Experimental study on additives applied to against slagging of Zhundong coal

LI Yuhang; ZHANG Xilai; ZHANG Sen; YAO Wei

English Version Reader LoginJournal Login

您当前的位置：

首页 >

文章列表页 >

Experimental study on additives applied to against slagging of Zhundong coal

更新时间：2025-09-28

- Experimental study on additives applied to against slagging of Zhundong coal
- Thermal Power Generation Vol. 46, Issue 9, Pages: 135-140(2017)
- 作者机构：
  
  西安热工研究院有限公司
- 作者简介：
- 基金信息：
- DOI：
  CLC： TK227.2
- Published：2017
- 稿件说明：
移动端阅览
LI Yuhang, ZHANG Xilai, ZHANG Sen, et al. Experimental study on additives applied to against slagging of Zhundong coal[J]. Thermal power generation, 2017, 46(9): 135-140.
DOI：

LI Yuhang, ZHANG Xilai, ZHANG Sen, et al. Experimental study on additives applied to against slagging of Zhundong coal[J]. Thermal power generation, 2017, 46(9): 135-140. DOI：

摘要

针对锅炉燃用新疆准东高钠煤存在严重的结渣问题

本文通过一维火焰炉模拟实际燃烧环境

试验研究了多种添加剂的防结渣效果

并对其防结渣机理进行了分析。试验结果表明:试验所用的高岭土、黏土类矿物对缓解结渣有较好的效果

试验样品中添加剂添加比例达到3%以上时防结渣效果更明显;添加剂起作用的前提是将煤灰中钠、钙、铁等元素质量分数降低到合理水平

尤其是将煤灰中Na_2O质量分数降低到3%以下

且钙、铁元素质量分数不大幅增加;添加剂加入后煤灰中的硅铝比对防结渣也起重要作用

合理的硅铝比有利于使低熔点的钠、钾、钙等碱/碱土金属化合物形成熔点相对较高的硅铝酸盐

单纯提高煤灰中Al_2O_3质量分数防结渣效果不明显。

Abstract

To solve the serious coking and contamination problems occurred on heating surface of utility boilers firing Xinjiang Zhundong coal

a one-dimensional furnace was used to simulate the actual combustion environment and the anti-slagging effects of several additives were experimentally investigated.Moreover

the mechanism against slagging was also analyzed.The results show that

the kaolin and clay have better anti-slagging effect.There are two additives having great effect in against slagging and the proportion of practical application in utility boilers shall not be less than 3%.By appearance comparison and phase analysis of slag

it is found that the additives act when the content of Na

Ca and Fe is controlled in a reasonable level

especially the content of Na_2O is declined below 3% and there is no obvious increase in that of Ca and Fe.In addition

the SiO_2/Al_2O_3 ratio in coal ash with additives plays an important role in against slagging.A rational SiO_2/Al_2O_3 ratio helps alkali/alkaline metal compounds with low melting point to form high-melting-point aluminosilicate.Only increasing mass fraction of Al_2O_3 has no obvious effect on anti-slagging.

关键词

Keywords

references

Views

183

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental study on influence of kaolin on slagging characteristics of Zhundong coal during combustion

STUDY ON PROPERTIES OF ZHUNDONG COAL IN XINJIANG REGION AND TYPE-SELECTION FOR BOILERS BURNING THIS COAL SORT

Effect of temperature and silicon additives on occurrence and transformation characteristics of alkali metal in Zhundong coal

Experiments about co-firing shale with Zhundong coal in a 100 MW unit boiler

Evaluation of fusion characteristics of modified fly ash when used as slagging inhibitor for high alkali coal in Zhundong area

Related Author

CAO Peiqing

ZHANG Xilai

BAI Yang

WANG Guifang

ZHAO Yonggang

YAO Wei

YANG Zhongcan

LIU Jiali

Related Institution

Shenhua Guoshen Group Technology Research Institute

Key Laboratory of Thermal Flow Science and Engineering, Ministry of Education, Xi'an Jiaotong University

Huadian Electric Power Research Institute

Xinlian Coal Chemical Industry and Trade Co., Ltd

Key Laboratory of Clean Coal Conversion and Chemical Processes Autonomous Region, Xinjiang University

AI问答

⁰