Retrofit on low NO<sub>x</sub> combustion system of a 600MW unit boiler

HU Zhihong; LI Degong; SHAO Hongjun; DONG Xinguang; HAO Weidong

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Retrofit on low NO_x combustion system of a 600MW unit boiler

更新时间：2025-09-28

- Retrofit on low NO_x combustion system of a 600MW unit boiler
- Thermal Power Generation Vol. 43, Issue 4, Pages: 131-134(2014)
- 作者机构：
  
  1. 山东电力研究院
  2. 华电国际邹县发电厂
  3. 华能沾化热电有限公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK227.1
- Published：2014
- 稿件说明：
移动端阅览
HU Zhihong, LI Degong, SHAO Hongjun, et al. Retrofit on low NO_x combustion system of a 600MW unit boiler[J]. Thermal power generation, 2014, 43(4): 131-134.
DOI：

HU Zhihong, LI Degong, SHAO Hongjun, et al. Retrofit on low NO_x combustion system of a 600MW unit boiler[J]. Thermal power generation, 2014, 43(4): 131-134. DOI：

摘要

为降低NOx排放浓度

通过更换低氮燃烧器

增加燃尽风喷嘴

采用分级燃烧技术对一台600 MW对冲燃烧锅炉进行了低氮燃烧改造

使NOx排放浓度由750~900mg/m3降低到350mg/m3以下

同时锅炉飞灰含碳量没有明显变化。改造后在燃尽风全关的情况下NOx排放浓度即可降低40%

且随燃尽风量增大NOx排放浓度继续降低。针对改造后过热器减温水量明显增加问题

提出了采用部分低温过热器置换为省煤器的方案

以降低减温水流量。

Abstract

To reduce the NOxemission

transformation on a 600MW unit opposed firing boiler was performed

by replacing the low NOxburners

adding overfire air(OFA)nozzles and adopting airstaged combustion technology.After the retrofit

the NOxemission decreased from 750-900mg/m3 to lower than 350 mg/m3 and the spray water flow rate of super-heater increased

but the unburned carbon in fly ash had nearly no change.The NOxemission decreased by 40%even the OFA dampers were fully closed

and it kept on decreasing with the increasing OFA. To reduce the significantly increased spray water flow rate

suggestion that parts of the lowertemperature superheater pipes be replaced by economizer pipes was proposed.

关键词

Keywords

references

Views

296

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

APPLICATION OF NODE FUNCTION ZONE IN LOW NO_x BURNER TECHNOLOGY FOR COAL-FIRED BOILERS

High temperature corrosion in wall-firing boiler:reason analysis and treatment

Design scheme and engineering application of capacity upgrading and low NO_x combustion retrofitting for gas boilers

Adaptive genetic algorithm based low NO_x combustion modeling and optimization for boilers

Operation adjustment for high temperature corrosion in water wall of supercritical opposed firing boiler

Related Author

YAN Weiping2 1.Yantai Longyuan Electric Power Technology Co Ltd

ZHANG Xiaoyong1

CUI Jinlei1

OU Zongxian1

LI Ming1

CHEN Yiyang

CHEN Minsheng

LIAO Xiaochun

Related Institution

College of Energy and Power Engineering, North China Electric Power University

Yantai Longyuan Electric Power Technology Co., Ltd

Guangdong Yuedian Jinghai Power Generation Co., Ltd

Xi'an Thermal Power Research Institute Co., Ltd

Shanghai Zhongyi Petrochemical Engineering Co., Ltd

AI问答

⁰

Retrofit on low NOx combustion system of a 600MW unit boiler

DOI：

摘要

Abstract

关键词

Keywords

references

Retrofit on low NO_x combustion system of a 600MW unit boiler