absorption tower was presented.Taking a 350 MW unit in Huanneng Nantong Power Plant as an example

through some relative experiments

the corresponding countermeasures that must be carried out after cancelling the bypass duct were determined.Such as

the desulfurization booster fans should be put into service and the baffle plate at inlet and outlet of the FGD system should receive the opening signal when the forced and induced draft fans started;after tripping of the induced and forced draft fans in one side

the booster fans should be intertripped

and the unit can be stabilized at 50% load to run under RB condition;if all the induced and draft fans tripped

intertrip the booster.If a fault occurred in the booster fan lubricating system

intertrip the booster fans and the boiler MFT.To overcome the resistance of the whole air and gas system

the booster fans were suggested to be cancelled

and the capacity-increasing transformation should be conducted on the two induced draft fans.

关键词

Keywords

references

Views

203

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Countermeasures for accident trip of booster fans

Survey on operation conditions of desulfurization facilities in coal-fired units

Experiment on water balance of the carbon capture system using chemical absorption method in coal-fired power plants

WET FLUE GAS DESULFURATION TECHNOLOGY WITHOUT BOOSTER FAN FOR 135MW UNIT

COMPARISON BETWEEN SCHEME OF ONE BOILER WITH ONE ABSORPTION TOWER AND THAT OF TWO BOILERS WITH ONE TOWER IN DESULFURATION PROJECTS FOR 300 MW COALFIRED UNIT

Related Author

SHEN Henan

NIU Shusen

YIN Bingyi

ZHANG Zhixue

ZHU Yue

ZHANG Yang

QIAN Xuyue

DU Zhen

Related Institution

Huadian Weifang Power Generation Co., Ltd

Huadian Electric Power Research Institute

Zhejiang Huanke Environmental Consulting Co., Ltd

National Energy Group Science and Technology Research Institute Co., Ltd

Zhejiang University Qingshanhu Energy Research Base

AI问答

⁰