Numerical simulation on air flow distribution characteristics in boiler secondary-air-box

FAN Qingwei; ZHANG Fan; LIU Dingpo; YANG Peijun

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Numerical simulation on air flow distribution characteristics in boiler secondary-air-box

更新时间：2025-09-28

- Numerical simulation on air flow distribution characteristics in boiler secondary-air-box
- Thermal Power Generation Vol. 43, Issue 5, Pages: 87-90(2014)
- 作者机构：
  
  1. 西安热工研究院有限公司
  2. 华能平凉发电有限责任公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK223.23
- Published：2014
- 稿件说明：
移动端阅览
FAN Qingwei, ZHANG Fan, LIU Dingpo, et al. Numerical simulation on air flow distribution characteristics in boiler secondary-air-box[J]. Thermal power generation, 2014, 43(5): 87-90.
DOI：

FAN Qingwei, ZHANG Fan, LIU Dingpo, et al. Numerical simulation on air flow distribution characteristics in boiler secondary-air-box[J]. Thermal power generation, 2014, 43(5): 87-90. DOI：

摘要

以某电厂600MW旋流燃烧器锅炉二次风箱为例

通过数值模拟的方法

对二次风箱内部各旋流燃烧器之间的流量分配及流动特性进行了研究。结果表明:两侧燃烧器的流量低于中间燃烧器的流量

流量偏差在6%~10%范围内变化

其迎风侧出口的流速比背风侧低10m/s左右;通过调整5只燃烧器的二次风门开度

研究提高炉膛两侧燃烧器风量的燃烧优化调整方案

其模拟结果与现场试验结果一致。

Abstract

Taking the secondary-air-box of a 600 MW unit boiler equipped with swirl burners as the example

numerical simulation was conducted to investigate the air distribution and flow characteristics among each burner inside the secondary-air-box.The results show that

the flow rates of side burners were lower than that of the middle one

but the deviation was just within 6%-8%. At the burner's outlet section

air velocity from the facing air side was 10m/s lower than that from the back air side.By adjusting the secondary air door's opening degree of the five burners

the combustion optimization scheme that can increase the side burner'air flow was obtained.The simulation results agreed well with the field test results.

关键词

Keywords

references

Views

197

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of closing-to-wall air on flow characteristics of a boiler's secondaryair-box: numerical simulation

CAUSES LEADING TO SLAGGING IN FURNACE OF TANGENTIAL FIRING PULVERIZED COAL BOILER AND PREVENTIVE MEASURES THEREOF

RETROFITTING OF AUXILIARY VALVE FOR SOLENOID BLOWOUT VALVES

STUDY ON TEMPERATURE FIELD MEASUREMENT IN FURNACE AND COMBUSTION DIAGNOSIS METHOD BASED ON DIGITAL IMAGE PROCESSING AND NEURAL NETWORK

STUDY ON SCHEME OF PREVENTING A 200T/H COALFIRING BOILER FROM SLAGGING PROBLEMS

Related Author

ZHANG Hongtao

GUAN Jian

LIU Ruimei

HU Qing

YANG Weijuan

WANG Zhihua

QIU Lichun

HU Min

Related Institution

State Key Laboratory of Clean Energy Utilization, Zhejiang University

Zhejiang Zhejiang Energy Technology Research Institute Co., Ltd

Shajiao C Power Plant

Guangdong Yuedian Group Co., Ltd.

AI问答

⁰