Experimental study on sulfite oxidation inhibition by basic aluminum sulfate desorption desulfurization method

WEN Gao; WU Fucai; ZHANG Shufeng; ZHANG Zijing; MA Minghui; WANG Yongxin

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Experimental study on sulfite oxidation inhibition by basic aluminum sulfate desorption desulfurization method

更新时间：2025-09-28

- Experimental study on sulfite oxidation inhibition by basic aluminum sulfate desorption desulfurization method
- Thermal Power Generation Vol. 44, Issue 7, Pages: 101-106(2015)
- 作者机构：
  
  内蒙古工业大学能源与动力工程学院
- 作者简介：
- 基金信息：
- DOI：
  CLC： X701.3
- Published：2015
- 稿件说明：
移动端阅览
WEN Gao, WU Fucai, ZHANG Shufeng, et al. Experimental study on sulfite oxidation inhibition by basic aluminum sulfate desorption desulfurization method[J]. Thermal power generation, 2015, 44(7): 101-106.
DOI：

WEN Gao, WU Fucai, ZHANG Shufeng, et al. Experimental study on sulfite oxidation inhibition by basic aluminum sulfate desorption desulfurization method[J]. Thermal power generation, 2015, 44(7): 101-106. DOI：

摘要

为了研究抑制石灰石-石膏湿法烟气脱硫中SO2-3氧化为SO2-4的不利副反应

配制了铝质量浓度为30g/L、碱度为26%的碱式硫酸铝溶液

分别进行不添加阻氧剂(空白)、添加2种阻氧剂(对苯二酚、乙醇)的SO2吸收及解吸效应试验

并分别采用间接碘量法和EDTA滴定法对溶液中的SO2-3和SO2-4浓度进行测定。试验结果表明:添加对苯二酚或乙醇均对SO2-3氧化为SO2-4具有抑制作用;添加对苯二酚的最佳浓度约为4mmol/L

SO2-3的氧化量较空白试验减少54%以上;添加乙醇的最佳浓度约为7 mmol/L

SO2-3的氧化量较空白试验减少63%以上;添加对苯二酚与乙醇均具有提高SO2解吸率效应

与空白试验相比

添加4mmol/L对苯二酚或7mmol/L乙醇时

SO2解吸率至少提高15%;就抑制氧化效应而言

添加乙醇的效果更好。

Abstract

To inhibit deputy reaction of SO2-3oxidized into SO2-4during the process of limestone-gypsum wet flue-gas desulfurization

the basic aluminum sulfate solution with aluminum content of 30g/L and alkalinity of 26% was prepared to carry out desulfurization tests.Two antioxidants

hydroquinone and ethanol

were added into the basic aluminum sulfate solution to prevent the SO2-3from being oxidized to SO2-4and to improve the SO2 desorption rate.The blank test was also conducted to provide a reference.The concentrations of SO2-3and SO2-4in the solution were measured by indirect iodimetry and EDTA titration method.The results show that

both the hydroquinone and the ethanol have an inhibition effect on SO2-3oxidation to SO2-4.The optimal hydroquinone concentration is about 4mmol/L

the reduced oxidatized SO2-3amount is about 54% higher than that in the blank test.The optimal ethanol concentration is about 7mmol/L

the reduced oxidatized SO2-3amount is about 63 % t higher than that in the blank test.Adding hydroquinone and ethanol can both improve the SO2 desorption rate.Compared with the blank test

adding 4mmol/L hydroquinone or 7mmol/L ethanol

the SO2 desorption rate can be increased by at least 15%.If only considering the effect of inhibition oxidation

adding ethanol is better.

关键词

Keywords

references

Views

192

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental study on catalyzed oxidation of S(Ⅳ) by ferrous and manganese ion in basic aluminum sulfate desorption desulfurization method

Economic research on desulfurization and denitration for a supercritical 350 MW circulating fluidized bed boiler

Ultra-low emission reform and its influence on the plant’s electricity supply cost

Mercury removal technology for coal-fired flue gas: research progress

Related Author

WANG Yongxin

WEN Gao

ZHAO Shuang

ZHANG Zijing

WANG Lin

GAO Jihui

CHE Hongwei

JING Xinjing

Related Institution

Langfang Thermal Power Plant,Guodian North China Electric Power Co.,Ltd.

School of Energy and Power Engineering ,Inner Mongolia University of Technology

School of Energy Science and Engineering, Harbin Institute of Technology

Xi’an Thermal Power Research Institute Co., Ltd.

Shenhua Guoneng (Shendong Power) Group

AI问答

⁰