Performance optimization and maximum denitration efficiency analysis for SCR-DeNO<sub>x</sub> power plants

FANG Zhaojun; JIN Lipeng; SONG Yubao; ZHAO Junwu; WANG Lele

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Performance optimization and maximum denitration efficiency analysis for SCR-DeNO_x power plants

更新时间：2025-09-28

- Performance optimization and maximum denitration efficiency analysis for SCR-DeNO_x power plants
- Thermal Power Generation Vol. 43, Issue 7, Pages: 157-160(2014)
- 作者机构：
  
  西安热工研究院有限公司苏州分公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： X773
- Published：2014
- 稿件说明：
移动端阅览
FANG Zhaojun, JIN Lipeng, SONG Yubao, et al. Performance optimization and maximum denitration efficiency analysis for SCR-DeNO_x power plants[J]. Thermal power generation, 2014, 43(7): 157-160.
DOI：

FANG Zhaojun, JIN Lipeng, SONG Yubao, et al. Performance optimization and maximum denitration efficiency analysis for SCR-DeNO_x power plants[J]. Thermal power generation, 2014, 43(7): 157-160. DOI：

摘要

分析了目前国内发电机组选择性催化还原技术(SCR)脱硝系统喷氨不均匀的原因

通过对2个机组SCR系统进行喷氨格栅(AIG)优化调整

得到保证氨逃逸值合格时的最大脱硝效率。试验结果表明

AIG优化调整后

脱硝效率为50%时

反应器A侧和B侧出口NOx浓度分布的相对标准偏差分别由31.59%、40.44%下降至9.25%、8.97%;脱硝效率为74.3%时

出口NOx浓度分布相对标准偏差仍可达到9.89%、10.75%。在催化剂投运16 000h后进行的最大脱硝效率试验结果显示

机组600MW负荷时最大脱硝效率由投运初期的87%降低到75%

降低约12%。

Abstract

Reason analysis for nonuniform ammonia spraying in SCR system of domestic power plants at present was carried out.By optimization and regulation for ammonia-injection-grid(AIG)of the SCR systems in two power units

the maximum denitration efficiency which can ensure the qualified ammonia escaping value was obtained.The experimental results show that:after the AIG was optimized

with the denitration efficiency of 50%

the relative standard deviation of NOxconcentration at outlet of side A and side B of the reactor decreased from 31.59% and 40.44% to 9.25% and 8.97%

respectively;with the denitration efficiency of 74.3%

the relative standard deviation of NOxconcentration at outlet of side A and side B of the reactor can still reach9.89% and 10.75%.Experiment about the maximum denitration efficiency was performed after the catalyst was put into service for 16 000hours.The results show that

under 600MW load condition

the maximum denitration efficiency dropped from 87% to 75%

by about 12%.

关键词

Keywords

references

Views

606

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

SNCR denitrification technology for a 600 t/d MSW incinerator

Formation mechanism and influencing factors of ammonium bisulfate during the selective catalytic reduction process

Deactivation of vanadium and titanium based SCR catalyst used in coal-fired power plants

Reason analysis for deactivation of commercial SCR de-NO_x catalyst and its regeneration

Regeneration of K poisoned commercial SCR catalyst by acid washing

Related Author

CHEN Zhenchao2 1.Zhejiang Electric Power Test and Research Institute

CAI Jiecong1

GUO Meng

MA Shuangchen

SONG Huihui

CHEN Gongda

YANG Jiehong

ZANG Bin

Related Institution

Department of Energy Engineering, Zhejiang University

Zhejiang Electric Power Test and Research Institute

College of Environmental Science and Engineering, North China Electric Power University

Guangdong Provincial Key Laboratory of Atmospheric Environment and Pollution Control

School of Environmental Science and Engineering, South China University of Technology

AI问答

⁰

Performance optimization and maximum denitration efficiency analysis for SCR-DeNOx power plants

DOI：

摘要

Abstract

关键词

Keywords

references

Performance optimization and maximum denitration efficiency analysis for SCR-DeNO_x power plants